Академический Документы
Профессиональный Документы
Культура Документы
: +4598571911
Smedevænget 3 Fax: +45 98 57 13 87
DK-9560 Hadsund E-mail: hjl@hjlubri.dk
Working area:
The working area is the
“Stroke Lengths” currently Change Operation settings:
possible. If changes are made to the
It is limited by the mechanical operation settings, regulation,
adjusted stroke length and by feed rate, etc. The stroke
the minimum amount of lube calculator should be used to
oil allowed. get the right stroke length
adjustment(s).
Current needed stroke length:
The dark green arrow indicates Click the button to show
the current needed stroke Stroke calculations. (See next
length, based on current engine page)
state and selected regulation.
While the arrow is inside the
working area the lube oil
regulation is optimal.
Adjustment needed:
When the dark green arrow
moves out of the working area
the mechanical stroke length
needs to be adjusted. If not
adjusted over-/ under-
lubrication error will occur.
Working area:
The working area is the “Stroke
Lengths” currently possible. Change Operation settings:
It is limited by the mechanical If changes are made to the
adjusted stroke length and by operation settings, regulation,
the minimum amount of lube oil feed rate, etc. The stroke
allowed. calculator should be used to
get the right stroke length
adjustment(s).
Current needed stroke length:
The dark green arrow indicates Click the button to show
the current needed stroke Stroke calculations. (See next
length, based on current engine page)
state and selected regulation.
While the arrow is inside the
working area the lube oil
regulation is optimal.
Adjustment needed:
When the dark green arrow
moves out of the working area
the mechanical stroke length
needs to be adjusted. If not
adjusted over-/ under-
lubrication error will occur.
Upload Configuration:
Changes to the Operation Setup, No Changes affects the
Regulation, Overlay and Load change lubrication before the “Upload
(Software), can be made. The setup is Configuration” button is
the same for all cylinders. pressed.
Mechanical stroke:
Planned Operation: Adjust the mechanical stoke
Maximum planned engine load length so the current conditions
should be inserted. are within the working area.
With Sulphur regulation there can be Make sure to adjust the lubricator
planned two profiles (one for low and to the same stroke length.
one for high Sulphur), where the NOTE: The individual stroke
needed stroke length can be lengths, on the same cylinder,
calculated. must have the same stroke length
Like the normal operation page the current working area are indicated. The purple colored bars show the current needed stroke lengths for the current S%/TBN.
If it is inside the working area no adjustment should be needed. If the bottom of the purple bars is lower than the greens, it can result in over-lubrication at low
engine load. Likewise, if the top of the purple bars is higher than the green bars, it can result in under-lubrication at high engine loads.