Академический Документы
Профессиональный Документы
Культура Документы
PRESSURE CONTROL
EXPERIMENTATION
perform the Operative Unit 10;
carry out the connections as in Fig.4.2.1;
disconnect for a moment the cable that connects jack 4 (Module 33 Unit 6) to jack 7 (Module 33
insert a terminal of the digital voltmeter, set to direct current, in jack 1 Uref (SET POINT) and th
adjust the SET POINT voltage to 4V (0.8bar);
move the terminal of the digital voltmeter in jack 3 of the pressure sensor (Module 33D);
close the DRAIN VALVE;
turn the knob Kp of the PROPORTIONAL CONTROLLER to 75% and the knob Ki of the INTEGRA
restore the connection between jack 4 (Module 33 Unit 6) and jack 7 (Module 33 Unit 8): the pu
adjust the DRAIN VALVE so to make the pressure decrease in the tank: the pump starts again to
observe what happens: after a series of oscillations the systems establishes itself;
repeat the previous operations for the different values of Ki, Kp, Uref and DRAIN VALVE so to de
described in the procedure were carried out. The set point was adjusted to 4V
corresponding to 0.8 bar. Drain valve was closed. Multimeter was then transferred
to the jack of the pressure sensor. The knob of the proportional controller was
turned to 75% while the knob of the integral controller was turned to 25%.
The pump was operated until it reached the set point value set with the
Uref. The pressure in the tank was decreased by adjusting the drain valve. Then,
the pump was operated again keeping a constant pressure in the tank. After a
the controller to the respective value. It was observed that voltage is a function of
the pressure. The data was then graphed showing a continuous rise up of the
calibrate the position sensor first before using to ensure the accuracy of the
pressure sensor were shown. In terms of the operation of the pressure control, I
conclude that voltage is a function of the pressure. As the pressure increases, the
On the other hand, the operation of a closed loop control system was
the most common control algorithm used in industrial control. It has a wide range
4) In its use field, does the operation of the regulator P depend on the time?
a) Yes
b) No
LYCEUM OF THE PHILIPPINES UNIVERSITY-CAVITE
Experiment No. 5
Pressure Control
Experiment No. 2
Temperature Sensor