Академический Документы
Профессиональный Документы
Культура Документы
When ACFMEC is applied for under water off shore structure testing coupling between
contact metal surface and probe is accomplished by
A. a constant electrical field generating for the probe
B. the sea water depending on the salt concentration
C. a change in magnetic field
D. nothing under water testing cannot be done
2. What likely effect would a transverse defect on the signals from an ACFM probe deployed
in conventional orientation along on ferrous weld?
A. no signal changes
B. a decrease in both the Bx and Be at side
C. a decrease in Bx
D. a increase in Bx and closed
3. With decreasing wall thickness, RFT wall loss signals
A. always rotate counter-clockwise on the voltage plane
B. rotate either clockwise or counter clockwise depending if they are on the ID or OD
C. don’t rotate at all unless there is also a change in voltage of more than 10 uamp
D. always rotate clockwise on the voltage plane
4. When an RFT probe with its smaller exciter to detect coil spacing is used this may have the
following effect
A. allows faster test speed
B. increases S/N ratio
C.
D. improves detectivity of gradual discontinuities
5. Non-ferrous tubes RFT can be used in frequency range of
A. 5 - 50 Hz
B. 5 - 150 Hz
C. 0.15 – 0.50 KHz
D. None of the above
6. Plot used in ECFM interpretation that is a BxvsBz diagram is usually called
A. forward diagram
B. B law
C. uniform field plot
D. butterfly plot
A. 33 %
B. 5 %
C. 1 %
D. 14 %
16. Many RFT probes used in interface practice consist of multiple exciters and detectors in a
variety of different configurations, the reason for this
17. Localized changes in tube dimensions like dents, bulges, expansions and bends can have the
following influence on the RFT signal
18. In order to locate flaws by RFT not only along the tube length but also around the
circumference, the following type of detector shall be applied
C. array detectors
19. Simultaneous blanking (suppression) of tube unwanted signals from discontinuities (exam
under support plate) during steam generator tubing examination required
20. A tube is magnetized using a probe in coil, calculate the field factor, specific type in OD =
120mm, ID = 100mm, coil diameter = 90mm
A. En = 0.75
B. En = 0.56
C. En = 0.81
D. En = 0.90
21. Mechanical treatment of welding operations at a heat exchanger during EC testing may
cause
A. increase in proportion to the content of the alloying element and number of value element
23. what is the main factor in determining max depth that can be calculated using an ACFM
probe
D. the frequency
25. It is often possible to sort various alloys of a non-magnetic metal by means of ECT when
A. All parts other than the part tested shall be kept 2 inch away from the test coil
B. The test coil be kept away from large motors and transform
C. The table on which all parts placed shall be equipped with magnetic tub
D. The test coil should small as possible
A. Direct ZONE
B. Transition ZONE
C. Remote Zone
D. Not related to RFT, its related to UT