Академический Документы
Профессиональный Документы
Культура Документы
م
2 July 2019 1440 شوال29
َ ُْ ََ
Analog IC Design
Lecture 05
MOSFET Small Signal Model
G
B S D
p+ n+ n+
p-sub
05: MOSFET AC 2
Regions of Operation Summary
OFF
ON
(Subthreshold)
𝑉𝐺𝑆 > 𝑉𝑇𝐻
𝑉𝐺𝑆 < 𝑉𝑇𝐻
𝑊 2
𝑉𝐷𝑆 𝜇𝐶𝑜𝑥 𝑊 2
𝐼𝐷 = 𝜇𝐶𝑜𝑥 𝑉𝑜𝑣 𝑉𝐷𝑆 − 𝐼𝐷 = 𝑉 1 + 𝜆𝑉𝐷𝑆
𝐿 2 2 𝐿 𝑜𝑣
05: MOSFET AC 3
Pinch-Off (Saturation)
❑ The channel is pinched off if the difference between the gate and
drain voltages is not sufficient to create an inversion layer
𝑉𝐺𝐷 ≤ 𝑉𝑇𝐻 𝑂𝑅 𝑉𝐷𝑆 ≥ 𝑉𝑜𝑣
❑ Square-law (long channel MOS)
𝜇𝑛 𝐶𝑜𝑥 𝑊 2
𝐼𝐷 = ⋅ 𝑉𝑜𝑣 1 + 𝜆𝑉𝐷𝑆
2 𝐿
VGS>VTH VGD<VTH
G
B S D
p+ n+ n+
p-sub
VDS>Vov
05: MOSFET AC 4
Large Signal Model
❑ The channel is pinched off if the difference between the gate and
drain voltages is not sufficient to create an inversion layer
𝑉𝐺𝐷 ≤ 𝑉𝑇𝐻 𝑂𝑅 𝑉𝐷𝑆 ≥ 𝑉𝑜𝑣
❑ Square-law (long channel MOS)
𝜇𝑛 𝐶𝑜𝑥 𝑊 2
𝐼𝐷 = ⋅ 𝑉𝑜𝑣 1 + 𝜆𝑉𝐷𝑆
2 𝐿
ID
G D
05: MOSFET AC 5
Small Signal Approximation
❑ The transistor is a VCCS
❑ Transconductance: how well it converts the voltage to a current
Δ𝐼𝐷 𝜕𝐼𝐷
𝑔𝑚 = =
Δ𝑉𝐺𝑆 𝜕𝑉𝐺𝑆
Δ𝑉𝐷𝑆 1
𝑟𝑜 = =
Δ𝐼𝐷 𝜕𝐼𝐷
𝜕𝑉𝐷𝑆
G D
vgs gmvgs ro
S
05: MOSFET AC 7
Large Signal vs Small Signal Model
G D
VGS IDS ro
S
G D
vgs gmvgs ro
S
05: MOSFET AC 8
Transconductance
❑ The transistor is a VCCS
❑ Transconductance: how well it
converts the voltage to a
current
𝜇𝑛 𝐶𝑜𝑥 𝑊 2
𝐼𝐷 ≈ ⋅ 𝑉𝑜𝑣
2 𝐿
Δ𝐼𝐷 𝜕𝐼𝐷 𝜕𝐼𝐷
𝑔𝑚 = = =
Δ𝑉𝐺𝑆 𝜕𝑉𝐺𝑆 𝜕𝑉𝑜𝑣
𝑊
= 𝜇𝐶𝑜𝑥 𝑉𝑜𝑣
𝐿
𝑊
= 𝜇𝐶𝑜𝑥 ⋅ 2𝐼𝐷
𝐿
2𝐼𝐷
=
𝑉𝑜𝑣
05: MOSFET AC [Sedra/Smith, 2015] 9
Transconductance
𝜇𝑛 𝐶𝑜𝑥 𝑊 2
𝐼𝐷 ≈ ⋅ 𝑉𝑜𝑣
2 𝐿
𝜕𝐼𝐷 𝑊 𝑊 2𝐼𝐷
𝑔𝑚 = = 𝜇𝐶𝑜𝑥 𝑉𝑜𝑣 = 𝜇𝐶𝑜𝑥 ⋅ 2𝐼𝐷 =
𝜕𝑉𝐺𝑆 𝐿 𝐿 𝑉𝑜𝑣
𝑔𝑚 ∝ 𝐼𝐷 𝑔𝑚 ∝ 𝐼𝐷 𝑔𝑚 ∝ 1/𝑉𝑜𝑣
05: MOSFET AC 10
Body Effect
❑ 𝑉𝑆𝐵 affects the charge required to invert the channel
• Increasing 𝑉𝑆 or decreasing 𝑉𝐵 increases 𝑉𝑇𝐻
𝑉𝑇𝐻 = 𝑉𝑇𝐻0 + 𝛾 2Φ𝐹 + 𝑉𝑆𝐵 − 2Φ𝐹
• Φ𝐹 = surface potential at threshold
➢Depends on doping level and intrinsic carrier concentration 𝑛𝑖
• 𝛾 = body effect coefficient
➢Depends on 𝐶𝑜𝑥 and doping
VGS>VTH VGD<VTH
VSB G
B S D
p+ n+ n+
p-sub
VDS>Vov
05: MOSFET AC 11
Bulk Transconductance
❑ The bulk behaves as a second gate that changes the output current
𝜕𝐼𝐷
𝑔𝑚𝑏 = = 𝜂𝑔𝑚
𝜕𝑉𝐵𝑆
05: MOSFET AC 12
Channel Length Modulation (CLM)
❑ The VCCS is not ideal: There is some dependence on 𝑉𝐷𝑆
Δ𝑉𝐷𝑆 1 𝑉𝐴 1
𝑟𝑜 = = = =
Δ𝐼𝐷 𝜕𝐼𝐷 /𝜕𝑉𝐷𝑆 𝐼𝐷𝑆 𝜆𝐼𝐷𝑆
𝜆: Channel length modulation coefficient (𝜆 ∝ 1/𝐿)
𝑉𝐷𝑆 𝑉𝐷𝑆 /𝐼𝐷𝑆 𝜇𝐶𝑜𝑥 𝑊 2
𝐼𝐷 = 𝐼𝐷𝑆 + = 𝐼𝐷𝑆 1 + = 𝑉𝑜𝑣 1 + 𝜆𝑉𝐷𝑆
𝑟𝑜 𝑟𝑜 2 𝐿
VGS>VTH VGD<VTH
G
S D
n+ n+
Leff
p-sub
VDS>Vov
05: MOSFET AC 14
Low-Frequency Small-Signal Model
𝜕𝐼𝐷 𝑊 𝑊 2𝐼𝐷
𝑔𝑚 = = 𝜇𝐶𝑜𝑥 𝑉𝑜𝑣 = 𝜇𝐶𝑜𝑥 ⋅ 2𝐼𝐷 =
𝜕𝑉𝐺𝑆 𝐿 𝐿 𝑉𝑜𝑣
𝑔𝑚𝑏 = 𝜂𝑔𝑚 𝜂 ≈ 0.1 − 0.25
1 𝑉𝐴 1 1
𝑟𝑜 = = = 𝑉𝐴 ∝ 𝐿 ↔ 𝜆 ∝
𝜕𝐼𝐷 /𝜕𝑉𝐷𝑆 𝐼𝐷 𝜆𝐼𝐷 𝐿
G D
vbs
S
B
05: MOSFET AC 15
Short Channel Effects: Velocity Saturation
𝜕𝐼𝐷
❑ ID-VGS quadratic: 𝑔𝑚 = = linear → 𝑔𝑚 increases with 𝑉𝐺𝑆
𝜕𝑉𝐺𝑆
𝜕𝐼𝐷
❑ ID-VGS linear: 𝑔𝑚 = = constant → 𝑔𝑚 saturates
𝜕𝑉𝐺𝑆
05: MOSFET AC 18
References
❑ A. Sedra and K. Smith, “Microelectronic Circuits,” Oxford University
Press, 7th ed., 2015
❑ B. Razavi, “Fundamentals of Microelectronics,” Wiley, 2nd ed., 2014
❑ B. Razavi, “Design of Analog CMOS Integrated Circuits,” McGraw-
Hill, 2nd ed., 2017
❑ N. Weste and D. Harris, “CMOS VLSI Design,” Pearson, 4th ed., 2010
05: MOSFET AC 19