Академический Документы
Профессиональный Документы
Культура Документы
LFC
Quick Start Guide
AC Power
Internet
Water
LFC Input
Site Requirements
• Supply Water: 35°C~50°C (95°F~120°F) • Outlet Pipe: 1½" to 3" depending on model
• Washout Water: 15°C~75°C (60°F~165°F) • AC power in accordance with service plate
• Use external mixing valve if water is too hot or cold • Internet: Ethernet wired or wireless (with
• Must have adequate pressure and flow rate external Wi-Fi client or GSM modem)
The LFC is designed to be installed by qualified personnel only. Installation by unqualified individuals
! may result in bodily injury, damage to the LFC and surrounding equipment, and void your warranty.
This Quick Start Guide is intended to be used by personnel who are experienced with the installation
of electrical and mechanical products. Consult the User's Manual if any step in this guide is unclear.
To prevent damage to the Powerzyme, unpack the LFC when you receive it or store it in a cool place. If
that is not possible, remove the Powerzyme from the LFC (see Step 1) and store it in a cool dark place.
Items You Will Need to Unpack the LFC
or or
19 mm wrench Various tools Spirit level Pallet jack Car jack J-bar
PVC adapter Flexible connector Stop valve Mixing valve Wi-Fi or Ethernet cable
GSM modem
Step 1 — Unpack
• Remove the top of the crate first, then the horizontal
stay bar, then the front, back and sides of the crate
• Use a fork lift to remove the LFC from the crate: on
larger LFCs, the forks must be at least 1.2 m (48")
• Recycle the crate or save it for future use
• Roll LFC into place (use pallet jack if available)
• Remove plastic wrap then remove all
accessories from inside the LFC
Step 2 — Position
• Lift chassis with pallet jack, car jack, or J-bar
• Install all four feet into the load cells
• Screw the foot as far as possible into each
load cell so that no thread is showing
• Place a rubber block under each foot
• Provide 5 mm (¼") clearance from wheel to floor
• Adjust feet and use a spirit level so that LFC is level
Step 3 — Power
Service
• Confirm that only Powerchips are inside the drum plate
• Verify AC power matches that on service plate
• Close the LFC door and plug the LFC power cord in
• Verify that the touch screen turns on with LFC logo
• Verify there is a beep from the display box
• Verify the LFC Stopped screen is displayed
Power Knot LLC | 2290 Ringwood Avenue | San Jose, CA 95131 USA | +1-408-889-8433 | www.powerknot.com
Power Knot, the Power Knot logo, the Power Knot mark, LFC, and LFC Cloud are trademarks or registered trademarks of Power Knot LLC.
All other trademarks used herein are the property of their respective owners. Copyright © 2009–2017 Power Knot LLC; all rights are reserved.
Specifications are subject to change at any time without notice. Document number 96-01044-02, 31 May 2017.