Академический Документы
Профессиональный Документы
Культура Документы
GI 8.001 Safety Requirements for GI 6.030 Traffic Control and Vehicle ARK-P116-PPE-001 Arkad PPE
Scaffolds Safety Assessment
Page 1 of 6
S No. Sequence of Steps Potential Hazards Corrective Action/Recomendation Action By
1. Obtain Work Permit and Scope of work not Issuers and Receivers shall have in their possession a valid TR Site Supervisor / All
meet the T.R. Issuer on identified work permit certificate.
the site Permits shall identify the specific work to be performed by the work
crew at a specific location.
Work Description section of the work permit form shall be
completed.
Hazard Identification and Control section of the work permit form
shall be completed
Review precautions taken and restrictions imposed to control the
hazards associated with the job site and/or work activity
Additional approvals/signatures shall be required for
renewed/extended work permits (see G.I 2.100 and section 4.7).
Attach applicable checklists/forms to the work permit that provide
supplemental information and/or approvals for the particular work
activity.
A joint site inspection with permit issuer and receiver shall be
conducted.
2. Site Preparation & Pre- Personnel Injury Site supervisor shall conduct pre-job (toolbox) safety meetings with Site Supervisor / All
task Meeting site personnel to address job-specific safety issues prior to
beginning work activity.
Supervisor shall inspect site to detect and correct unsafe acts and
conditions.
Supervisory personnel, safety personnel and/ or other qualified staff
shall be present at the job site while work is in progress.
Work permits shall be used to control hazardous work activities at
all SA facilities and locations.
Adequate number and types of fire extinguishers shall be available
at job site
Traffic control plan shall be developed for jobsite to include parking
areas, speed control and signage.
All personnel to wear complete PPE i.e. Safety Helmet, Safety
Shoes, Safety Glass, FRC/Coveralls and working gloves.
All drivers shall comply with G.I- 6.030 Traffic Control and Vehicle
Safety.
3. Erection of Scaffolding Falls Scaffolds shall be inspected and tagged by SA certified scaffold
supervisor before its first use.
Slips, trips Keep floors clean and free of slip and trip.
Page 2 of 6
Appropriate personal protection (harnesses, lanyards, anchor
Falls from height points, rope system, etc) shall be provided and used by all
personnel.
Falling object Ensure the working area shall be secured and barricaded
4. Dismantling of Dismantling shall be supervised by a certified scaffold supervisor.
Scaffolding Falling objects Relocation planning considerations will be considered during the
dismantling process.
Barricades and signs shall be used as appropriate.
Avoid dropping or throwing the components
Provide a safe means of access and fall protection
5. Housekeeping Health Hazard The entire site shall be cleaned including identifying areas where Site Supervisor / All
each subcontractor is responsible for the cleaning.
An adequate amount of trash receptacles shall be available in work
areas.
Site supervision shall ensure that trash and debris is properly
collected and disposed of daily.
Environmental Pollution Trash containers shall be of durable construction and shall be Site Supervisor / All
located as needed throughout the work area. Trash containers shall
be covered, clearly marked and emptied daily.
Plastic Bottled water or disposable cups shall be provided at site
daily.
Storage and disposal of nonhazardous and hazardous waste in
shall be in accordance with GI 430.001 and Arkad CEWMP
Waste shall be segregated at all times in accordance with waste
handling requirements.
Separate trash containers, with suitable disposable plastic liners,
shall be provided for food scraps and other organic matter.
Refuse trash and garbage shall only be disposed of at approved
sites as designated by SA or local community.
Excavation spoils and building materials shall only be disposed of
at other approved sites as designated by SA or local municipality.
Page 3 of 6
Supervisor responsible for explaining contents of this JSA
Name: Signature: Date:
Page 4 of 6
Sign On: I confirm that the JSA has been explained and its contents are clearly understood and accepted. I also confirm that my
required qualifications to undertake this activity are current and approved. I clearly understand the controls in this JSA must be applied
as documented; otherwise work is to cease immediately and a review is to be completed and work can recommence.
Page 5 of 6
Page 6 of 6