Академический Документы
Профессиональный Документы
Культура Документы
Drill Pipe Size Tool Joint Size Seal for Tool Seal ID Seal for Pipe Seal ID Top Plate Top Plate Size
Joint Part # Body Part # Part #
2-3/8” 2-3/8” Body KK001-1 2-3/8” KK005-1 2-3/8”
01
Unpacking
Your Kelly Kan™ has been shipped to you in one box.
Carefully unpack and, referring to packing list, make sure
that you have received 1 Kelly Kan™, 1 set of Top Plates,
and 2 sets of Kelly Kan™ seals, as illustrated in Figure 1a
(and Figure 1b if you have also ordered the optional Kelly
Kan™ Seal Kit). If any of the parts are missing, please
contact our 24-hour customer service line at 780.414.6083 Figure 1a
or toll free in North America by dialing 1.800.840.2877.
02
Kelly Kan™ Top Plate - The top plate is designed to fit above the tool joint of drill pipe or in
the saver sub groove - to ensure ideal Kelly Kan™ placement. Use the table on the first page to
determine the correct size top plate for your drill pipe. The correct top plates must be used on all
applications excluding heavy-weight and drill collars. The top plates are easily interchanged by
rotating the six bolts as illustrated in Figure 2a. Then slide and remove top plates as shown in
Figure 2b.
Figure 2a Figure 2b
Figure 3a
Note: When handling the Kelly Kan™ use handles to lift as shown above. Optimum placement of the Kelly Kan™
is 2” above slips
03
Applications
Using the Kelly Kan™ for Connections Heavy-weight and Drill Collars
& Blowing the Kelly
• Remove top plates by backing off bolts by
• Fasten to kelly as you would for a connection. one turn.
• The top plate holds Kelly Kan™ in place on • Slide top plates off Kelly Kan™ and remove.
saver sub. • Attach Kelly Kan™ two inches above pin end.
• Release air or steam slowly. • Hoist pipe slowly.
• Monitor drainage from Kelly Kan™ and repeat • Allow fluid to drain.
air or steam release as required. • Replace top plate as soon as possible to
• When kelly is clear of fluids, remove Kelly avoid misplacing them.
Kan™ and rack kelly as usual.
*applicable during winter conditions and rig out
04
Maintenance
Guidelines
i. Check the Kelly Kan™ to make sure the rig crew is using it properly.
ii. Check the seals to make sure there are no rips or tears. If the seals are damaged, replace
them before next Kelly Kan™ application.
iii. Clean the Kelly Kan™ constantly to make sure it works properly at all times.
Grooves Tongue
In order to achieve full performance from the Kelly Kan™, regular cleaning may be necessary. For
instance, deposits may build-up in the tongue and groove joints of the Kelly Kan™; affecting ability
to close and seal properly.
05
Kelly Kan™/Splash Guard™ Combination
Working in conjunction with the Kelly Kan™, the Splash Guard™ is highly effective at eliminating
splashing and flooding of the rotary table. This is achieved by the guard controlling the downward
re-direction of drilling fluid to the Upper Katch Kan™. The Splash Guard™ also keeps hoses and other
foreign objects out of slip handles/bushings while they are rotating.
Another added bonus is that this product flexes down so no extra effort is required when pulling or
inserting slips.
You can find out more about other products, such as our Katch Mat™ (rig work-floor covering) by
calling us at 780.414.6083 or toll free at 1.800.840.2877.
06