Академический Документы
Профессиональный Документы
Культура Документы
Step 2:
In order to program the Syrus 3G, you need to connect the following cables:
● Ground (GND), Power (VCC), TX and RX
On the Developer Programming Box, push down with a flat-head screw driver the top of the connector to
open it and then insert the proper cable into its specific connector as shown below:
The cables should look like this once inserted to start programming:
If your PC fails to recognize the drivers, please visit the following page for instructions.
Write the following command in the white line and press send to test communication
>QVR<
You should see a response in the console window with something similar to :
>RVR;__S3 Firmware__;ID=__IMEI__<
>SRFAapn<
>SRFLlogin<
>SRFPpassword<
Example: >SRFAinternetd.gdsp<
QUESTIONS?
support@digitalcomtech.com
- END