Вы находитесь на странице: 1из 46

PTDI PROCESS SPECIFICATION

Figure 20 Panel Configuration With Film Adhesive


Remarks:
(1) 2 plies per side of N09-0101 or Z-19.101
(2) Film adhesive: the same as that used in the manufacturing of the part.
(3) Honeycomb core materials:
- Non-metallic core type N07-0654 or Z-17.654of 12.7 mm height.
- Metallic core type N07-0527 or Z-17.527of 15 mm height.

• Other Cases : Unless otherwise indicated specific documentation, applicable to a


particular elements, for parts manufactured with glass fiber, core
and other finishing types of prepreg (metallic, carbon fiber, etc.), 1
panel shall be manufactured depending on whether Case I or II
applies, and a panel as indicated in the applicable process
specification to other types of coatings.

11.3 Non-Destructive Inspection

All parts which be made from fiber glass material, laminate and sandwich structure, shall be
inspection by Fokker Bond Tester (MTM12-O-D004-21) or Tapping Method
(MTM12-O-D004-23) or Trough Transmission Ultrasonic (MTM12-O-D004-25). The
classification of acceptance criteria and the method of NDI to be used are according to
engineering and drawing requirements.

11.4 General Acceptance Criteria

a. Table 4, 5, and 6 indicate the general acceptance criteria applicable to typical


discrepancies.
The acceptance criterion is established for each discrepancy, as well as the general
repair/rework method, when applicable.
b. - When any discrepancies below or equal to “acceptable values without repair” are
observed, repair methods shall be unnecessary.
- If the discrepancy is greater than “acceptable values without repair” though below or
equal to “acceptable values with repair” it shall then be necessary to apply/rework
methods such as those indicated in the “correction method” column.

20-O-34-0151 ISSUE : (2nd) August 15, 2016


Page 31 of 46

Вам также может понравиться