Академический Документы
Профессиональный Документы
Культура Документы
Lista de Componentes
13x - SR3100
1x - arduino nano/uno/mega
2x - ir2110
1x - 7804 (not-gate)
1x - lm2576-5.0
1x - lm2576-12.0
the load is the M connecting the two sets of switches. Using one
current source, you can drive current in two directions by
closing two switches.
If Q1 and Q4 are closed, then the current will flow from the
LEFT to RIGHT on this image:
If Q3 and Q2 are closed, then the current will flow from the
RIGHT to LEFT on this image:
if you are going to use a 12v battery make sure to use 10v
single tap transformer, you can use 11v, or 12v, but 10v, is
better. just like the 24v battery, choose 22v single tap
transformer. 23v, 24v but 22v is better.
in 12v system you want to carry about 500w of load. (if you buy
a ready made transformer make sure it is 500w)
if you build your own using ohms law
I(current)= Power/Volts
500w / 10v = 50amps
make sure your transformer can carry at the low voltage side at
maximum 50 amps into the wire. (better if you put an allowance)
make sure your mosfet can carry the load you want to power.
i recomend irf3205, you can parallel your mosfet for the load
you want to carry.
Step 4: Build
http://www.hobbytronics.co.uk/arduino-xloader
go to this website and follow the instruction