b) kHz pulses c) ionization gas d) different nozzles
2 hazards a) high voltage
b) pressurized gases, CDA c) heat d) UV radiation e) chemical byproducts (O3, NOx)
3 frequent errors a) lack of gas
c) worn/defective nozzle d) cable damage e) PS2000 over- /under-voltage f) insufficient cooling of PS2000 g) wrong nozzle fixing
4 system setup a) setup of PS2000
b) rule for HV-extension c) fixing of the plasma generators PG-31 d) grounding e) interlock f) CAN-connectivity g) gas lines h) gas flow management / control
5 operation mode a) diffuse plasma
b) arc transfer c) pulsed operation d) operation with injector
6 triggering a) manual operation (Plasmatool)
b) CAN - PC-connection c) CAN - Beckhoff connection d) CAN - EATON (PLC) connection
7 typical applications a) surface activation
b) cleaning c) reduction d) film (oxide, paint) removal e) coating