Академический Документы
Профессиональный Документы
Культура Документы
PROFESIONÁLNE
VYTVORENÉ
Prihlásiť sa
DIAGNOSTICKÝ
SOFTVÉR BMW
Získajte prístup k exkluzívnym
programom
predajňa Angličtina Deutsch INFO on-line Blog Kontakt zľava zľava Viac ...
All Posts
Installation instructions:
1.Go to Ediabas folder. For INPA its normally C:\Ediabas\Bin, for ISTA+ its in Ediabas\Bin
folder with ISTA+ directory.
2. If you are using STD:OBD rename existing obd32.dll to obd32.ebas.dll. Users of other
cable types rename respective dll (for example STD:CAN users rename can32.dll to
can32.ebas.dll).
3. Extract the downloaded file.
4. Copy included obd32.dll to Ediabas\Bin. For other cable types rename it to respective
name first (for example can32.dll).
5. For ISTA+ only: copy included NodeISTAVoltageControl.dll to Ediabas\Bin folder within
ISTA+ installation.
6. For ISTA+ v4.05 (and above) only:
a) replace existing IstaOperation.exe within ISTA+'s TesterGUI\Bin\Release folder by
included one (from respective folder based on ISTA+ version).
b) run included AllowFakeISTAOperation.reg file (choose x86 or x64 depending on your
system being 32 or 64 bit respectively).
UPDATE V2.0:
Version 2.0 of this tool has been released. New features:
1. It now checks the actual interface type setting in ISTA during runtime, so if you switch from
Ediabas to ICOM it will stop interfering and resume operation as soon as interface type is set
b k t Edi b
https://www.bmw-ista.com/post/bmw-ultimate-ediabas-ista-voltage-control-v3 1/3
6. 8. 2019 BMW Ultimate Ediabas/ISTA+ voltage control V3
back to Ediabas.
2. It now supports K+DCAN cables which have an ability to detect clamp states (probably
most higher quality cables). To use this feature control application should be closed. It will
then read actual clamp states and update ISTA voltage states accordingly without any
manual actions required. Starting control application will switch the operation to manual
control. Closing it will resume automatic recognition.
UPDATE V3.0:
Version 3.0 of this tool has been released. New features:
1.Control application can now be minimized.
2. Support for ISTA+ v4.05 (and hopefully above).
System requirements: Visual Studio 2015 x86 runtime must be installed (same as required
for last versions of ISTA+).
This voltage control utility is not designed to and will not influence voltages reported
by ICOM
P.P.S. This utility works without any issues with original ISTA+, standalone not
necessary.
43 views
How to Flash Any NBTevo Parts & VIN Decoder & TIS & BMW E-sys Launcher Cheat
ID4 to ID5 or ID6 ECE/US/… ETK & Workshop Useful Li… Codes - How to Make your …
https://www.bmw-ista.com/post/bmw-ultimate-ediabas-ista-voltage-control-v3 2/3
6. 8. 2019 BMW Ultimate Ediabas/ISTA+ voltage control V3
https://www.bmw-ista.com/post/bmw-ultimate-ediabas-ista-voltage-control-v3 3/3