Академический Документы
Профессиональный Документы
Культура Документы
85
SHERWIN-WILLIAMS
COMPANY
Tank Linings,
Containment & ENVIROLASTIC ®
AR425
Corrosion Control PART A B81V3200 ISOCYANATE
Coatings PART B B81-3200 SERIES
INDUSTRIAL
& MARINE
COATINGS PRODUCT INFORMATION Revised 11/04
SAFETY PRECAUTIONS
Refer to the MSDS sheet before use.
Recommended Spreading Rate per application: May be applied in one or two coats to achieve the recom-
Wet mils: 30.0 - 250.0 mended film thickness.
Dry mils: 30.0 - 250.0
Coverage: 6 - 53 sq ft/gal approximate
For steel, stripe coat all chine, welds, bolted connections, and
Drying Schedule @ 30.0 mils wet @ 73°F and 50% RH: sharp angles to prevent early failure in these areas. For con-
To touch: 45 seconds crete, all cracks must receive a 6" wide by 30 mil dft detail coat.
To recoat:
minimum: 45 seconds Use only heated, plural component equipment capable of
maximum: 16 hours producting 2,500 psi at 160°F and 2 gallon/minute output con-
Gel time: 15 seconds sistently.
Tack free: 45 seconds
Light traffic: 2 hours In order to avoid blockage of spray equipment, clean equip-
To cure: 24 hours ment before use or before periods of extended downtime
If maximum recoat time is exceeded, abrade surface and solvent wipe before with Butyl Cellusolve™ (R6K25), Dowanol PM™, or Propylene
recoating. Dryingtimeistemperature,humidity,andfilmthicknessdependent. Glycol.
Pot Life: None While spraying, use a 50% overlap with each pass of the gun
to avoid holidays, bare areas, and pinholes. If necessary, cross
Sweat-in Time: None spray at a right angle.
Application of coating above maximum or below minimum rec- Spreading rates are calculated on volume solids and do not
ommended spreading rate may adversely affect coating per- include an application loss factor due to surface profile, rough-
formance. ness or porosity of the surface, skill and technique of the ap-
plicator, method of application, various surface irregularities,
material lost during mixing, spillage, overthinning, climatic con-
ditions, and excessive film build.