Академический Документы
Профессиональный Документы
Культура Документы
After the designed experiment is performed, linear regression is used, sometimes iteratively, to obtain results. Coded variables
are often used when constructing this design.
Contents
Implementation
Design matrix
Choosing α
Application of central composite designs for optimization
References
Implementation
The design consists of three distinct sets of experimental runs:
1. A factorial (perhaps fractional) design in the factors studied, each having two levels;
2. A set of center points, experimental runs whose values of each factor are the medians of the values used in the factorial
portion. This point is often replicated in order to improve the precision of the experiment;
3. A set of axial points, experimental runs identical to the centre points except for one factor, which will take on values both
below and above the median of the two factorial levels, and typically both outside their range. All factors are varied in this
way.
Design matrix
The design matrix for a central composite design experiment involving k factors is derived from a matrix, d, containing the
following three different parts corresponding to the three types of experimental runs:
1. The matrix F obtained from the factorial experiment. The factor levels are scaled so that its entries are coded as +1 and
−1.
2. The matrix C from the center points, denoted in coded variables as (0,0,0,...,0), where there are k zeros.
3. A matrix E from the axial points, with 2k rows. Each factor is sequentially placed at ±α and all other factors are at zero.
The value of α is determined by the designer; while arbitrary, some values may give the design desirable properties. This
part would look like:
https://en.wikipedia.org/wiki/Central_composite_design 1/2
11/5/2019 Central composite design - Wikipedia
The design matrix X used in linear regression is the horizontal concatenation of a column of 1s (intercept), d, and all
elementwise products of a pair of columns of d:
Choosing α
There are many different methods to select a useful value of α. Let F be the number of points due to the factorial design and T
= 2k + n, the number of additional points, where n is the number of central points in the design. Common values are as follows
(Myers, 1971):
References
1. Asadi, Nooshin; Zilouei, Hamid (March 2017). "Optimization of organosolv pretreatment of rice straw for enhanced
biohydrogen production using Enterobacter aerogenes" (https://www.researchgate.net/publication/311881656_Optimizatio
n_of_organosolv_pretreatment_of_rice_straw_for_enhanced_biohydrogen_production_using_Enterobacter_aerogenes).
Bioresource Technology. 227: 335–344. doi:10.1016/j.biortech.2016.12.073 (https://doi.org/10.1016%2Fj.biortech.2016.1
2.073).
Myers, Raymond H. Response Surface Methodology. Boston: Allyn and Bacon, Inc., 1971
Text is available under the Creative Commons Attribution-ShareAlike License; additional terms may apply. By using this site,
you agree to the Terms of Use and Privacy Policy. Wikipedia® is a registered trademark of the Wikimedia Foundation, Inc., a
non-profit organization.
https://en.wikipedia.org/wiki/Central_composite_design 2/2