Академический Документы
Профессиональный Документы
Культура Документы
Roll no-
Sr no Question Answer
When water is heated with rise of temperature, it consumes
1 c
(a) Latent heat (b) Enthalpy (c) Sensible heat (d) None
When water is heated without rise of temperature, it consumes
2 a
(a) Latent heat(b) Enthalpy(c) Sensible heat(d) None
When dry saturated steam is further heated, its dryness fraction
3 c
(a) Increase(b) Decreases (c) Remains same (d) None
Water at atmospheric pressure is a
4 (a) Ideal gas (b) Far below the critical temperature b
(c) Far above the critical temperature (d) None
The latent heat of steam at the atmospheric pressure is
5 b
(a) 2157 k J/kg(b) 2257 k J/kg (c)2457 k J/kg (d) None
Volume of steam is approximately
6 (a) 600 times that of water (b) 800 times that of water b
(c) 1000 times that of water (d) None
Internal energy is with respect to
7 b
(a) Constant pressure(b) Constant volume (c) Constant temperature(d) None
Sensible heat of water is
8 (a) Greater than the latent heat of steam (b) Less than the latent heat of steam b
(c) Equal to the latent heat of steam (d) None
Critical temperature and critical pressure of steam is
9 c
(a) 2 0C and 374.15 Bar (b) 15 0C and 374.15 bar (c) 15 0C and 221bar (d) None
With the increase of pressure, the boiling point of water
10 a
(a) Increases(b) Decreases (c) No change (d) None
Specific internal energy of dry steam is given by
11 b
(a) u= h g + 100 p v g (b) u = h g – 100 p v g (c) u = 100 h g/p v g (d) None
What is effect of increase of pressure on the enthalpy of steam
12 b
(a) Increases(b) Decreases(c) Remains same(d) None
Determine power rating of an electric motor if it runs at 1440 r.p.m and line shaft
13 transmits torque of 75 Nm. Assume Reduction ratio = 1.6 c
a. 10.36 kW b. 11.3 kW c. 7.068 kW d. 9.12 kW
Determine torque transmitted on the pinion shaft if torque transmitted on gear shaft is
14 20 Nm. Consider Gear ratio = 4 b
a. 8 Nm b. 5 Nm c. 80 Nm d. 16 Nm
Why is an idler gear used in gear trains?
a. To obtain minimum centre distance between driving and driven shaft
15 b. To have required direction of rotation b
c. Both a. and b.
d. None of the above
Which flat belt drive system has two pulleys mounted on driven shaft and one pulley
on driving shaft?
16
a. Multiple belt drive b. Cone pulley drive c. Fast and loose pulley drive
c
d. None of the above
Which of the following statements are false for belt drives?
17 1. Belt drive is used in applications having constant speed drive d
2. Belt drives can be used at extremely high speeds
3. Belt drives have low power transmitting capacity
4. Belt drives need continuous lubrication
a. 1 and 2 b. 1, 2 and 3 c. 2, 3 and 4 d. 1, 2 and 4