Академический Документы
Профессиональный Документы
Культура Документы
Soil grains consists of inert rock materials (cobble, gravel, sand and silt) often
combined with significant amounts of clay (say more than 5%). While inert silt
grains may be angular or rounded (thus contributing to greater or less angle of
internal friction), particles of clay are small platelets with negative charges on
both faces which attract the positively charged ends of water molecules. Thus
bond is responsible for the cohesion ends of water molecules. This bond is
responsible for the cohesion “C” of clay.
Silt or sand with appreciable amounts of clay (say more than 15%) behaves like
clayey soil since the permeability of clay is of the order of 10-7 cm/s compared
to 10cm/s for sand. This capacity of the clay to hold the water molecules for
long even when the pressure is applied on the soil, greatly influences its
behaviour, i.e. shear strength, compressibility and permeability.
a) Clay lumps are more difficult to crush with fingers than silt. When moistened,
the soil lump surface texture is felt with the finger. If it is smooth, it is clay, if
rough it is silt.
b) A ball of the soil is formed and shaken horizontally on the palm of the hand.
If the material becomes shiny from water coming to the surface, it is silt.
c) If soil containing appreciable percent of clay is cut with a knife, the cut
surface appears lustrous. In case of silt, the surface appears dull.
4) Colour of the soil indicates its origin and the condition under which it was
deposited. Sand and gravel deposits may contain lenses of silt, clay or even
organic deposits. If so, the presumptive bearing capacity is reduced.
Based on the field identification of the soil, the presumptive bearing capacity of
the soil can be guessed by referring to Table-2 of IS:1904 – 1986. The
objectives of preliminary soil investigations are to drawn up an appropriate
program for detailed soil investigation and to examine the sketch plans and
preliminary drawings prepared by the Architect from the point of suitability of
the proposed structure.