Академический Документы
Профессиональный Документы
Культура Документы
*Note: Optional ingredients (if you chose not to use fly ash set cement/cementitious ratio to 1)
¥Note:Air Entrainer - Recommanded Dosage of Micro-Air (8 - 98ml/100kg of Cement)
Indicate the variables in the mixture design and admixture
Instructions
You can only change whats in the yellow boxes.
Step 1: You want to know your water/cementitious ratio to find the strength if the concrete.
Indicates the Water/Cementitious Ratio
Step 2: Look on Table 4: Water Requirement and chose the amount of slump that you want, (20mm max size of
aggregate). In thus case the slump doesn't matter much because we aren't working the concrete much.
Indicates the Water
Step 3: Density is obtained by changing the amount (kg/m3) of total fine aggregate, gravel, and by changing the
cement/cementitious ratio. To adjust the density use goal seeker to always keep the yield at 1m3. In goal Seeker,
set cell to E34, value to 1, and change either the total fine or the gravel to find an answer
The Density is what you are looking for when designing the mix
Step 4: The dosage of admixture is last, I don't know how much air it will give so you have to take a guess!
Cement Fly Ash Expanded PSand Gravel Water
Mass (g) Needed 1088.8254 1088.8254 22.196798 1087.6431 3824.961118 771.92036
Percent Passing
Grada
Sieve (mm) Sand Expanded Polystrene Beads Composite
9.5 1 1 1
4.75 1 1 1
1
2.36 0.8 1
1.18 0.5 0.85
Indicate the variables in the gradation table 0.6 0.25 0.6
0.6
your strength.
0.3
0.2
0.1
0.1
S ieve
Gradation Curve
Upper Limit
Low er Limit
Upper Limit
Composite Mix
1 10
S ieve S ize (m m )
1
0.9
0.8
0.7
L ow e r L imit
0.6
U p pe r L imit
0.5
0.4
0.3
0.2
0.1
0.1 1 10