Академический Документы
Профессиональный Документы
Культура Документы
Design parameter
Factored Design Shear , V= 22.75 Ton 50 Kips
Bolts Properties
Grade = A325 Mpa
Ultimate Tensile Strength , Fu = 828 120 Ksi
Nominal Tensile Strength , Fnt = 621 90 Ksi
Nominal shear Strength , Fnv = 332 48 Ksi
Dia of bolts used, d = 20 mm
Nominal dia of hole , dh = 22 mm
Section
Supproted sec. = NPB300
Connector sec. = Face Plate
Connecting sec. = ISMB200 Face Plate
D Tf Tw B L W t
NPB300 300 10.7 7.1 150 200 160 10
ISMB200 200 10 5.7 100
Total Design Bearing Strength at bolts hole = 54.88 Ton >22.75Ton, Hence O.K.
[As the edge end of the face plate along pitch is restrained by weld, so the edge tearout strength
is not considered]
iv) Checking of Face Plate for Bolts Bearing for Supported Member
[As the face plate thickness is same of connecting member so further check of bearing strength
is not required for the supported member]
Eccentricity , e = 81.45 mm
Moment,M = 1.86 Ton-m Different checking is pending
As the junction of the connection is fully restrained by web stiffeners so further check is not
required for this case.