Академический Документы
Профессиональный Документы
Культура Документы
Maksud garam
7
UNIT
SALT / GARAM
Solubility Qualitative analysis
Uses in daily life
Keterlarutan Analisis kualitatif
Kegunaan dalam
kehidupan harian
Confirmatory test
Determining using reagent using reagent
Action of heat
Preparation Preparation formula Ujian pengesahan Ujian pengesahan
on salt
Penyediaan Penyediaan Menentukan menggunakan menggunakan
Tindakan haba
formula reagen reagen
pada garam
Reaction of acids with: Double decomposition Continuous method (a) Silver nitrate and nitric acid (a) Sodium hydroxide solution
Tindak balas asid dengan: through precipitation Kaedah berterusan for chloride ion Larutan natrium hidroksida
(a) Alkali Penguraian ganda dua Argentum nitrat dan asid (b) Aqueous ammonia
Alkali melalui pemendakan nitrik bagi ion klorida Ammonia akueus
(b) Metal oxide (b) Barium nitrate and nitric acid (c) Specific reagents
Oksida logam for sulphate ion Reagen spesifik
153
(c) Metal carbonate Barium nitrat dan asid nitrik
Karbonat logam bagi ion sulfat
(d) Metal (c) Iron(II) sulphate and
Logam sulphuric acid for nitrate ion
Ferum(II) sulfat dan asid
sulfurik bagi ion nitrat
(d) Nitric acid and lime water for
carbonate ion
Asid nitrik dan air kapur bagi
ion karbonat
Learning objective / Objektif pembelajaran 1 In food preparation Some salts decompose when they are heated:
Dalam penyediaan Sebahagian garam terurai apabila dipanaskan:
1 Synthesising salts makanan Salt ➝ metal oxide + gas
2 In agriculture Garam ➝ Oksida logam + gas
Mensintesiskan garam Dalam pertanian (Colour of residue refers to certain cation /
2 Synthesising qualitative analysis of salts 3 In medicial substances Warna baki merujuk kepada kation tertentu)
Mensintesiskan analisis kualitatif garam Dalam bahan perubatan (Gas identification refers to certain anion /
3 Practising sistematic and meticulous attitude during cation // Pengenalan gas merujuk kepada
the activity anion / kation tertentu)
Mengamalkan sikap sistematik dan teliti semasa
menjalankan aktiviti
UNIT 7
MODULE • Chemistry FORM 4
What is salt? A salt is a compound formed when the hydrogen ion in an acid is replaced with metal ion or ammonium
Apakah garam? ion. Example: Sodium chloride, copper(II) sulphate, potassium nitrate and ammonium sulphate.
Garam ialah sebatian yang terhasil apabila ion hidrogen daripada asid diganti oleh ion logam atau ion
ammonium. Contoh: natrium klorida, kuprum(II) sulfat, kalium nitrat dan ammonium sulfat.
Write the formulae of the salts in the Table of Salts below by replacing hydrogen ion in sulphuric acid, hydrochloric acid, nitric acid
and carbonic acid with metal ions or ammonium ion:
Tuliskan formula kimia garam dalam Jadual Garam berikut dengan menggantikan ion hidrogen dalam asid sulfurik, asid hidroklorik,
asid nitrik dan asid karbonik dengan ion logam atau ion ammonium:
Table of Salts / Jadual Garam
Metal ion Sulphate salt (from H2SO4) Chloride salt (from HCl) Nitrate salt (from HNO3) Carbonate salt (from H2CO3)
Ion logam Garam sulfat (dari H2SO4 ) Garam klorida (dari HCl) Garam nitrat (dari HNO3 ) Garam karbonat (dari H2CO3 )
Examples / Contoh:
Food preparation Sodium chloride, NaCl As food seasoning and food preservative in salted fish
Penyediaan makanan Natrium klorida, NaCl Sebagai perasa makanan dan pengawet makanan dalam ikan masin
Sodium benzoate (C6H5COONa) Preservative in food such as tomato sauce, oyster sauce and jam
Natrium benzoat (C6H5COONa) Pengawet dalam makanan seperti sos tomato, sos tiram dan jem
Sodium nitrate (NaNO3) Preservative in processed meat such as burger and sausages
Natrium nitrat (NaNO3) Pengawet dalam daging yang diproses seperti dalam burger dan sosej
Medical substances Calcium carbonate (CaCO3) and calcium Antacid to reduce acidity in the stomach of gastric patient
Bahan perubatan hydrogen carbonate (CaHCO3) Antasid untuk mengurangkan keasidan dalam perut pesakit gastrik
Kalsium karbonat (CaCO3) dan kalsium
hidrogen karbonat (CaHCO3)
Calcium sulphate (CaSO4) To make plaster of Paris that is used to support fractured bones
Kalsium sulfat (CaSO4) Untuk dibuat plaster Paris yang digunakan untuk menyokong tulang
yang patah
Barium sulphate, BaSO4 Enables the intestine of suspected stomach cancer patients to be seen
Barium sulfat, BaSO4 clearly in X-ray film
Membolehkan usus pesakit yang disyaki menghidapi kanser perut
dilihat dengan jelas dalam filem X-ray
Other uses Silver bromide (AgBr) To produce black and white photographic film
Kegunaan lain Argentum bromida (AgBr) Untuk menghasilkan filem fotografik hitam putih
What are the classification of salt? (i) Soluble salt / Garam terlarutkan
Apakah pengelasan bagi garam? (ii) Insoluble salt / Garam tak terlarutkan
7
State general rules of solubility for (i) All salts K+, Na+ and NH4+ are soluble.
UNIT
salt in water. Semua garam K+, Na+ dan NH4+ terlarutkan.
Nyatakan peraturan umum (ii) All nitrate salts are soluble.
keterlarutan garam dalam air. Semua garam nitrat terlarutkan.
(iii) All carbonate salts are insoluble except K2CO3, Na2CO3 and (NH4)2CO3.
Semua garam karbonat tak terlarutkan kecuali K2CO3, Na2CO3 dan (NH4)2CO3.
(iv) All sulphate salts are soluble except CaSO4, PbSO4 and BaSO4.
Semua garam sulfat terlarutkan kecuali CaSO4, PbSO4 dan BaSO4.
(v) All chloride salts are soluble except PbCl2 and AgCl.
Semua garam klorida terlarutkan kecuali PbCl2 dan AgCl.
* Based on the solubility of the salts in water, shade the insoluble salts in the Table of Salts in page 154.
* Berdasarkan keterlarutan garam dalam air, lorekkan garam tak terlarutkan dalam Jadual Garam di
muka surat 154.
penurasan.
7
Exercise / Latihan
Choose pair of reactants that require the use of titration method or by adding excess solid.
Pilih pasangan bahan tindak balas yang memerlukan penggunaan kaedah pentitratan atau penambahan pepejal berlebihan.
Titration method By adding excess of solid reactant
Reactants
Kaedah pentitratan Dengan menambah pepejal bahan tindak balas berlebihan
Bahan tindak balas
(3 / 7) (3 / 7)
What type of reactants are needed The precipitate of insoluble salt is formed when two different solutions that contain the cation and anion of
for this method? the insoluble salt are mixed. The precipitate is then obtained by filtration.
Apakah jenis bahan tindak balas Mendakan garam tak terlarutkan terbentuk apabila dua larutan berbeza yang mengandungi kation dan
yang diperlukan untuk kaedah ini? anion garam tak terlarutkan dicampur. Mendakan diperoleh melalui penurasan.
Give the chemical equation for the Pb(NO3)2 (aq/ak) + Na2SO4 (aq/ak) ➝ PbSO4(s/p) + 2NaNO3 (aq/ak)
precipitation of lead(II) sulphate.
Remark / Catatan:
Berikan persamaan kimia bagi How to deduce the correct reactants from a given insoluble salt: lead(II) sulphate.
pemendakan plumbum(II) sulfat. Bagaimana cara untuk mendeduksi bahan tindak balas daripada garam tak terlarutkan yang diberi: plumbum(II) sulfat.
Pb2+ SO42–
Nitrate of Pb2+ because all nitrate salts are soluble. Sulphate of NH4+ / Na+ / K+ because all are soluble
Nitrat Pb2+ kerana semua garam nitrat adalah terlarutkan. Sulfat NH4+ / Na+ / K+ kerana semua terlarutkan
It is advisable to suggest the reactants in which one is nitrate salt and the other one salt of ammonium / potassium /
sodium as they are always soluble.
Adalah dinasihatkan untuk mencadangkan bahan tindak balas yang mana satu daripadanya adalah garam nitrat dan
satu lagi garam ammonium / kalium / natrium kerana ia sentiasa terlarutkan.
https://goo.gl/pRXBZ4
7
Exercise / Latihan
UNIT
Suggest the suitable reactants and write the ionic equation for the following insoluble salts:
Cadang bahan tindak balas yang sesuai dan tulis persamaan ion bagi garam tak terlarutkan berikut:
Describe the Preparation of Soluble and Insoluble Salt / Huraikan Penyediaan Garam Terlarutkan dan Garam tak Terlarutkan
1 Salts are prepared based on their solubility as shown in the flow chart below:
Garam disediakan berdasarkan keterlarutannya sebagaimana yang ditunjukkan pada carta aliran di bawah:
Salts / Garam K+, Na+, NH4+ Other than / Garam selain K+, Na+, NH4+ The salt is prepared by precipitation method
(Double decomposition reaction).
Garam ini disediakan melalui kaedah
Method I / Kaedah I Method II / Kaedah II pemendakan. (Tindak balas penguraian ganda
dua)
The salt is prepared by titration method of acid and alkali The salt is prepared by reacting acid with insoluble metal/metal oxide/metal carbonate: – Mix two solutions containing cations and
using an indicator. Garam ini disediakan melalui tindak balas antara asid dengan logam/oksida logam/ anions of insoluble salts.
Garam ini disediakan melalui kaedah pentitratan di antara karbonat logam yang tak larut: Campur dua larutan yang mengandungi kation
asid dan alkali dengan menggunakan penunjuk. – Acid + Metal Salt + Hydrogen (Displacement reaction) dan anion garam tak terlarutkan.
Asid + Logam Garam + Hidrogen (Tindak balas penyesaran) – Stir with glass rod.
158
– Acid + Alkali Salt + Water
(Neutralisation Reaction) – Acid + Metal oxide Salt + Water (Neutralisation reaction) Kacau dengan rod kaca.
Asid + Alkali Garam + Air Asid + Oksida logam Garam + Air (Tindak balas peneutralan) – Filter using filter funnel.
(Tindak balas Peneutralan) – Acid + Metal carbonate Salt + Water + Carbon dioxide Turas dengan corong turas.
Asid + Karbonat logam Garam + Air + Karbon dioksida – Rinse the residue with distilled water.
Bilas baki dengan air suling.
– Dry the residue by pressing it between filter
papers.
Keringkan baki dengan menekankan antara
– A titration is conducted to determine the volume of acid – Add metal/metal oxide/metal carbonate powder until excess into a fixed volume kertas turas.
needed to neutralise a fixed volume of an alkali with the of the heated acid.
aid of an indicator. Tambah serbuk logam/oksida logam/karbonat logam ke dalam isi padu tetap asid
Pentitratan dijalankan dengan menentukan isi padu yang dihangatkan sehingga berlebihan.
asid yang diperlukan untuk meneutralkan alkali yang – Filter the mixture to remove the excess metal/metal oxide/metal carbonate.
isi padunya sudah ditetapkan dengan menggunakan Turas campuran tersebut untuk mengeluarkan pepejal logam/oksida logam/
penunjuk. karbonat logam yang berlebihan.
– The same volume of acid is then added to the same
volume of alkali without any indicator to obtain pure and
neutral salt solution. – Evaporate the filtrate until it becomes a saturated solution. / Sejatkan hasil turasan hingga larutan tepu.
Isi padu asid yang sama kemudiannya ditambah – Dip in a glass rod, if crystals are formed, the solution is saturated.
kepada isi padu alkali yang sama tanpa penunjuk untuk
Celupkan dengan rod kaca, jika hablur terbentuk dengan serta merta, larutan adalah tepu.
mendapatkan garam yang tulen dan neutral.
– Cooled at room temperature / Biarkan sejuk pada suhu bilik.
– Filter and dry the salt crystals by pressing them between filter papers.
Turas dan keringkan hablur garam dengan menekan antara kertas turas.
2 Steps to Prepare Soluble Salt / Langkah Penyediaan Garam Terlarutkan
Method I: / Kaedah I:
Method II: / Kaedah II: Soluble salt of K+, Na+ and NH4+
Soluble salt except K+, Na+ and NH4+ / Garam terlarutkan selain K+, Na+ dan NH4+ Garam terlarutkan K+, Na+ dan NH4+
• Stir themixture with a glass rod . • The salt solution is poured into • Measure and pour 50 cm3 of
• Filter the mixture to separate excess
Kacau campuran dengan menggunakan metal/metal oxide/metal carbonate with evaporating dish . 1 mol dm–3 of any alkali
rod kaca . the salt solution . Larutan garam dituangkan dalam into a conical flask. Add a few
campuran mangkuk penyejat drops of phenolphthalein.
• Add metal / metal oxide / metal carbonate Turas tersebut untuk .
powder to the acid until excess . mengasingkan bahan berlebihan iaitu • Evaporate the salt solution until Sukat dan tuangkan 50 cm3
➋ ➌ saturated solution sebarang alkali berkepekatan
Tambah serbuk logam / oksida logam logam/oksida logam/karbonat logam is formed.
larutan tepu 1 mol dm–3 ke dalam
/ karbonat logam kepada asid sehingga dengan larutan garam . Sejatkan larutan sehingga
berlebihan terbentuk. ➀ kelalang kon. Tambah
. The residue is
metal /metal oxide beberapa titis fenolftalein.
Saturated
Excess of metal/ /metal carbonate • 1 mol dm–3 of any acid is
. salt solutions
metal oxide/ logam/ titrated to the alkali until
Baki adalah Larutan garam neutral by using an indicator.
metal carbonate logam oksida/ tepu The volume of acid used is
Logam/oksida logam/ logam karbonat . Heat recorded.
karbonat logam
Panaskan Sebarang asid 1 mol dm–3
yang berlebihan. The filtrate is salt solution.
dititratkan kepada alkali
159
Heat Hasil turasan ialah
sehingga neutral menggunakan
Panaskan larutan garam ➍
. ➁ penunjuk. Isi padu asid yang
digunakan dicatat.
➊ salts crystals • Repeat the titration without the
• Cool it at room temperature until are
• Measure and pour 100 cm3 of 1 mol dm–3 of any acid and pour into a formed. indicator to get pure and neutral
beaker. Sejukkan pada suhu bilik sehingga hablur garam terbentuk. salt solution.
100 1 Ulang titratan tanpa penunjuk
Sukat dan tuangkan cm3 sebarang asid berkepekatan mol dm–3 Salt crystals untuk mendapatkan larutan
dan tuangkan ke dalam bikar. Hablur garam tulen dan
• Add metal/metal oxide/ metal carbonate powder into the acid and heat gently . garam yang
Tambahkan serbuk logam/ oksida logam/ karbonat logam pada isi padu asid ➎ ➂ neutral .
UNIT 7
MODULE • Chemistry FORM 4
How are the soluble salts purified – The insoluble impurities in soluble salt solution are removed by filtration whereas the soluble are
by recrystallisation? removed by recrystallisation. / Bendasing tak terlarutkan dalam larutan garam terlarutkan ditapis keluar
Bagaimanakah garam terlarutkan melalui penurasan manakala terlarutkan dikeluarkan secara penghabluran semula.
ditulenkan oleh penghabluran – Steps in recrystallisation process includes: / Langkah proses penghabluran semula termasuklah:
semula? (i) The soluble salt is dissolved in a suitable solvent, usually water.
Garam terlarutkan dilarutkan dalam pelarut yang sesuai, biasanya air.
(ii) The aqueous solution is then heated to evaporate until the solution saturated.
Larutan akueus kemudiannya dipanaskan untuk menyejat sehingga larutan menjadi tepu.
(iii) When the hot saturated solution is allowed to cool, the salt reappears as pure crystals, leaving
behind the impurities in the solvent.
Apabila larutan tepu yang panas dibiarkan untuk menyejuk, garam muncul semula sebagai hablur
tulen, meninggalkan bendasing dalam pelarut.
(iv) The crystals are obtained as a residue through filtration.
Hablur diperoleh sebagai baki melalui penurasan.
1 Measure and pour 100 cm3 2 Measure and pour 100 cm3
of 1 mol dm–3 of aqueous of 1 mol dm–3 of aqueous
solution contains X m+ cation into a solution contains Yn– anion into another
beaker. beaker.
Sukat dan tuangkan 100 cm3 Sukat dan tuangkan 100 cm3
larutan berkepekatan 1 mol dm–3 larutan berkepekatan 1 mol dm–3
mengandungi kation Xm+ ke dalam mengandungi anion Yn– ke dalam bikar
bikar. yang lain.
UNIT
Exercise / Latihan
1 Complete the following table by writing “S” for soluble salts and “IS” for insoluble salts. Write all the possible chemical
equations to prepare soluble salts and two chemical equations for insoluble salts.
Lengkapkan jadual berikut dengan menulis “L” bagi garam terlarutkan dan “TL” bagi garam tak terlarutkan. Tuliskan semua
persamaan kimia dalam penyediaan garam terlarutkan dan dua persamaan kimia bagi garam tak terlarutkan.
Zn + 2HCl ZnCl2 + H2
Zinc chloride S
ZnCO3 + 2HCl ZnCl2 + CO2 + H2O
Zink klorida L
ZnO + 2HCl ZnCl2 + H2O
Sodium nitrate S
NaOH + HNO3 NaNO3 + H2O
Natrium nitrat L
7
UNIT
Mg + 2HNO3 Mg(NO3)2 + H2
Magnesium nitrate S
MgO + 2HNO3 Mg(NO3)2 + H2O
Magnesium nitrat L
MgCO3 + 2HNO3 Mg(NO3)2 + CO2 + H2O
Potassium chloride S
KOH + HCl KCl + H2O
Kalium klorida L
2 The diagram below shows the set-up of apparatus to prepare soluble salt Y.
Rajah di bawah menunjukkan susunan radas bagi menyediakan garam terlarutkan Y.
Nitric acid
Asid nitrik
Phenolphthalein is used as an indicator in a titration between nitric acid and potassium hydroxide solution. 25 cm3 of nitric acid
completely neutralises 25 cm3 of 1 mol dm–3 potassium hydroxide solution. The experiment is repeated by reacting 25 cm3 of
1 mol dm–3 potassium hydroxide solution with 25 cm3 nitric acid without phenolphthalein. Salt Y is formed from the reaction.
Fenolftalein digunakan sebagai penunjuk dalam pentitratan antara asid nitrik dengan larutan kalium hidroksida. 25 cm3 asid
nitrik meneutralkan 25 cm3 larutan kalium hidroksida 1 mol dm–3. Eksperimen ini diulang dengan menindakbalaskan 25 cm3
larutan kalium hidroksida 1 mol dm–3 dengan 25 cm3 asid nitrik tanpa fenolftalein. Garam Y terbentuk daripada tindak balas ini.
(a) Name salt Y. / Nyatakan nama garam Y.
Potassium nitrate / Kalium nitrat
(b) Write a balanced equation for the reaction that occurs. / Tuliskan persamaan seimbang bagi tindak balas yang berlaku.
HNO3 + KOH KNO3 + H2O
(c) Calculate the concentration of nitric acid. / Hitungkan kepekatan asid nitrik tersebut.
25
Number of moles of KOH / Bilangan mol bagi KOH = 1 × = 0.025 mol
1 000
From the equation, / Dari persamaan kimia, 1 mol KOH : 1 mol HNO3
0.025 mol KOH : 0.025 mol HNO3
Concentration of HNO3, M / Kepekatan HNO3, M
25
0.025 = M ×
1 000
M = 1 mol dm–3
(d) Why the experiment is repeated without phenolphthalein? / Mengapakah eksperimen ini diulang tanpa menggunakan fenolftalein?
To get pure and neutral salt solution Y. / Untuk mendapatkan larutan garam Y yang tulen dan neutral.
(e) Describe briefly how a crystal of salt Y is obtained from the salt solution.
UNIT
Huraikan secara ringkas bagaimana hablur garam Y diperoleh daripada larutan garamnya.
The salt solution is poured into an evaporating dish. The solution is heated to evaporate the solution until one third of its
7
original volume // a saturated solution formed. The saturated solution is allowed to cool until salt crystals Y are formed.
The crystals are filtered and dried by pressing them between filter papers.
Larutan garam dituang ke dalam mangkuk penyejat. Larutan itu dipanaskan untuk menyejatkan air sehingga satu pertiga
daripada isi padu asalnya // larutan yang tepu terbentuk. Larutan tepu dibiarkan sejuk sehingga hablur Y terbentuk. Hablur
tersebut dituras dan dikeringkan dengan menekannya di antara kertas turas.
(f) Name two other salts that can be prepared with the same method.
Namakan dua garam lain yang boleh disediakan dengan kaedah yang sama.
Potassium / sodium / ammonium salt. Example: potassium nitrate, sodium sulphate.
Garam kalium / natrium / ammonium. Contoh: kalium nitrat, natrium sulfat.
(g) State the type of reaction in the preparation of the salts. / Nyatakan jenis tindak balas dalam penyediaan garam ini.
Neutralisation / Peneutralan
3 The following are the steps in preparation of dry copper(II) sulphate crystals.
Berikut adalah langkah-langkah dalam penyediaan hablur garam kuprum(II) sulfat kering.
Step I: Copper(II) oxide powder is added a little at a time with constant stirring to the heated 50 cm3 of
1 mol dm–3 sulphuric acid until some of it no longer dissolve.
Langkah I: Serbuk kuprum(II) oksida ditambahkan, sedikit demi sedikit sambil dikacau ke dalam 50 cm3 asid
sulfurik 1 mol dm-3 yang dipanaskan sehingga serbuk itu tidak boleh larut lagi.
Step III: The filtrate is poured into an evaporating dish and heated to evaporate the solution until one
third of its original.
Langkah III: Hasil turasan dipanaskan di dalam mangkuk penyejat sehingga isi padunya menjadi satu
pertiga daripada isi padu asal.
Step IV: The salt solution is allowed to cool at room temperature for the crystallisation to take place.
Langkah IV: Hasil turasan itu dibiarkan sejuk ke suhu bilik sehingga penghabluran berlaku.
Step V: The crystals formed are filtered and dried by pressing them between filter papers.
Langkah V: Hablur yang terbentuk dituraskan dan dikeringkan dengan menekannya di antara kertas turas.
(a) (i) State two observations during Step I. / Nyatakan dua pemerhatian pada Langkah I.
– Black solid dissolve / Pepejal hitam larut
– Colourless solution turns blue. / Larutan tanpa warna bertukar menjadi biru
(ii) Write a balance chemical equation for the reaction that occur in Step I.
Tuliskan persamaan kimia seimbang bagi tindak balas yang berlaku dalam Langkah I.
CuO + H2SO4 CuSO4 + H2O
(iii) State the type of reaction in the preparation of the salts.
Nyatakan jenis tindak balas yang berlaku dalam penyediaan garam.
Neutralisation / Peneutralan
(b) Why is copper(II) oxide powder added until some of it no longer dissolve in Step I?
Mengapakah serbuk kuprum(II) oksida ditambah kepada larutan tersebut sehingga ia tidak boleh melarut lagi dalam
Langkah I?
7
To make sure that all sulphuric acid has reacted. / Untuk memastikan semua asid sulfurik telah bertindak balas.
UNIT
(c) What is the purpose of heating in Step III? / Apakah tujuan pemanasan dalam Langkah III?
To evaporate the water and make the copper(II) sulphate solution to become saturated.
Untuk menyejatkan air dan menjadikan larutan kuprum(II) sulfat tepu.
(f) Draw a labelled diagram to show the set-up of apparatus used in Step II and Step III.
Lukiskan gambar rajah berlabel untuk menunjukkan susunan alat radas yang digunakan dalam Langkah II dan Langkah III.
Filter paper
Excess of copper(II)
Kertas turas Copper(II) sulphate solution
oxide
Kuprum(II) oksida Larutan kuprum(II) sulfat
berlebihan
Heat
Panaskan
Copper(II) sulphate solution
Larutan kuprum(II) sulfat
(g) Can copper powder replace copper(II) oxide in the experiment? Explain your answer.
Bolehkah serbuk kuprum digunakan untuk menggantikan kuprum(II) oksida dalam eksperimen ini? Terangkan jawapan
anda.
Cannot. Copper is less electropositive than hydrogen in the Electrochemical Series, copper cannot displace hydrogen from
the acid. / Tidak boleh. Kuprum kurang elektropositif daripada hidrogen dalam Siri Elektrokimia. Kuprum tidak dapat
menyesarkan hidrogen daripada asid.
(h) Name other substance that can replace copper(II) oxide to prepare the same salt. Write a balance chemical equation for the
reaction that occur.
Namakan bahan lain yang dapat menggantikan kuprum(II) oksida dalam penyediaan garam yang sama. Tuliskan
persamaan kimia yang seimbang bagi tindak balas yang berlaku.
Substance / Bahan : Copper(II) carbonate / Kuprum(II) karbonat
4 The diagram below shows the flow chart for the preparation of zinc carbonate and zinc sulphate through reactions I and II.
Rajah di bawah menunjukkan carta aliran bagi penyediaan garam zink karbonat dan zink sulfat melalui tindak balas I dan
tindak balas II.
Reaction I Reaction II
Zinc nitrate Tindak balas I Zinc carbonate Tindak balas II Zinc sulphate
Zink nitrat Zink karbonat Zink sulfat
(a) Based on the flow chart above, classify the above salt to soluble salt and insoluble salt.
Berdasarkan carta aliran di atas, kelaskan garam di atas kepada garam terlarutkan dan garam tak terlarutkan.
UNIT
Soluble salt / Garam terlarutkan : Zinc nitrate, zinc sulphate / Zink nitrat, zink sulfat
Insoluble salt / Garam tak terlarutkan: Zinc carbonate / Zink karbonat
7
(b) (i) State the reactant for the preparation of zinc carbonate from zinc nitrate in reaction I.
Nyatakan bahan tindak balas untuk penyediaan zink karbonat dari zink nitrat dalam tindak balas I.
Sodium carbonate solution / potassium carbonate solution / ammonium carbonate solution
Larutan natrium karbonat / larutan kalium karbonat / larutan ammonium karbonat
(iii) Describe the preparation of zinc carbonate from zinc nitrate in the laboratory through reaction I.
Huraikan penyediaan zink karbonat dari zink nitrat dalam makmal melalui tindak balas I.
50 cm3 of 1 mol dm–3 zinc nitrate solution is measured and poured into a beaker. 50 cm3 of 1 mol dm–3 sodium
carbonate solution is measured and poured into another beaker. The mixture is stirred with a glass rod and a white
solid, zinc carbonate (ZnCO3) is formed. The mixture is filtered and the residue is rinsed with distilled water. The
white precipitate is dried by pressing it between filter papers.
50 cm3 larutan zink nitrat 1 mol dm–3 disukat dan dituangkan ke dalam sebuah bikar. 50 cm3 larutan natrium karbonat
1 mol dm–3 disukat dan dituang ke dalam bikar lain. Campuran dikacau dengan rod kaca dan pepejal putih zink
karbonat (ZnCO3) terbentuk. Campuran dituras dan baki dibilas dengan air suling. Mendakan putih ditekan antara
kertas turas untuk mengeringkannya.
(c) (i) State the reactant for the preparation of zinc sulphate from zinc carbonate in reaction II.
Nyatakan bahan tindak balas bagi penyediaan zink sulfat dari zink karbonat dalam tindak balas II.
Sulphuric acid / Asid sulfurik
(ii) Describe laboratory experiment to prepare zinc sulphate from zinc carbonate through reaction II.
Huraikan eksperimen dalam makmal untuk menyediakan zink sulfat dari zink karbonat melalui tindak balas II.
50 cm3 of 1 mol dm–3 of sulphuric acid is measured and poured into a beaker and is heated. The white precipitate
from reaction I/zinc carbonate powder is added to the acid until in excess. The mixture is stirred with a glass rod.
The excess white precipitate is filtered out. The filtrate is poured into an evaporating dish. The salt solution is gently
heated until saturated. The hot saturated salt solution is allowed to cool for crystals to form. The crystals formed are
filtered and dried by pressing it between sheets of filter papers.
50 cm3 asid sulfurik 1 mol dm–3 disukat dan dituang ke dalam bikar dan dihangatkan. Mendakan putih dari tindak
balas I/serbuk zink karbonat ditambah kepada asid hingga berlebihan. Campuran dikacau dengan rod kaca.
Mendakan putih yang berlebihan dituras keluar. Hasil turasan dituangkan dalam mangkuk penyejat. Larutan garam
dipanaskan sehingga tepu. Larutan tepu yang panas disejukkan sehingga hablur terbentuk. Hablur yang terbentuk
7
dituraskan dan dikeringkan dengan menekannya antara kertas turas.
UNIT
(iii) Write the chemical equation for the reaction in (c)(ii).
Tuliskan persamaan kimia untuk tindak balas yang berlaku dalam (c)(ii).
ZnCO3 + H2SO4 ZnSO4 + H2O + CO2
Additional Questions
Soalan Tambahan
Manipulated variable / Pemboleh ubah dimanipulasikan : Volume of lead(II) nitrate solution / Isi padu larutan plumbum(II) nitrat
Height of precipitate / Tinggi mendakan
Responding variable / Pemboleh ubah bergerak balas :
Constant variable / Pemboleh ubah yang dimalarkan :
Volume and concentration of potassium chromate(VI) solution, concentration of lead(II) nitrate solution, size of test tube
Isi padu dan kepekatan larutan kalium kromat(VI), kepekatan larutan plumbum(II) nitrat, saiz tabung uji
Hypothesis / Hipotesis : When the volume of lead(II) nitrate solution increases, the height of precipitate will increase until all
potassium chromate(VI) has reacted.
Apabila isi padu larutan plumbum(II) nitrat bertambah, ketinggian mendakan akan meningkat sehingga
semua kalium kromat(VI) bertindak balas.
Apparatus / Radas : Test tubes of same size, measuring cylinder//burette, test tube rack, stopper, ruler
Tabung uji bersaiz sama, silinder penyukat//buret, rak tabung uji, penutup tabung uji, pembaris
Materials / Bahan : 0.5 mol dm of lead(II) nitrate and potassium chromate(VI) solution
–3
Larutan plumbum(II) nitrat dan kalium kromat(VI) 0.5 mol dm
-3
5 cm3 of 0.5 mol dm–3 of potassium chromate(VI) solution is poured into every test tube as shown in the following diagram:
5 cm3 larutan kalium kromat(VI) 0.5 mol dm–3 dituangkan ke dalam setiap tabung uji seperti ditunjukkan dalam rajah di bawah:
5 cm3 5 cm3 5 cm3 5 cm3 5 cm3 5 cm3 5 cm3 5 cm3
UNIT
7
1 cm3 of 0.5 mol dm–3 lead(II) nitrate solution is added to the first test tube, 2 cm3 to the second test tube and so on until 8 cm3 to
the eighth test tube as shown 1incmthe
3
2 cm3
following 3 cm3
diagram: 4 cm3 5 cm3 6 cm3 7 cm3 8 cm3
1 cm larutan plumbum(II) nitrat 0.5 mol dm ditambah ke dalam tabung uji pertama, 2 cm3 ke dalam tabung uji kedua dan
3 –3
seterusnya hingga 8 cm3 ke dalam tabung uji kelapan seperti ditunjukkan dalam rajah di bawah:
1 cm3 2 cm3 3 cm3 4 cm3 5 cm3 6 cm3 7 cm3 8 cm3
Precipitate / Mendakan
Precipitate / Mendakan
Procedure / Prosedur:
(a) Eight test tubes of same size are labelled from 1 to 8 and placed on a test tube rack.
Lapan tabung uji sama saiz dilabelkan 1 hingga 8 dan diletakkan di atas rak tabung uji.
(b) 5.00 cm3 of 0.5 mol dm-3 potassium chromate(VI) solution is measured and poured into each of the test tubes.
5.00 cm3 larutan kalium kromat(VI) 0.5 mol dm-3 disukat dan dituangkan ke dalam setiap tabung uji.
(c) 1 cm3 of 0.5 mol dm-3 lead(II) nitrate solution is added to the first test tube, 2 cm3 to the second test tube and so on until
8 cm3 to the eighth test tube.
1 cm3 larutan plumbum(II) nitrat 0.5 mol dm-3 ditambahkan ke dalam tabung uji pertama, 2 cm3 kepada tabung uji kedua dan
seterusnya hingga 8.0 cm3 kepada tabung uji kelapan.
(d) The test tubes are stoppered and shaken well. / Tabung uji ditutup dan digoncang.
(e) The test tubes are left aside for one hour on a test tube rack. / Tabung uji dibiarkan di atas rak selama satu jam.
(f) The height of precipitate in each test tube is measured. / Tinggi mendakan dalam setiap tabung uji diukur.
(g) The colour of the solution above the precipitate in each test tube is recorded.
Warna larutan di atas mendakan dalam setiap tabung uji dicatatkan.
(h) A graph of height of precipitate against volume of lead(II) nitrate solution added is plotted.
Graf tinggi mendakan melawan isi padu larutan plumbum(II) nitrat dilukis.
Result / Keputusan:
Test tube
1 2 3 4 5 6 7 8
Tabung uji
Volume of
0.5 mol dm–3 of
potassium
chromate(VI)
5.00 5.00 5.00 5.00 5.00 5.00 5.00 5.00
solution / cm3
Isi padu larutan
kalium kromat(VI)
0.5 mol dm–3 / cm3
Volume of
0.5 mol dm–3 of
lead(II) nitrate
solution / cm3 1.00 2.00 3.00 4.00 5.00 6.00 7.00 8.00
Isi padu larutan
plumbum(II) nitrat
0.5 mol dm–3 / cm3
Height of
precipitate /cm
0.5 0.8 1.2 1.6 2.0 2.0 2.0 2.0
Tinggi mendakan /
cm
Colour of solution
above precipitate Yellow Yellow Yellow Yellow Colourless Colourless Colourless Colourless
Warna larutan di Kuning Kuning Kuning Kuning Tanpa warna Tanpa warna Tanpa warna Tanpa warna
7
atas mendakan
UNIT
Chemicals in the Excess of Excess of Excess of Excess of Potassium Excess of Excess of Excess of
solution above potassium potassium potassium potassium lead(II) lead(II) lead(II)
nitrate
precipitate chromate(VI) chromate(VI) chromate(VI) chromate(VI) nitrate nitrate nitrate
Bahan kimia di formed.
and and and and Kalium and and and
dalam larutan di
potassium potassium potassium potassium potassium potassium potassium
atas mendakan nitrat
nitrate nitrate nitrate nitrate nitrate nitrate nitrate
terbentuk.
formed. formed. formed. formed. formed. formed. formed.
Kalium Kalium Kalium Kalium Plumbum(II) Plumbum(II) Plumbum(II)
kromat(VI) kromat(VI) kromat(VI) kromat(VI) nitrat yang nitrat yang nitrat yang
berlebihan berlebihan berlebihan berlebihan berlebihan berlebihan berlebihan
dan kalium dan kalium dan kalium dan kalium dan kalium dan kalium dan kalium
nitrat nitrat nitrat nitrat nitrat nitrat nitrat
terbentuk. terbentuk. terbentuk. terbentuk. terbentuk. terbentuk. terbentuk.
Ions present in the
solution above the
precipitate NO3-, K+ NO3-, K+ NO3-, K+ NO3-, K+ Pb2+, Pb2+, Pb2+,
NO3-, K+
Ion yang hadir CrO42- CrO42- CrO42- CrO42- NO3-, K+ NO3-, K+ NO3-, K+
dalam larutan di
atas mendakan
The height of precipitate in test tubes 1 to 4 • The increase in volume of lead(II) nitrate added increases the mass of precipitate formed
increases. in test tubes 1 to 4.
Tinggi mendakan dalam tabung uji 1 hingga Peningkatan isi padu plumbum(II) nitrat yang ditambah meningkatkan jisim mendakan
4 meningkat. yang terbentuk dalam tabung uji 1 hingga 4.
The solution above precipitate is yellow in potassium chromate(VI)
• There are excess of solution in test tubes 1 to 4.
test tubes 1 to 4.
Terdapat kalium kromat(VI) yang berlebihan dalam tabung uji 1 hingga 4.
Larutan di atas mendakan berwarna kuning
dalam tabung uji 1 hingga 4.
The height of precipitate remains constant in • In test tube 5, potassium chromate(VI) solution has completely reacted with lead(II)
test tubes 5 to 8. nitrate solution. All chromate(VI) ions and all lead(II) ions have reacted. The solution
Tinggi mendakan kekal tidak berubah dalam above precipitate is potassium nitrate .
tabung uji 5 hingga 8. Dalam tabung uji 5, larutan kalium kromat(VI) telah bertindak balas lengkap dengan
The solution above precipitate is colourless larutan plumbum(II) nitrat. Semua ion kromat(VI) dan ion plumbum(II) telah bertindak
in test tubes 5 to 8.
Larutan di atas mendakan adalah tanpa balas. Larutan di atas mendakan adalah .kalium nitrat .
warna dalam tabung uji 5 hingga 8. • In test tubes 6 to 8, there are excess of lead(II) ions as more lead(II) nitrate
solution is added.
Dalam tabung uji 6 hingga 8, terdapat ion plumbum(II) yang berlebihan apabila
larutan plumbum(II) nitrat berlebihan ditambah.
2 The graph below is obtained when the height of precipitate is plotted against the volume of lead(II) nitrate solution.
Lakaran graf di bawah diperoleh apabila tinggi mendakan dilukis melawan isi padu larutan plumbum(II) nitrat.
Height of precipitate (cm) / Tinggi mendakan (cm)
(a) What is the colour of lead(II) nitrate solution and potassium chromate(VI) solution?
Apakah warna larutan plumbum(II) nitrat dan kalium kromat(VI)?
Lead(II) nitrate solution / Larutan plumbum(II) nitrat : colourless / tanpa warna
Potassium chromate(VI) solution / Larutan kalium kromat(VI) : yellow / kuning
(b) (i) State the name of the precipitate formed. / Nyatakan nama mendakan yang terbentuk.
UNIT
Yellow / Kuning
(c) (i) Based on the above graph, what is the volume of lead(II) nitrate solution needed to completely react with potassium
chromate(VI) 5 cm3 of solution?
Berdasakan graf di atas, apakah isi padu larutan plumbum(II) nitrat yang diperlukan untuk bertindak balas lengkap
dengan 5 cm3 larutan kalium kromat(VI)?
5 cm3
(ii) Calculate the number of moles of lead(II) ions in 5.0 cm³ of 0.5 mol dm-3 lead (II) nitrate solution.
Hitungkan bilangan mol ion plumbum(II) yang terdapat dalam 5.0 cm³ larutan plumbum(II) nitrat 0.5 mol dm-3.
Ionisation equation of lead(II) nitrate solution: / Persamaan pengionan larutan plumbum(II) nitrat:
Pb(NO ) Pb2+ + 2NO3–
3 2
Number of moles of Pb(NO3)2 / Bilangan mol Pb(NO3)2 = 5.0 × 0.5 = 0.0025 mol
1 000
From the ionisation equation / Daripada persamaan pengionan,
1 mol Pb(NO3)2 : 1 mol Pb2+
0.0025 mol Pb(NO3)2 : 0.0025 mol Pb2+
(iii) Calculate the number of mol of chromate(VI) ions in 5.0 cm³ of 0.5 mol dm-3 potassium chromate(VI) solution.
Hitungkan bilangan mol ion kromat(VI) yang terdapat dalam 5.0 cm³ larutan kalium kromat(VI) 0.5 mol dm–3.
Ionisation equation of potassium chromate(VI) solution:
Persamaan pengionan larutan kalium kromat(VI):
K CrO 2K+ + CrO4 2-
2 4
(iv) Calculate the number of moles of chromate(VI) ions reacts completely with one mol of lead(II) ions.
Hitungkan bilangan mol ion kromat(VI) yang bertindak balas lengkap dengan satu mol ion plumbum(II).
0.0025 mol Pb2+ : reacts completely with 0.0025 mol CrO 2- 4
0.0025 mol Pb2+ : bertindak balas lengkap dengan 0.0025 mol CrO42-
1 mol Pb2+ : 1 mol CrO42-
(d) Write the ionic equation for the formation of the precipitate.
Tuliskan persamaan ion bagi pembentukan mendakan.
Pb2+ + CrO42- ➝ PbCrO4
Mass in gram
Jisim dalam gram
7
UNIT
Example / Contoh:
50 cm3 of 2 mol dm–3 sulphuric acid is added to excess of copper(II) oxide powder. Calculate the mass of copper(II) sulphate formed
in the reaction.
[Relative atomic mass: H = 1, O = 16, Cu = 64, S = 32]
50 cm3 asid sulfurik 2 mol dm–3 ditambah kepada serbuk kuprum(II) oksida berlebihan. Hitungkan jisim kuprum(II) sulfat yang
terbentuk dalam tindak balas itu.
[Jisim atom relatif: H = 1, O = 16, Cu = 64, S = 32]
Write a balanced equation M = 2 mol dm–3
Write the information from the question above the equation V = 50 cm3 ?g
Tulis persamaan seimbang CuO(aq/ak) + H2SO4 CuSO4(aq /ak) + 2H2O(I/ce)
Tulis maklumat daripada soalan di atas persamaan
Convert the given quantity into moles by using the method Number of moles of sulphuric acid / Bilangan mol asid sulfurik
shown in the chart above. 2 × 50
= 1 000
Tukar kuantiti yang diberikan kepada mol dengan menggunakan
teknik yang ditunjukkan dalam carta di atas. = 0.1 mol
Use the mole ratio of the substances involved to find the number From the equation,
of moles of other substance. Daripada persamaan,
Gunakan nisbah mol bahan yang terlibat untuk mencari bilangan 1 mol H2SO4 : 1 mol CuSO4
mol bahan lain. 0.1 mol H2SO4 : 0.1 mol CuSO4
Remark / Catatan:
The coefficient of each formula shows the number of moles of reactants react
and products formed.
Pekali untuk setiap formula menunjukkan bilangan mol bahan tindak balas dan
hasil yang terbentuk.
Convert the mole into the quantity required in the question by Mass of CuSO4 / Jisim CuSO4
using the method shown in the chart above. = 0.1 mol × [64 + 32 + (16 × 4)] g mol–1
Tukar mol kepada kuantiti yang dikehendaki oleh soalan dengan = 16 g
menggunakan kaedah yang ditunjukkan dalam carta di atas.
Exercise / Latihan
1 27.66 g of lead(II) iodide is precipitated when 2.0 mol dm–3 of aqueous lead(II) nitrate solution is added to an excess of aqueous
potassium iodide solution. Calculate the volume of aqueous lead(II) nitrate solution used.
[Relative atomic mass: I = 127, Pb = 207]
27.66 g plumbum(II) iodida termendak apabila 2.0 mol dm–3 larutan plumbum(II) nitrat akueus ditambahkan kepada larutan
kalium iodida akueus berlebihan. Hitungkan isi padu plumbum(II) nitrat yang digunakan.
[Jisim atom relatif: I = 127, Pb = 207]
M = 2 mol dm–3
V = ? cm3 27.66 g
Pb(NO3)2(aq/ak) + 2KI(aq/ak) PbI2(s/p) + 2KNO3(aq/ak)
27.66
Number of moles of PbI2 / Bilangan mol PbI2 = = 0.06 mol
(207 + 2 × 127)
From the equation / Daripada persamaan, 1 mol PbI2 : 1 mol Pb(NO3)2
0.06 mol PbI2 : 0.06 mol Pb(NO3)2
n mol 0.06 mol
Volume of Pb(NO3)2 / Isi padu Pb(NO3)2 = = = 0.03 dm3 = 30 cm3
M mol dm–3 2 mol dm–3
2 Zinc oxide powder is added to 100 cm3 of 2 mol dm–3 nitric acid to form zinc nitrate. Calculate
Serbuk zink oksida ditambahkan kepada 100 cm3 asid nitrik 2 mol dm–3 untuk membentuk zink nitrat. Hitungkan
(i) the mass of zinc oxide that has reacted.
UNIT
jisim zink nitrat yang terhasil. [Jisim atom relatif: H = 1, O = 16, N = 14, Zn = 65]
M = 2 mol dm–3
V = 100 cm3
(i) 2HNO3(aq/ak) + ZnO(s/p) Zn(NO3)2(aq/ak) + H2O(l/ce)
100 × 2
Number of moles of HNO3 / Bilangan mol HNO3 = = 0.2 mol
1 000
From the equation / Daripada persamaan, 2 mol HNO3 : 1 mol ZnO
0.2 mol HNO3 : 0.1 mol ZnO
Mass of ZnO / Jisim ZnO = 0.1 × [65 + 16] = 8.1 g
(ii) From the equation / Daripada persamaan, 2 mol HNO3 : 1 mol Zn(NO3)2
0.2 mol HNO3 : 0.1 mol Zn(NO3)2
Mass of Zn(NO3)2 / Jisim Zn(NO3)2 = 0.1 mol × [65 + [14 + (16 × 3)] × 2] g mol–1
= 0.1 × 189
= 18.9 g
3 200 cm3 of 1 mol dm–3 barium chloride solution reacts with 100 cm3 of 1 mol dm–3 silver nitrate solution. Calculate the mass of
precipitate produced. [Relative atomic mass Ag = 108, Cl = 35.5]
200 cm3 larutan barium klorida 1 mol dm–3 bertindak balas dengan 100 cm3 larutan argentum nitrat 1 mol dm–3. Hitungkan jisim
mendakan yang terbentuk. [Jisim atom relatif: Ag = 108, Cl = 35.5]
What is qualitative analysis of Qualitative analysis of a salt is a chemical technique to identify the ions present in a salt.
salt? Analisis kualitatif garam ialah suatu teknik dalam kimia yang digunakan untuk mengenal pasti ion-ion
Apakah analisis kualitatif garam? yang hadir dalam garam.
What is the preliminary The preliminary examination is on the physical properties such as colour and solubility, indicate the
examination on salt? possibility the presence of certain cations, anions or metal oxide.
Apakah pemeriksaan awal ke atas Pemeriksaan awal adalah ke atas sifat-sifat fizikal seperti warna dan keterlarutan, menunjukkan
garam? kemungkinan kehadiran kation, anion atau oksida logam tertentu.
7
Fe3+
Perang Perang
UNIT
Black Insoluble
CuO
Hitam Tak terlarutkan
Yellow when hot,
white when cold Insoluble
ZnO
Kuning apabila panas, Tak terlarutkan
putih apabila sejuk
Brown when hot,
yellow when cold Insoluble
PbO
Perang apabila panas, Tak terlarutkan
kuning apabila sejuk
How are qualitative analysis being The qualitative analysis consists of the following steps:
done to identify salts? Analisis kualitatif terdiri daripada langkah-langkah berikut:
Bagaimanakah analisis kualitatif (a) Observe the physical properties on salt.
dijalankan untuk menentukan Perhatikan sifat-sifat fizik garam.
garam? (b) The action of heat on salts.
Kesan haba ke atas garam.
(c) Prepare aqueous solution of salts and conduct confirmatory test for cation and anion that present.
Sediakan larutan akueus garam dan jalankan ujian pengesahan untuk kation dan anion yang hadir.
What are the effect of heat on Some salts decompose when they are heated:
salts? Beberapa jenis garam terurai apabila dipanaskan:
Apakah kesan haba ke atas Salt metal oxide gas
garam? +
Garam oksida logam gas
Heat
Panaskan
Lime water
Air kapur
– Colourless gas with pungent smell. – Produced by heating ammonium salt with alkali.
Gas tanpa warna dengan bau yang sengit. Terhasil apabila garam ammonium dipanaskan
Ammonia, NH3 – Place a moist red litmus paper at the mouth of the boiling tube, red dengan alkali.
Ammonia, NH3 litmus paper turns blue. – Ammonium ion NH4+ present.
Letakkan kertas litmus merah lembap pada mulut tabung didih, kertas Ion ammonium NH4+ hadir.
UNIT
2KNO3 2KNO2 + O2
White solid White solid
K +
–
Pepejal putih Pepejal putih
2NaNO3 2NaNO2 + O2
Na+ White solid White solid –
Pepejal putih Pepejal putih
Decompose to oxygen gas, nitrogen dioxide gas and Decompose to carbon dioxide gas and metal oxide when
metal oxide when heated heated
Terurai kepada gas oksigen, gas nitrogen dioksida dan Terurai kepada gas karbon dioksida dan oksida logam apabila
oksida logam apabila dipanaskan dipanaskan
3 Sulphate salts are more stable, they are not easily decompose when heated.
Garam sulfat lebih stabil kerana ia tidak terurai dengan mudah apabila dipanaskan.
A white salt is heated. – Nitrogen dioxide gas released. Nitrate ion present.
7
– Brown gas is released, the gas turns moist blue litmus
paper red. – The residue is zinc oxide. Zinc ion present.
UNIT
– Residue is yellow when hot and white when cold. zinc nitrate
– The white salt is .
Garam berwarna putih dipanaskan.
– Gas perang dibebaskan, ia menukarkan kertas litmus biru – Gas nitrogen dioksida dibebaskan. Ion nitrat
lembap kepada merah.
– Baki berwarna kuning apabila panas dan putih apabila hadir.
sejuk. – Baki ialah zink oksida. Ion zink hadir.
A white salt is heated. – Carbon dioxide gas released. Carbonate ion present.
– Colourless gas released, the gas turns lime water chalky. – The possible residues are CaO/MgO/Al2O3.
– Residue is white
– Gas karbon dioksida dibebaskan. Ion karbonat
Garam berwarna putih dipanaskan.
– Gelembung gas dibebaskan, ia menukarkan air kapur hadir.
menjadi keruh. – Baki yang mungkin adalah CaO/MgO/Al2O3.
– Baki berwarna putih.
UNIT
– From the above table, action of heat on salt can be used to identify lead(II) nitrate , lead(II) carbonate , zinc nitrate ,
7
List the cations. Ca2+, Zn2+, Al3+, Pb2+, Cu2+, Fe2+, Fe3+, NH4+
Senaraikan kation.
What are the two steps for testing Step 1: Add a few drops of sodium hydroxide solution or ammonia solution to the aqueous solution of salt
cations? and observe.
Apakah dua langkah untuk Step 2: Add excess of sodium hydroxide solution or ammonia solution and observe.
menguji kation? Langkah 1: Tambah beberapa titis larutan natrium hidroksida atau larutan ammonia kepada larutan
akueus garam dan perhatikan.
Langkah 2: Tambah larutan natrium hidroksida atau larutan ammonia sehingga berlebihan dan perhatikan.
What are the essential Three main observations / Tiga pemerhatian utama:
observations? 1 Is there a precipitate formed in a few drops of testing reagent?
Apakah pemerhatian yang Adakah terdapat mendakan terbentuk dalam beberapa titis reagen ujian?
penting? 2 If yes, what is the colour of the precipitate? / Jika ya, apakah warna mendakan itu?
3 Does the precipitate dissolve in excess testing reagent?
Adakah mendakan itu larut dalam reagen ujian sehingga berlebihan?
7
ferum(II) sulfat, ferum(III) sulfat, plumbum(II) nitrat, magnesium nitrat, zink nitrat dan ammonium klorida.
UNIT
B Confirmatory test for cation using ammonia solution, NH3:
Ujian pengesahan bagi kation menggunakan larutan ammonia, NH3:
1 2 cm3 of calcium nitrate solution is poured into a test tube.
2 A few drops of ammonia solution are added into the test tube using dropper.
3 The test tube is shaken.
4 Observation on whether the precipitate is produced and its colour is recorded.
5 If a precipitate is formed, ammonia solution is added continuously until no further changes occurred.
6 The test tube is shaken.
7 Observation on whether the precipitate dissolved in excess ammonia solution is recorded.
8 Steps 1 – 7 are repeated by replacing calcium nitrate solution with aluminium nitrate, copper(II) sulphate, iron(II) sulphate,
iron(III) sulphate, lead(II) nitrate, magnesium nitrate, zinc nitrate and ammonium chloride solutions.
1 2 cm3 larutan kalsium nitrat dimasukkan ke dalam tabung uji.
2 Beberapa titis larutan ammonia dimasukkan ke dalam tabung uji menggunakan penitis.
3 Tabung uji digoncang.
4 Pemerhatian sama ada mendakan terbentuk dan warnanya dicatatkan.
5 Jika mendakan terbentuk, larutan ammonia terus ditambah hingga tiada perubahan lagi.
6 Tabung uji digoncang.
7 Pemerhatian sama ada mendakan yang terbentuk larut dalam larutan ammonia berlebihan dicatatkan.
8 Langkah 1 – 7 diulang dengan menggantikan larutan kalsium nitrat dengan larutan aluminium nitrat, kuprum(II) sulfat,
ferum(II) sulfat, ferum(III) sulfat, plumbum(II) nitrat, magnesium nitrat, zink nitrat dan ammonium klorida.
175 © Nilam Publication Sdn. Bhd.
MODULE • Chemistry FORM 4
Result / Keputusan:
Sodium hydroxide solution Ammonia solution
Cations Larutan natrium hidroksida Larutan ammonia Confirmatory test with other reagent
Kation small amount excess small amount excess Ujian pengesahan dengan bahan uji lain
sedikit berlebihan sedikit berlebihan
Insoluble in excess No change
White precipitate No change
Ca2+ Tak larut dalam Tiada –
Mendakan putih Tiada perubahan
berlebihan perubahan
Insoluble in excess Insoluble in excess
White precipitate White precipitate
Mg2+ Tak larut dalam Tak larut dalam –
Mendakan putih Mendakan putih
berlebihan berlebihan
Soluble in excess Soluble in excess
White precipitate White precipitate
Zn2+ Larut dalam Larut dalam –
Mendakan putih Mendakan putih
berlebihan berlebihan
Soluble in excess Insoluble in excess
White precipitate White precipitate Refer to page 178
Al3+ Larut dalam Tak larut dalam
Mendakan putih Mendakan putih Merujuk kepada muka surat 178
berlebihan berlebihan
Soluble in excess Insoluble in excess
White precipitate White precipitate Refer to page 178
Pb2+ Larut dalam Tak larut dalam
Mendakan putih Mendakan putih Merujuk kepada muka surat 178
berlebihan berlebihan
Add a few drops of potassium hexacyanoferrate(III)
Insoluble in excess Green Insoluble in excess
Green precipitate solution, dark blue precipitate is formed
Fe2+ Tak larut dalam precipitate Tak larut dalam
Mendakan hijau Tambah beberapa titis larutan kalium
berlebihan Mendakan hijau berlebihan
heksasianoferat(III), mendakan biru terbentuk
• Add a few drops of potassium hexacyanoferrate(II)
solution, dark blue precipitate is formed
Brown Tambah beberapa titis larutan kalium
Insoluble in excess Insoluble in excess
Brown precipitate precipitate heksasianoferat(II), mendakan biru terbentuk
Fe 3+
Tak larut dalam Tak larut dalam
Mendakan perang Mendakan • Add a few drops of potassium thiocyanate solution,
berlebihan berlebihan
perang blood red colouration is formed
Tambah beberapa titis larutan kalium tiosianat,
mendakan merah darah terbentuk
Insoluble in excess Soluble in excess
Blue precipitate Blue precipitate
Cu2+ Tak larut dalam Larut dalam –
Mendakan biru Mendakan biru
berlebihan berlebihan
No change. A gas that changes red litmus
Add a few drops of Nessler’s reagent, brown
paper to blue is released when heated. No change
No change precipitate is formed
NH4+ Tiada perubahan. Suatu gas yang Tiada
Tiada perubahan Tambah beberapa titis reagen Nessler, mendakan
mengubah kertas litmus merah kepada perubahan
perang terbentuk
biru dibebaskan apabila dipanaskan.
(a) Reaction with small amount until excess of sodium hydroxide solution: (refer to the above table)
Tindak balas dengan larutan natrium hidroksida sedikit demi sedikit sehingga berlebihan: (rujuk jadual di atas)
Pungent smell, moist red litmus paper turn to blue
UNIT
Solution Add a little sodium Bau sengit, menukarkan kertas litmus merah lembap kepada biru
contains: hydroxide solution
7
Heat / Panaskan
Larutan Tambahkan sedikit NH4+ NH4+
mengandungi: larutan natrium
Ca2+, Mg2+, Al3+, hidroksida No precipitate
Zn2+, Pb2+, Fe2+, Tiada mendakan
Fe3+, Cu2+, NH4+ Cu2+ (blue / biru),
Fe2+ (green / hijau),
Precipitate formed Fe3+ (brown / perang)
Mendakan terbentuk Coloured precipitate
Mendakan berwarna Soluble
Larut
Zn2+, Al3+, Pb2+
Pb2+, Al3+,
Zn2+, Ca2+,
White precipitate Mg2+ Add excess sodium hydroxide
Mendakan putih solution
Tambahkan larutan natrium Ca2+, Mg2+
Insoluble
hidroksida berlebihan Tak larut
7
changes red litmus paper to blue
UNIT
Tiada mendakan dalam larutan natrium hidroksida dan berbau sengit apabila dipanaskan, gas terbebas
menukarkan kertas litmus merah kepada biru
(e) All cations can be identified with confirmatory test using sodium hydroxide solution and ammonia solution except Al3+
and Pb2+.
Semua kation boleh dikenal pasti dengan ujian pengesahan menggunakan larutan natrium hidroksida dan larutan
ammonia kecuali Al3+ dan Pb2+.
Al3+ Pb2+
7
What are the essential The observation could be one of the following:
observation? Pemerhatian mungkin salah satu daripada berikut:
Apakah pemerhatian yang • Colour of precipitate / Warna mendakan
penting? • Gas released / Gas yang dibebaskan
2 cm3 of solution that contains anion Xn– is poured into a test tube.
2 cm3 larutan yang mengandungi anion Xn– dituang ke dalam tabung uji.
1 4 cm3 of dilute hydrochloric 1 Dilute nitric acid is added into the 1 Dilute hydrochloric acid / nitric acid is 1 2 cm3 of dilute sulphuric acid is
acid is added into the test tube. test tube until no further changes. added into the test tube until no further added into the test tube followed by
4 cm3 asid hidroklorik cair Asid nitrik cair ditambah ke dalam changes / Asid hidroklorik/asid nitrik 2 cm3 of iron(II) sulphate solution.
ditambah ke dalam tabung uji. tabung uji hingga tiada sebarang cair ditambah ke dalam tabung uji The test tube is shaken.
2 The gas given off is passed perubahan. hingga tiada sebarang perubahan. 2 cm3 asid sulfurik cair ditambah
through lime water. 2 2 cm3 of silver nitrate solution is 2 2 cm3 of barium chloride / barium ke dalam tabung uji diikuti dengan
Gas yang terbebas dialirkan added into the test tube. / 2 cm3 nitrate solution is added into the test 2 cm3 larutan ferum(II) sulfat.
melalui air kapur. larutan argentum nitrat ditambah tube. / 2 cm3 larutan barium klorida/ Tabung uji digoncang.
ke dalam tabung uji tersebut. barium nitrat ditambah ke dalam 2 The test tube is slanted and held
tabung uji tersebut. with a test tube holder. / Tabung
Add nitric acid followed uji dicondongkan dan dipegang
by silver nitrate solution Add nitric acid followed
Tambah asid nitrik by silver nitrate solution dengan pemegang tabung uji.
Acid Tambah asid nitrik 3 A few drops of concentrated
Asid diikuti dengan larutan
argentum nitrat diikuti dengan larutan sulphuric acid are dropped along
argentum nitrat
the wall of the test tube and is
held upright. / Beberapa titis asid
179
Sodium carbonate Lime
Sodium
waterchloride solution White precipitate Sodium chloride solution sulfurik pekat dititiskan melalui
Natrium karbonat Air
Larutan
kapur natrium klorida Mendakan putih Larutan natrium klorida White precipitate dinding tabung uji dan ditegakkan.
Mendakan putih
Concentrated sulphuric acid is added drop
by drop.
Observation / Pemerhatian : Observation / Pemerhatian : Asid sulfurik pekat ditambah titis demi titis
Observation / Pemerhatian :
• Effervescence occurs. • A white precipitate is formed.
• A white precipitate is formed.
Gelembung gas terbentuk. Mendakan putih terbentuk.
Mendakan putih terbentuk.
• Lime water turns chalky. Inference / Inferens :
Air kapur keruh. Inference / Inferens :
• The precipitate is silver chloride . • The precipitate isbarium sulphate .
Inference / Inferens : Sodium nitrate solution Brown ring
Mendakan putih adalah argentum Mendakan putih adalah barium
+ dilute sulphuric acid + Gelang perang
• The gas is carbon dioxide . iron(II) sulphate solution
klorida . sulfat
karbon . Larutan natrium nitrat + asid
Gas itu adalah Observation
sulfurik cair + larutan ferum(II) / Pemerhatian :
dioksida Conclusion / Kesimpulan : Conclusion / Kesimpulan : sulfat
. • Brown ring is formed.
Chloride ion present. Sulphate ion present. Gelang perang terbentuk.
Conclusion / Kesimpulan :
Ion klorida hadir. Ion sulfat hadir. Conclusion / Kesimpulan :
Carbonate ion present.
Ionic equation / Persamaan ion : Ionic equation / Persamaan ion : Nitrate ion present.
Ion karbonat hadir.
Ag+ + Cl– → AgCl Ba2+ + SO42– → BaSO4 Ion nitrat hadir.
Ionic equation / Persamaan ion :
CO32– + 2H+ → 2H2O + CO2
UNIT 7
MODULE • Chemistry FORM 4
Exercise / Latihan
1 (a) Substance A is white in colour. When A is strongly heated, brown gas, B and gas C are released. Gas C lighted a glowing
wooden splinter. Residue D which is yellow in colour when hot and white when cold is formed.
Bahan A berwarna putih. Apabila A dipanaskan dengan kuat, gas berwarna perang B dan gas C dibebaskan. Gas C
menyalakan kayu uji berbara. Baki D yang berwarna kuning apabila panas dan putih apabila sejuk terbentuk.
(i) Name substances A, B, C and D. / Namakan bahan A, B, C dan D.
A: Zinc nitrate / Zink nitrat
B: Nitrogen dioxide / Nitrogen dioksida
C: Oxygen / Oksigen
D: Zinc oxide / Zink oksida
(ii) Write the chemical equation when substance A is heated. / Tuliskan persamaan kimia apabila bahan A dipanaskan.
2Zn(NO3)2 2ZnO + 4NO2 + O2
(b) A colourless solution E gives the following results when a few series of tests are conducted.
Larutan tanpa warna E memberi keputusan berikut apabila beberapa siri ujian dijalankan:
S1 – Add sodium hydroxide solution, a white precipitate is formed. The precipitate is soluble in excess sodium hydroxide
solution.
S2 – Add ammonia solution, a white precipitate is formed. The precipitate is insoluble in excess ammonia solution.
S3 – Add potassium iodide solution, a yellow precipitate F, is formed.
L1 – Apabila ditambah dengan larutan natrium hidroksida, mendakan putih terbentuk. Mendakan ini larut apabila
ditambah natrium hidroksida berlebihan.
L2 – Apabila ditambah larutan ammonia, mendakan putih terbentuk dan mendakan ini tidak larut dalam larutan
ammonia berlebihan.
L3 – Apabila ditambah dengan larutan kalium iodida, mendakan kuning F terbentuk.
(i) What are the possible cations present in substance E as a result of S1 test?
Apakah kation-kation yang mungkin hadir dalam bahan E hasil ujian L1?
Pb2+, Al3+, Zn2+
(ii) What are the possible cations present in solution E as a result from S1 and S2 tests?
Apakah kation yang mungkin hadir dalam larutan E hasil ujian L1 dan L2?
Pb2+, Al3+
(iii) What is the ion present in E after S3 test has been done? Write an ionic equation for the formation of substance F.
Apakah ion yang disahkan hadir dalam E setelah dilakukan ujian L3? Tulis persamaan ion bagi pembentukan bahan F.
Ion present / Ion hadir : Pb
2+
UNIT
2 The table below shows the colour of five solutions labelled A, B, C, D and E added with small amount until excess of sodium
hydroxide solution and ammonia solution.
Jadual di bawah menunjukkan warna lima larutan berlabel A, B, C, D dan E yang ditambah dengan larutan natrium hidroksida
dan larutan ammonia sedikit demi sedikit sehingga berlebihan.
A: Cu
2+
B: Zn
2+
C: Fe
2+
E: Mg
2+
(d) Describe briefly a test that can differentiate the cations present in solution D.
Terangkan secara ringkas satu ujian yang boleh digunakan untuk membezakan kation-kation yang hadir dalam larutan D.
Add a few drops of potassium iodide / sodium chloride / sodium sulphate solution into 1 cm3 of solution D. Yellow/white
precipitate formed, lead(II) ion / Pb2+ present. No precipitate, aluminium ion / Al3+ present.
Tambahkan beberapa titik larutan kalium iodida/natrium klorida/natrium sulfat kepada 1 cm3 larutan D. Mendakan
kuning/putih terbentuk, Pb2+ hadir. / Tiada mendakan, Al3+ hadir.
3 The diagram below shows the flow chart of changes that took place beginning from solid M. Solid M is a zinc salt. When solid
M is heated strongly, it decomposes into solid Q which is yellow when hot and white when cold.
Rajah di bawah menunjukkan carta aliran bagi perubahan yang berlaku bermula daripada pepejal M. Pepejal M adalah suatu
garam bagi zink. Apabila pepejal M dipanaskan dengan kuat, ia terurai kepada suatu pepejal Q yang berwarna kuning apabila
panas dan putih apabila sejuk.
7
Heat Add dilute nitric acid
UNIT
Panaskan Tambah asid nitrik cair
Solid Q + carbon dioxide gas
Pepejal Q + gas karbon dioksida
Solution S + Carbon dioxide gas + Water
Larutan S Gas karbon dioksida Air
(a) (i) State one chemical test for carbon dioxide gas.
Berikan satu ujian kimia bagi gas karbon dioksida.
Passed the gas through lime water, lime water turns chalky
Lalukan gas pada air kapur, air kapur menjadi keruh
Solid M
Pepejal M
Heat
Panaskan
Lime water
Air kapur
(c) State the observations made when excess ammonia solution is added to solution S.
Nyatakan pemerhatian yang dibuat apabila larutan ammonia berlebihan ditambahkan kepada larutan S.
White precipitate, soluble in excess of ammonia solution.
Mendakan putih terbentuk, ia larut dalam larutan ammonia berlebihan.
(ii) For reaction II, calculate the volume of carbon dioxide gas released at room condition if 12.5 g solid M decomposes
completely. [Relative atomic mass: C = 12, O = 16, Zn = 65, 1 mole of gas occupies 24 dm3 at room condition]
Bagi tindak balas II, hitungkan isi padu gas karbon dioksida yang dibebaskan pada keadaan bilik, jika 12.5 g pepejal
M terurai dengan lengkap. [Jisim atom relatif: C = 12, O = 16, Zn = 65, 1 mol gas menempati 24 dm3 pada suhu
bilik]
12.5
Number of moles of solid M / Bilangan mol pepejal M = 125 = 0.1 mol
UNIT
Volume of CO2 / Isi padu CO2 = 0.1 mol × 24 dm3 mol–1 = 2.4 dm3
(f) Describe a chemical test to determine the presence of anion in the magnesium nitrate solution.
Huraikan ujian kimia untuk menentukan kehadiran anion dalam larutan magnesium nitrat.
– About 2 cm3 of magnesium nitrate solution is poured into a test tube.
– 2 cm3 of dilute sulphuric acid is added to the solution followed by 2 cm3 of iron(II) sulphate solution. The
mixture is shaken .
– The test tube is slanted and held with a test tube holder.
– A few drops of concentrated sulphuric acid are dropped along the wall of the test tube and is held upright.
– A brown ring is formed between two layers. Anion present is nitrate ion.
– Masukkan 2 cm3 larutan magnesium nitrat ke dalam tabung uji.
– 2 cm3 asid sulfurik cair ditambah kepada larutan diikuti dengan 2 cm3 larutan ferum(II) sulfat .
Campuran digoncang .
– Tabung uji dicondongkan dan dipegang dengan pemegang tabung uji.
– Beberapa titis asid sulfurik pekat dititiskan melalui dinding tabung uji dan ditegakkan.
– Gelang perang terbentuk antara dua lapisan. Anion yang hadir adalah ion nitrat .
4 You are given zinc chloride crystals. Describe how you would conduct a chemical test in the laboratory to identify the ions
present in zinc chloride crystals.
Anda diberi hablur zink klorida. Huraikan bagaimana anda boleh menjalankan ujian kimia di dalam makmal untuk mengenal
pasti ion-ion yang hadir dalam hablur zink klorida
7
– Larutan tersebut dituang ke dalam tiga tabung uji.
UNIT
– Tambahkan beberapa titik larutan natrium hidroksida ke dalam larutan zink klorida sehingga berlebihan .
Mendakan putih larut dalam larutan natrium hidroksida berlebihan terbentuk.
– Tambahkan beberapa titik larutan ammonia ke dalam larutan zink klorida yang lain sehingga berlebihan .
Mendakan putih larut dalam larutan ammonia berlebihan terbentuk. Ion yang hadir adalah ion zink .
– 2 cm3 asid nitrik cair ditambahkan kepada 2 cm3 larutan zink klorida diikuti dengan 2 cm3 larutan argentum nitrat .
Mendakan putih terbentuk. Ion yang hadir adalah ion klorida.
Additional Questions
Soalan Tambahan