Академический Документы
Профессиональный Документы
Культура Документы
Table of Components
Topographic system overview.
Definitions / Abbreviations
HW configuration overview
System overview
Line power supply
Ground wire cabling
Detail line distribution
Signal cabling 1
Signal cabling 2
Video Cabling
CAN XCS cabling.
On/Off Circuit
Safety circuit.
Exposure direct radiology
Fluoroscopy
Radiation triggering
Tube Unit connection, external signals
Polidoros Hardware Interface / Camera Interface
System Control Console interface
Signal overview, partial wiring harness W10/N20
Signal overview, partial wiring harness W420
Signal overview, partial wiring harness W120
History of the document
Page Table of Contents Page Table of Contents
1A Table of contents 14 XCS
1B Table of contents 15 Exposure and fluoroscopy button
2 General Notes, Notes
3 Overview wiring diagram 16A Operation, spotfilm device
4 Illustration of unit 16B Operation, zoom I.I.
4A Overview of assemblies
4B Overview of boards 17 Display, spotfilm device
18 CAN
5 Basic unit assemblies 19A Controller for motors in spotfilm device
5A Basic unit assemblies 19B Diaphragm plate- and grid control
5B Basic unit assemblies 19C Cassette clamping
5C Component overview 19D Cassette transport, transverse
5D Component overview
20 Service button and voltage monitoring
6 Electronics panel
6A Component overview 23A Transverse table movement
6B Component overview 23B Brake and clutch
6C Component overview 23C Device movement
7 Spotfilm device with PCB-box (A1) 23D Compression /SID
7A Component overview 23E Device movement
8 Ground wire cabling
3 Component Overview
4 Display collimator
PCB overview
5 Operational diagram:
D21, width- heightlamella and prefilter
6 Operational diagram:
D22, user Interface
9 Compatibility list
General information
Wiring diagram 66625 shows the complete version of collimator N PBL
II. THE VOLTAGE SUPPLY IS EXTERN