Академический Документы
Профессиональный Документы
Культура Документы
SafetyPrcuions
Write the model and serial numbers here for the indoor and
outdoor units:
Dealer's Name
Date Purchased
Operating Instructions
Remote Control Features ...7
OperatingIsuco
Additional Features ..........15 READ THIS MANUAL
?
Inside you will find many helpful hints on how to use and
maintain your air conditioner properly. Just a little
preventive care on your part can save you a great deal of
time and money over the life of your air conditioner.
?
You'll find many answers to common problems in the chart
of troubleshooting tips. If you review our chart of
Troubleshooting Tips first, you may not need to call for
service at all.
CarendMitc
?
Contact the installer for installation of this unit.
?
The air conditioner is not intended for use by young
children or infirm persons without supervision.
?
Young children should be supervised to ensure that
they do not play with the air conditioner.
Troubleshooting tips
Before You
Call For Service ..............22
Troubleshtingp 2
Important safety precautions
Read all instructions before using.
SafetyPrcuions
To prevent injury to the user or other people and property damage, the following instructions must be followed.
Incorrect operation due to ignoring of instruction will cause harm or damage, the seriousness is classified by the
following indications.
properties only.
OperatingIsucoCdm
Installation precautions
WARNING
Do not install, remove and reinstall the unit by yourself.
?
Improper installation will cause water electrical shock, or fire. Please consult authorized
leakage,
dealer orspecialist for the installation work. Please note fault caused by improper installation is not
covered by warranty.
?
Unit must be installed in an easily accessible Any additional cost required
area. to hire a special
equipment to service the unit will be the responsibility of the customer.
CAUTION
Please confirm the following important points during installing.
This room air conditioner must be earthed. The reverse cycle system of the air conditioner
It may cause electrical shock if is based on the air cooling type heat pump
is not which absorbs heated air from the outdoor unit
grounding perfect.
and discharges it indoor.
Therefore if the outdoor unit is exposed to very
Do not install the unit at place where leakage low temperature, specifically below 0°C, the
of gas may occur and/or in an explosive
heating capacity drops off rapidly.
atmosphere.
In case gas leaks, the gas may
accumulates the unit and it may
OPERATING TEMPERATURE(°C)
cause fire ignition.
Troubleshtingp
COOLING MODE
INDOOR OUTDOOR
Confirm drainage piping is connected MAX. MIN. MAX. MIN.
properly. 32°C 21°C 43°C 21°C
3
Operation precautions
generation.
cause
?
It will
If the
be
cause
supply
electrical shock
cord is
damaged,
replaced by the manufacturer or
its service agent or a similarly
qualified person in order to avoid a
or fire.
it must
hazard.
OperatingIsuco ?
Do not
length
cause
or
?
It may cause electrical shock.
Do not insert anything into the
air inlet/air outlet.
?
Since the fan rotates at
speed, this may cause
or damage the unit.
high
an injury
?
This could damage your health.
When
power
?
an abnormality (smell of
operated
or turn off the breaker.
?
or
by
If this is done
relocation should not
the customer.
incorrectly, it may
cause a fire, electric shock, injury
condition, it may cause a fire,
by dropping of the unit, water
damage, etc. In this case, etc. Consult your
leakage,
Troubleshtingp
consult your dealer.
dealer.
4
CAUTION
SafetyPrcuions
When the air filter is to be Do not clean the air Ventilate well when used
removed, do not touch the conditioner with water.
together with a stove, etc.
metal parts of the indoor unit.
?
It may cause an injury. An oxygen
?
Water may enter the unit and ?
shortage may occur.
?
Should be disconnected from degrade the insulation. It may
supply cause an electric shock.
OperatingIsucoCdm
When the unit is to be Do not put a pet or house Do not use for special
cleaned, switch off, and turn plant where it will be
purposes.
off the circuit breaker. exposed to direct air flow.
?
Since the fan rotates at high ?
This could injure the pet or plant. ?
Do not use this air conditioner to
speed during operation, it may preserve precision devices, food,
cause an injury. animal, plants, and art objects.
It may cause deterioration of
quality, etc.
Do not operate switches Do not apply an insecticide Do not put a stove, etc.
with wet hands. or flammable spray. where is exposed to direct
air flow.
?
It may cause an electric shock. ?
It may cause a fire or deformation ?
It may affect combustion.
of the cabinet.
5
Troubleshtingp
CAUTION For installation
?
If not, dirt may collect and
cause a fire.
?
Do not operate for a long
time in high humidity, e.g.
leaving a door or window
open.
In the cooling mode, if it is
operated in a room with high
humidity (80%RH or more) for
a long time, water condensed
CAUTION
installing the
OperatingIsuco
interrupter depending on the
place where the air
conditioner is to be installed.
(humid place, etc.)
an electric shock.
?
It may cause an injury through ?
It may cause an injury, etc. by
dropping or falling down. falling down.
CarendMitc
?
If gas leaks and collect around the
unit, it may cause an explosion.
?
If the drainage route is incomplete,
water may drop from the unit. It
Troubleshtingp
may wet and spoil furniture.
6
About the remote control on the system
1
transmitter
SafetyPrcuions
2
3
Heat pump model
Cooling model
OperatingIsucoCdm
4 8
5 9
6 10
11
Flip-up door(opened)
Troubleshtingp
TIME SETTING BUTTONS RESET BUTTON
5 Used to adjust the time. 11 Used prior to resetting time or after
replacing batteries.
TIMER SET/CANCEL BUTTONS
6 Used to set the timer when the desired time
is obtained and to cancel the Timer
operation.
7
SafetyPrcuions
Features of the Remote Control- Door Closed
1
2
OperatingIsuco
Heat pump model
Cooling model
4 5
Flip-up door(closed)
CarendMitc
button is pressed and stops Used to select fan speed in four
when the button is pressed again. steps-low, medium, high, or
CHAOS.
OPERATION MODE
2 SELECTION BUTTON JET COOL
Used to select the operation mode.
5 Used to start or stop the speed
cooling. (Speed cooling
ROOM TEMPERATURE operates super high fan speed
3 SETTING BUTTONS in cooling mode.)
Used to select the room
temperature.
Operation Mode
Troubleshtingp
Auto Operation
Auto Operation
Healthy
Dehumidification
Operation
Healthy
Dehumidification
Operation Heating Operation
(Cooling Model) (Heat Pump Model)
8
About the remote control on the system
SafetyPrcuions
?
The remote control may be stored inside the system ?
To operate the room air conditioner, aim the
or mounted on a wall.(except 7K, 9K model) remote control at the signal receptor.
?
The remote control will operate the air
conditioner at a distance of up to 7m.
OperatingIsucoCdm
How to Insert the Batteries
Remove the battery cover by pulling NOTES:
it according to the arrow direction. ?
Use 2 AAA(1.5volt) batteries. Do not use
Insert new batteries making sure that rechargeable batteries.
the (+) and (-) of battery are installed
?
Remove the batteries from the remote
correctly. control if the system is not going to be
used for a long time.
Reattach the cover by sliding it back
into position.
AUTO RESTART: In case the power comes on again after a power failure, the air FORCED
OPERATION
conditioner will operate in "Auto Restart Operation" mode. This function automatically AUTO
RESTART
returns the air conditioner to the pervious operating conditions.
REMOTE
CONTROL
REMOTE CONTROL: If you do not want to use Auto Restart Operation
Signal Receptor
Receives the signals from the remote control.
(Signal receiving sound: two short beeps or one long beep.
Operation Indication Lamps
On/Off : Lights up during the system operation.
Slide Switch
Sleep Mode : Lights up during Sleep Mode Auto operation.
Troubleshtingp
Timer : Lights up during Timer operation.
Defrost Mode : Lights up during Defrost Mode or Hot Start operation
(Heat pump model only)
Signal receptor
OUT OUTDOOR : Lights up during outdoor unit operation.
indication
DOOR UNIT (Cooling model only) Operation lamps
OPERATION
9
How to use the Operation Mode Selection button
SafetyPrcuions
Cooling Operation
Press the Start/Stop button. The unit will respond with a beep.
1
OperatingIsuco 2
Open the door on
Operation, press
Cooling
the remote control. To select Cooling
the Operation Mode Selection button.
Each time the button is pressed, the operation mode is shifted
in the direction of the arrow.
Auto Healthy
Dehumidification (Heat
Heating
pump model only)
CarendMitc
Close the door on the remote control. Set the temperature
3 lower than the room temperature. The temperature can be set
within a range of 18°C~30°Cin 1°C increments.
Set the fan speed again with the door of the remote control
4 still closed. You can select the fan speed in four steps-low,
Troubleshtingp
medium, high, or CHAOS. Each time the button is pressed,
the fan speed mode is shifted.
10
SafetyPrcuions
Auto Operation
Press the Start/Stop button. The unit will respond with a beep.
1
OperatingIsuco
the remote control. To select Auto
2 Operation, press the Operation Mode Selection button.
Each time the button is pressed, the operation mode is shifted
in the direction of the arrow.
Carendmitc
3 electronic controls based on the actual room temperature. If
you want to change the set temperature, close the door on
the remote control and press the Room Temperature Setting
buttons. The cooler or warmer you feel, the more times (up to
two times) you should press the button. The set temperature
will then be changed automatically.
Troubleshtingp
You cannot switch the indoor fan speed. It has already been set by the Fuzzy rule.
If thesystem is not operating as desired, manually switch to another mode. The system will not
automatically switch from the cooling mode to the heating mode, or from heating to cooling, it must
be done by manually resetting.
During Auto Operation, pressing the Airfllow direction Start/Stop button makes the horizontal louvers
swing up and down automatically. If you want to stop auto-swing, press the Airflow Direction
Start/Stop button again.
11
SafetyPrcuions
Healthy Dehumidification Operation
Press the Start/Stop button. The unit will respond with a beep.
1
OperatingIsuco 2
Open the door on the remote control. To select Healthy
Dehumidification Operation, press the Operation Mode
Selection button.
Each time the button is pressed, the operation mode is shifted
in the direction of the arrow.
Troubleshtingp
In this case, however, the setting temp. is not displayed in the remote controller and you are not
able to control the room temp. either.
During the healthy dehumidification function, the airflow volume is automatically set according to the
optimization algorithm responding to the current room temp. status and makes the room condition
healthy and comfortable even in the high humidity season.
12
Heating Operation(Heat pump model only)
1
Press the Start/Stop button. The unit will respond with a beep.
SafetyPrcuions
2
Open the door on
Operation, press
the remote control. To select Heating
the Operation Mode Selection button.
Each time the button is pressed, the operation mode is shifted
in the direction of the arrow.
Set the fan speed again with the door of the remote control
4 still closed. You can select the fan speed in four steps--low,
medium, high, or CHAOS. Each time the button is pressed,
Troubleshtingp
the fan speed mode is shifted.
13
SafetyPrcuions
Jet Cool Operation
Press the Start/Stop button. The unit will respond with a beep.
1
OperatingIsuco 2
Press the Jet Cool button to operate the speed cooling mode
and the unit will operate in super high fan speed on cooling
mode for 30 minutes.
CarendMitc
To cancel the Jet Cool mode, press the Jet Cool button
3 again or the fan speed button or the room temperature setting
button and the unit will operate in high fan speed on cooling
mode.
or or
NOTE:
During the JET COOL function at any moment, the A/C starts to blow the cool air at extremely
Troubleshtingp
high speed for 30 minutes setting the room temp. automatically to 18°C. It is especially used
to cool the room temp. in the shortest time in a hot summer.
In heat pump mode or neuro fuzzy mode however, the power cooling function is not available.
In order to return to the normal cooling mode from the JET COOL mode, you just press either
the operation mode selection button, airflow volume selection or temp. setting button or the
power cooling button again.
14
Additional features
Sleep Mode
2
Press the Sleep Mode Auto button to
set the time you want the unit to turn off
automatically.
OperatingIsucoCdm
Press the Time Setting buttons until
Time can be set only when you have pressed 2
the Reset button. If you have just replaced the the desired time is set.
batteries, the Reset button should be pressed
to reset the time.
3
NOTE: Check the indicator
for A.M. and P.M.
Troubleshtingp
NOTE: Select one of the following four types of operation.
with the unit running
Delay OFF Timer Delay ON Timer Delay OFF and ON Timer Delay ON and OFF Timer
15
Airflow Direction (Indoor unit)
SafetyPrcuions
The up/down airflow (Vertical Airflow) can be NOTE:
adjusted by using the remote control. If you press the CHAOS swing button, the
horizontal airflow direction is changed
automatically based on the CHAOS algorithm
to distribute the air in the room evenly and at
the same time to make the human body feel
most comfortable, as if enjoying a natural
breeze.
Always use the remote control to adjust the
up/down airflow direction. Manually moving the
vertical airflow direction louver by hand could
damage the air conditioner.
When the unit is shut off, the up/down airflow
direction louver will close the air outlet vent of
OperatingIsuco
the system.
To adjust left/right(Horizontal Airflow) direction
Press the Start/Stop button to start the unit.
1 Caution : Ensure unit is turned off before adjusting
the horizontal airflow direction control.
Carefully open vertical louver to allow
access to the horizontal airflow direction.
CarendMitc 1
2
Air Circulation Mode
Circulates the
Press the
Open
room
Start/Stop
air without cooling
the door on the remote control. Press the Air Circulation button. Close the door on the
remote control. Now each time that you press the Indoor Fan Speed Selector, the fan speed
is shifted from low to CHAOS and back to low again.
Troubleshtingp NOTE:
CHAOS Air Fan speed is on low. Fan
CHAOS Air economizes power consumption and prevents overcooling. The fan speed is
speed is
automatically changed from medium to low or vice versa, depending on the ambient temperature.
16
on medium. Fan speed is on high.
Slide Switch Operation
FORCED OPERATION
AUTO
RESTART
REMOTE
CONTROL
Slide Switch
SafetyPrcuions
automatically set as follows:
panel upward
During Forced Operation, the initial mode continues.
OperatingIsucoCdm
< <
AUTO RESTART
In casethe power comes on again after a power
failure, Auto Restarting Operation is the function to
Slide Switch
operate procedures automatically to the previous
conditions. Slide FORCED
operating OPERATION
Switch
In case the air conditioner does not receive any signal AUTO
RESTART
17
Troubleshtingp
Operation Details
For
Speed
morefresh feeling than other fan speed, press the Indoor Fan
Selector and set to CHAOS mode. In this mode, the wind
blows like natural breeze by automatically changing fan speed
according to the CHAOS logic.
The
speed
capacity will
High fan
cool the
and cooling capacity.
cooling capacity
the value when the fan
be lower
indicated in the
speed
speed is recommended
room quickly.
specification is
is set to
high, and the
at low or medium fan speed.
CarendMitc
Troubleshtingp 18
Care and maintenance of the air conditioner
CAUTION: Before performing any maintenance, turn off the main power to the system.
SafetyPrcuions
Indoor Unit
Powder
Gasoline
OperatingIsucoCdm
Air Filters
The air filters behind the front grille should Lift the front access panel and pull the filter tab
1 forward to remove the filter.
be checked and cleaned once every 2 slightly
weeks or more often if neccessary.
Clean the filter with a vacuum or warm, soapy
2
water.
?
If dirt is conspicuous, wash with a solution of
detergent in lukewarm water.
?
If hot water (40°C or more) is used, it may be
deformed.
Outdoor Unit
The heat exchanger coils and panel vents of
(Rear)
the outdoor unit should be checked regularly.
If clogged with dirt or soot, the heat Air intake vents
(Side)
Piping
exchanger and panel vents may be
professionally steam cleaned. Drain Hose
NOTE:
Troubleshtingp
efficiency of the system and cause higher (Rear)
operating costs.
Piping
(Side)
Air intake vents
Drain Hose
19
When the air conditioner is not going to be used for a long time.
OperatingIsuco
Clean it before
?
This will dry out the internal mechanisms. installing
CAUTION
CarendMitc
cause a
Helpful information
Troubleshtingp
Wasted
The air filters are your electiric bill.
If the air filters become clogged with dust, the cooling
capacity will drop, and 6% of the electricity used to
operate the air conditioner will be wasted.
20
Operation Tips
This is not
and
good for the
wastes electricity.
room.
health
Keep
closed.
blinds or curtains
Adjust
ensure a
in the
the room temperature
room.
uniform temperature
SafetyPrcuions
OperatingIsucoCdm
4~6°C
Make sure that the doors Clean the air filter regularly. Ventilate the room
and windows are shut tight. occasionally.
21
Troubleshtingp
Before you call for service...
SafetyPrcuions
Troubleshooting Tips! Save time and money!
?
Check the following points before requesting repairs or service.... If the fault persists,
please contact your dealer or service center.
Does not operate. The room has a It seems that Air conditioner does not
peculiar odor. condensation is leaking operate for about 3
from the air conditioner. minutes when restarted.
OperatingIsuco ?
?
Have you made
mistake in timer
operation?
Has the fuse blown
has the circuit breaker
been tripped?
or
or
heat
?
Check that this is not
damp
the walls,
furniture,
in the
smell exuded
carpet,
or
room.
cloth items
Remote control
is faint, or no
at all.
occurs
air.
display
display
?
?
This is the
the mechanism.
Wait about three
minutes and
will begin.
protector of
operation
CarendMitc ?
?
Is the air filter
See air filter
instructions.
(Refer
Has the
been set
to page
dirty?
cleaning
19)
temperature
incorrectly?
Are the indoor unit's air
?
?
For
For
a
like water
like the
noise that sounds
flowing.
-This is the sound of
freon flowing
air conditioner unit.
inside the
?
Are the batteries
depleted?
Are the batteries
inserted in the
(+) and (-)
opposite
directions?
?
This sound is
generated by the
expansion/constriction
of the front panel, etc.
due to changes of
temperature.
Troubleshtingp
-This is the sound of
the dehumidifying
water being processed
inside the air
conditioning unit.
NOTE
WATER RESISTANT: The outdoor side of this appliance is WATER RESISTANT.
The indoor side is not water resistant and should not be exposed to excess water.
22
P/No.: 3828AR7216W Printed in Korea