Академический Документы
Профессиональный Документы
Культура Документы
OWNER’S MANUAL
Carrier is committed for continuous improvement of Carrier products according to national and international
standards to ensure the highest quality and reliability standards, and to meet market regulations and requirements.
All specifications subject to change without prior notice according to Carrier policy of continuous development.
16117000000574
2015.12.01
CONTENT
1. QUICK START ··································································································· 2
2. DISPLAY AND BUTTONS ···················································································· 3 1. QUICK START
2.1 Display ········································································································· 3
2.2 Buttons ········································································································· 4
3. HOW TO USE BASIC FUNCTIONS ······································································· 5
AUTO SET TEMP. FAN AUTO SET TEMP. FAN
* Optional Functions:
INSTRUCTIONS OF USING WIRELESS REMOTE CONTROL The function is not available on the
actual remote controller or not workable
Swing
Swing
Timer
Timer
Sleep X-ECO
The remote control uses two alkaline batteries (1.5 Volts). for the air conditioner.
Do not use old batteries or batteries of different types, as this may cause the controller malfunction. My Mode Follow Me LED Turbo
* My Mode Follow Me LED Turbo
*
If you do not use the remote control for more than two months, please remove the batteries. * Self Clean*Silence*
Fresh * Self Clean* Silence*
Fresh
6 5 4
On/Off Fan
Correct Disposal of Battery AUTO
LOW
MED
- This marking printed in the batteries attached to your Air Conditioning product is information for end-uses according to the
HIGH
EU directive 2013/56/EU article 20 annex II. DR
HE Y
AT
AU
CO TO
OL
SET
TEMPE
RATUR
E
FA
- Batteries, at their end-of-life, should be disposed of separately from general household waste. Please, dispose of batteries
N
HIG
ME H
LO D
W
Mo
de
On
/Of
f
Sw
Fa
ing
n
Tim
Ion LE
D
er
ise
r Tu
Se rbo
lf Cle
an
PRESS POWER BUTTON POINT REMOTE TOWARD UNIT SELECT FAN SPEED
01 02
DISPLAY AND BUTTONS
Mode display
Displays the selected mode.
AUTO, COOL, DRY, HEAT
Swing
Timer
SET TEMP. Sleep
Fan speed display (X-ECO)
Displays the selected fan speed: AUTO, HIGH, Direct My Mode Follow Me LED Turbo
TIMER ON
Press to set the louver position. Press to set the timer to turn
MED and LOW. Nothing displays when the fan
unit on.
speed is selected in AUTO speed. When AUTO Fresh Self Clean Silence
LOCK display
Lock display is displayed during LOCK mode.
03 04
HOW TO USE BASIC FUNCTIONS
ATTENTION Before operation, please ensure the unit is plugged in and power is available. TIMER ON/OFF - Set the amount of time after which the unit will automatically turn on/off.
Press to initiate Press it for multiple times to set Point remote to unit and wait 2sec,
the ON time sequence. the desired time to turn on the unit. the TIMER ON will be activated.
Select AUTO mode Set your desired temperature Turn on the air conditioner
n
Mode On/Off TIMER
ON h
AUTO HEA
COO
DRY L
T
AUT
O
SET
TEMPER
ATURE
FAN
Mode
HIG
MED H
LOW
Mod
e
On/
Off
Swi
Fan
ng
My
Slee
Mod
e Foll p
ow
Me
Tim
Ioni LED
er
ser
Self Turb
Clea o
n
NOTE:
1. In AUTO mode for heat pump system, the air conditioner can automatically choose the mode of Cool, Heat or Fan
by sensing the difference between the actual room temperature and setting temperature. Press to initiate Press it for multiple times to set Point remote to unit and wait 2sec,
2. In AUTO mode for cooling only system, the air conditioner can automatically choose the mode of Cool or Fan the OFF time sequence. the desired time to turn off the unit. the TIMER OFF will be activated.
by sensing the difference between the actual room temperature and setting temperature.
3. In AUTO mode, fan speed can not be set. n
Select COOL/HEAT mode
TIMER
Set the temperature Set the fan speed Turn on the air conditioner
OFF h
COOL Mode Fan On/Off OFF
or
AUT
COO O
DRY L
HEA SET
TEMPER
T ATURE
FAN
HIG
MED H
LOW
Mod
e
On/
Off
Swi
Fan
ng
HEAT
My
Slee
Mod
e Foll p
ow
Me
Tim
Ioni LED
er
ser
Self Turb
Clea o
n
Mode NOTE:
1. When setting the TIMER ON or TIMER OFF, the time will increase by 30 minutes increments with each press, up to 10 hours.
After 10 hours and up to 24, it will increase in 1 hour increments. (For example, press 5 times to get 2.5h, and press 21 times to
get 11h,) The timer will revert to 0.0 after 24.
2. Cancel either function by setting its timer to 0.0h.
Select DRY mode Set the temperature Turn on the air conditioner
Mode
Setting TIMER ON & OFF (example).
On/Off
5 10
DRY h h
Mode HEA
T
AUT
COO O
DRY L
SET
TEMPERAT
URE
ON OFF
DRY L
HEA
T
AUT
COO O
SET
TEMPERAT
URE
FAN
FAN HIGH
HIGH MED
MED LOW
LOW
Mod
NOTE:
e
Mod
e
On/O
On/O ff
Swin
ff
Fan
Swin
g
Fan
g
My
Slee
Mod
My e Follo p
Slee
Mod
e Follo p w
Me
Time
w Ionis LED
Me
Time
r
LED er
Ionis Self Turb
r
er Clea o
Self Turb
o n
Clea
n
In DRY mode, fan speed can not be set since it has already been automatically controlled.
2s
My Mode The unit will memorize My Mode
My The unit will restore to
Direct the current setting
the setting you made
Mode mode, Temp., fan).
last time.
The horizontal louver will move an angle of 6 degree for each press. My mode function enable you to memorize or restore your favorite settings (mode, temperature and fan
Press the button until the louver reach your prefer location. speed). The default memorized setting is AUTO mode, 26 C and AUTO fan.
Press Swing button Press Swing button for more than 2 sec
Press this button under COOL or HEAT operating Mode Press this button more than 2 seconds
In AUTO mode for heat pump system, the air conditioner can automatically choose the mode of Cool, Heat, Fan
by sensing the difference between the actual room temperature and setting temperature. The controller will display 2s The ionizer or Plasma
Follow Me Follow Me
2s Follow the actual temp. at its dust collector (model
location and send this dependent) is energized.
Me Fresh signal to indoor unit Fresh
or every 3 minutes
Swing Fresh
Press this button to activate Follow me. This function Keep pressing this button more than 2 seconds, the
can adjust room temperature base on the controller’s fresh function is activated and will help to remove
The horizontal louver will swing up and down Keep pressing this button more than 2 seconds, the vertical sensor and make you comfort. pollen and impurities from the air. (Model dependent)
automatically when pressing Swing button. louver swing function is activated. (Model dependent) Note:Please put the controller in the location where
Press again to make it stop. can ensure the indoor unit can receive the signal.
Press LED button Press this button under COOL or DRY Mode more than 2 seconds
Press Sleep button (RG56N) under Cool/Heat mode
2s The unit will enter low
LED LED
The set temp. will increase LED fan mode to dry up the
(cooling) or decrease coil. The cleaning cycle
(heating) by 1 C per hour or Self Clean takes 15~30 mins, after
Self Clean
Sleep
for the first 2hs. Thereafter Self which the unit will turn
Sleep it keeps this new temp. for Clean off automatically.
5hs before switching off.
Press this button to turn on and turn off the display Keep pressing this button more than 2 seconds, the unit will
on the indoor unit. clean itself to avoid bacteria grow around heat
This Sleep operation saves energy and improves night time comfort by synchronising with the
Cl dependent)
body’s metabolism.
Press X-ECO button (RG56V) under Cool mode Press more than 2 seconds under Cool/Heat operate mode for Sleep
Press this button Press this button more than 2 seconds
The unit will automatically 2s The set temp. will increase
regular the fan speed and (cooling) or decrease The unit will operate at the 2s The unit will bring faint
Turbo Turbo
X-ECO compressor speed. The
X-ECO
(heating) by 1 C per hour Turbo biggest capacity outut to breeze to reduce the
X-ECO temp. can be selected from reach the setting Temp. quickly. noise to the lowest level .
for the first 2hs. Thereafter
or 24~30 C in ECO mode. or Silence Silence
it keeps this new temp. for
Sleep The function will be disable
5hs before switching off. Silence
after 8hs.
This X-ECO and Sleep operation saves energy and improves night time comfort by synchronising with the
Press this button to activate Turbo. It enables Keep pressing this button more than 2 seconds, the Silence
body’s metabolism.
the unit to reach the set temperature in function is activated. (Model dependent)
Note: The X-ECO function is invalid for multi system. the shortest time. Press it again to disable it. Note: Due to low speed of operation, it may result in
insufficient cooling and heating capacity.
07 08
HOW TO USE ADVANCED FUNCTIONS
Press together Direct button and Swing button at the same time more than 2 seconds to activate Lock Mode 1 function.
2s 2s
Lock SET TEMP.
Mode
1
Lock symbol displays
Enter lock mode 1 by pressing Direct and Swing button at the same time more than 2 seconds. At lock mode 1, all
buttons will not response except press these two buttons again to disable locking.
Press together TIMER ON button and TIMER OFF button at the same time more than 2 seconds to activate lock mode 2 function.
2s 2s
Lock SET TEMP.
Mode
2
Lock symbol displays
Enter lock mode 2 by pressing TIMER ON and TIMER OFF button at the same time more than 2 seconds. At lock
mode 2, all buttons will not response except press ON/OFF, TEMP UP and DOWN buttons or press these
two buttons again to disable locking.
Press together Mode button and Fan button at the same time more than 2 seconds.
Mode 2s Fan 2s
Cool
Only
Disable the HEAT mode by pressing Mode and Fan buttons at the same time more than 2 seconds.
Recover the HEAT mode by pressing Mode and Fan buttons at the same time more than 2 seconds again.
09 10