Академический Документы
Профессиональный Документы
Культура Документы
Training Files:
Download the training files using the button below, if you have not done so already.
Download
Procedure Setup:
1. To avoid naming conflicts, it is recommended you save your work, click File > Close until no models
display, then click File > Manage Session > Erase Not Displayed.
2. Click File > Manage Session > Set Working Directory and navigate to the
PTCU\CreoParametric2\Simulate_Modeling\Interfaces folder and click OK
2. Right-click Load1 and select Edit Definition. The Structural Temperature Load dialog box
appears.
2. Click Measures from the Run group. The Measures dialog box appears.
4. Complete the Measure Definition dialog box as shown. After selecting Surfaces in the Spatial
Evaluation section, click Select Reference and select Surf:F8(REVOLVE_1):STAMP in the
model.
http://precisionlms.ecorp.cat.com/precisionlms/standard-content/coach_cp_2b2ec2c6-... 21-03-2018
Reviewing Interfaces Page 2 of 6
Figure 1
6. Click Close.
2. Click Interface from the Connections group. The Interface Definition dialog box appears.
3. Complete the dialog box as shown. For the two surface references, in any order, select the top
surface of PLATE.PRT and the bottom surface of STAMP.PRT.
http://precisionlms.ecorp.cat.com/precisionlms/standard-content/coach_cp_2b2ec2c6-... 21-03-2018
Reviewing Interfaces Page 3 of 6
Figure 2
4. Click OK.
2. Select Maximum Element Size from the Control Types drop-down menu in the AutoGEM
group. The Maximum Element Size Control dialog box appears.
4. In the model tree, press CTRL and select PLATE.PRT and STAMP.PRT.
6. Click OK.
7. Click AutoGEM from the AutoGEM group. The AutoGEM dialog box appears.
http://precisionlms.ecorp.cat.com/precisionlms/standard-content/coach_cp_2b2ec2c6-... 21-03-2018
Reviewing Interfaces Page 4 of 6
Figure 3
9. Inspect the mesh and note that no common nodes are created where surfaces of the parts
involved are sharing a free interface connection. There are common nodes everywhere else.
10. Click Close in all dialog boxes to return to the AutoGEM dialog box.
2. Click Analyses and Studies from the Run group. The Analyses and Design Studies dialog box
appears.
3. Click File > New Static. The Static Analysis Definition dialog box appears.
4. Type Welded_Joint_Free in the Name field. Keep all other default settings.
5. Click OK.
9. Inspect the information displayed in the Run Status dialog box. Identify the maximum displacement
magnitude. Also, in the summary file, identify the resultant measure defined, Reaction_Y.
http://precisionlms.ecorp.cat.com/precisionlms/standard-content/coach_cp_2b2ec2c6-... 21-03-2018
Reviewing Interfaces Page 5 of 6
1. Click Results > Define Result Window. The Result Window Definition dialog box appears.
Figure 4
4. Review the plot. Examine the deformation and notice that the plates are held together by the weld.
Figure 5
http://precisionlms.ecorp.cat.com/precisionlms/standard-content/coach_cp_2b2ec2c6-... 21-03-2018
Reviewing Interfaces Page 6 of 6
http://precisionlms.ecorp.cat.com/precisionlms/standard-content/coach_cp_2b2ec2c6-... 21-03-2018