Академический Документы
Профессиональный Документы
Культура Документы
A fine-gained soil can exist in any of several states; which state depends on the amount of water in the soil system. When water is added to a dry
soil, each particle is covered with a film of adsorbed water. If the addition of water is continued, the thickness of the water film on a particle
increases. Increasing the thickness of the water films permits the particles to slide past one another more easily. The behavior of the soil, therefore,
is related to the amount of water in the system. Approximately sixty years ago, A. Atterberg defined the boundaries of four states in terms of "limits"
as follows:
https://www.aboutcivil.org/atterberg-limits.html 1/5
7/18/2019 Atterberg's Limits Soil Classification - Liquid Limit, Plastic Limit, Shrinkage
Atterberg's De nitions
Liquid limit: The boundary between the liquid and plastic states;
Plastic limit: The boundary between the plastic and semi-solid states;
Shrinkage limit: The boundary between the semi-solid and solid states.
Procedure for Determination of Liquid Limit | Procedure for Determination of Plastic Limit
Casagrande's De nition
These limits have since been more definitely defined by A. Casagrande as the water contents which exist under the following conditions:
Liquid limit: The water content at which the soil has such a small shear strength that it flows to close a groove of standard width when jarred in a
specified manner.
Plastic limit: The water content at which the soil begins to crumble when rolled into threads of specified size.
Shrinkage limit: The water content that is just sufficient to fill the pores when the
It is the minimum moisture content at which a soil flows upon application of very small shear force. OR
The moisture content at which any increase in the moisture content will cause a plastic soil to behave as a liquid. The limit is defined as the moisture
content, in percent, required to close a distance of 0.5 inches along the bottom of a groove after 25 blows in a liquid limit device.
Liquid Limit (LL or wL) - the water content, in percent, of a soil at the arbitrarily defined boundary between the semi-liquid and plastic states.
https://www.aboutcivil.org/atterberg-limits.html 2/5
7/18/2019 Atterberg's Limits Soil Classification - Liquid Limit, Plastic Limit, Shrinkage
Atterberg's Limits
The moisture content at which any increase in the moisture content will cause a semi-solid soil to become plastic. The limit is defined as the
moisture content at which a thread of soil just crumbles when it is carefully rolled out to a diameter of 1/8 inch.
Plastic Limit (PL or wP) - the water content, in percent, of a soil at the boundary between the plastic and semi-solid states.
Plasticity
It is defined as the property of cohesive soil which posses the ability to undergo changes of shape without rupture or a change in volume.
https://www.aboutcivil.org/atterberg-limits.html 3/5
7/18/2019 Atterberg's Limits Soil Classification - Liquid Limit, Plastic Limit, Shrinkage
Shrinkage Limit
It is the maximum water content at which a reduction in water content will not cause a decrease in volume of the soil mass. It is the lowest water
content at which soil can still be saturated.
Flow Index
The curve obtained from the graph of water content against the log of blows while determining the liquid limit lies almost on a straight line and is
known as the flow curve. The equation for flow curve is:
W = - If Log N + C
Where 'If is the slope of flow curve and is termed as "Flow Index"
Toughness Index
https://www.aboutcivil.org/atterberg-limits.html 4/5
7/18/2019 Atterberg's Limits Soil Classification - Liquid Limit, Plastic Limit, Shrinkage
The shearing strength of clay at plastic limit is a measure of its toughness. It is the ratio of plasticity index to the flow index. It gives us an idea of the
shear strength of soil.
https://www.aboutcivil.org/atterberg-limits.html 5/5