Академический Документы
Профессиональный Документы
Культура Документы
Hi,
I would like to just point out a few pointers for those tuning EDC15P as beginners.
IQ to HP (@ 4000 rpm)
100hp - 36mg
130hp - 44mg
160hp - 58mg
190hp - 69mg (This is where I think duration's must stop on PD100 setups)
210hp - 76mg
222hp - 80mg (This is where I think duration's must stop on PD130/PD160 setups)
SVBL
No need to change on stock turbo, avoid requesting higher than the manufactures SVBL
Always make sure SVBL is greater than you target by atleast 50mbar
Torque Limiter
Look at PD130 vs PD160 Torque limiter. don't ever raise entire TL by a common
factor,you will attract boost spikes and end up
with results like : 510nm 190hp for a PD130 tune, the shape changes to achieve this :
stage 1 410nm 160hp, stage 2 410nm 190hp
You can also use the torque limiter to remove boost spikes cause by injection.
Datalogging
You need to log the following, but log one group at a time for 3rd gear and you can log
both on 4th.
Group 11 - Turbo control
Group 3 - MAF (use this readings for the smoke limiter, 2150mbar = 780 mg/str, 780/17
= NO MORE than 45,8mg required
Also check torsion value if 0 or within spec,
Check status of injectors as well.