Академический Документы
Профессиональный Документы
Культура Документы
http://www.masibus.com
MODEL 408
+
K T/C -100 to 1372 C
T T/C -100 to 400 C
2. RTD Pt-100,3 wire : 4. mA Input:
R T/C 0 to 1768 C
S T/C 0 to 1768 C 3 4 5 2 3 4
-
+
Accuracy For T/C & RTD +/-(0.25% of FS + 1 count)
*
LINK
For Linear +/-(0.1% of FS + 1 count)
Transmitter power 24VDC @ 30mA 3. Volt Input : 5. Two wire loop:
supply 1 2 3 4
2 3 4
Zero adjustment automatic by software -
+
Calibration -
+
*
LINK LINK
CJC adjustment for T/C type input and span V
adjustment by trimpot at the back of the 250 Ohms,0.1%(USE EXTERNALLY)
instrument *
Wiring Precautions
Power supply 230V/110V AC@50Hz or 24VDC (factory set)
1.- Ensure the wires connected to rear terminals are propely done as
Operating Ambient 0 to 55 Deg C
Shown rear terminal connection table.
Humidity Up tp 95% RH non-condensing 2.- Turn OFF power, before changing the wiring of the temperature
Power Consumption Less than 10VA sensor and other wiring.
3.- Be sure to match compensating cable with the thermocouple type.
Physical Bezel size 96 x 48 mm also ensure that the polarity of compensating cable properly
Panel cutout 92 x 45 mm Connected.
Depth behind Panel 160 mm 4.- Ensure that the compensating cable/signal wire route separately from
Cassette ( Suitable for wire size of 2.5 Sq. mm) power wires to prevent electrically induce noise.
=45
2. CONFIGURE ZERO
DISPLAY NOTE:-
After adjusting ZERO & SPAN value, once again check ZERO &
PRESS
SPAN value for any deviation.
To change desire value of zero, Run mode is the normal mode of display. From configuration mode of
operations,display falls back to this mode if no key is pressed for
PRESS
60 seconds..
The unit having provision for programming operating range by
PRESSING KEY TO SAVE THE ZERO VALUE AND NEXT
ZERO & SPAN setting. In case sensor getting open then dsplay shows
PARAMETER ON DISPLAY. “ OPEN” or in case the value of PV out side the SPAN value it’s shows
“OVER” message on display.
3. CONFIGURE SPAN
DISPLAY
PRESS
PRESS
DISPLAY
PRESS
PRESS
Calibration
Instrument factory calibrate for one type input as per customer purchase order.
Change of input is subject to recalibration.
DISPLAY