Академический Документы
Профессиональный Документы
Культура Документы
Item Amount
Item Unit Quantity Rate (Rs.)
No. (Rs.)
Rebat
e
BILL NO.1 GENERAL PROVISIONS
1.01 (i) Providing rental accomodation of 100 Sqm carpet area for base
office for the employer and his staff complete as per Technical
Specification Clause 122, along with all furniture etc. detailed Month 12.00 24269.44 291233.28
therein.
(ii) Maintenance of Base office & its furniture & equipments Month 12.00 12195.10 146341.2
1.02 Providing and maintaining vehicles for the Employer including
providing driver, POL etc. complete as per Technical Specification
Clause 123.
a) Hard top Vehicle with AC, Power Steering, etc. Veh. 360.00 1804.84 649742.4
Days
1.03 Supply of colour photographs three prints of Size 6"x 4" mounted in
album completed with soft copy in DVD No. 189.00 85.00 16065
1.05 Carrying out video shooting of roads i/c bridges showing landmarks
such as Km. stones, buildings, and
other sailent features along the road in 3 DVDs i/c cost of hiring of
vehicle ,Video camera of good quality, other equipments, manpower per Km. 12.60 50.00 630
etc and i/c editing/lattering on film before/after construction of
road.
Item Amount
Item Unit Quantity Rate (Rs.)
No. (Rs.)
Rev-04 PAGE 2 OF 26
MP ROAD DEVLOPMENT CORPORATION
Widening and reconstruction of Rampayali Garra Chouki Road
LIMITED
Bill of Quantities of ADB-V
Item Amount
Item Unit Quantity Rate (Rs.)
No. (Rs.)
(a) Earth with CBR more than 5% in embankment cum 0.00 168.00 0
(b) Earth with CBR more than 8% in subgrade 66326.40 178.00 11806099.2
(c) Earth with CBR more than 12% for shoulders above drainage layer
cum 33328.64 223.00 7432286.72
Rev-04 PAGE 3 OF 26
MP ROAD DEVLOPMENT CORPORATION
Widening and reconstruction of Rampayali Garra Chouki Road
LIMITED
Bill of Quantities of ADB-V
Item Amount
Item Unit Quantity Rate (Rs.)
No. (Rs.)
(i) For Drainage layer GSB grading- VI Material as per Table 400-1.
cum 23722.92 943.00 22370714
5.02 Providing and applying tack coat with bitumen emulsion using
emulsion pressure distributor on the prepared bituminous / granular
surface cleaned with mechanical broom and as per relevant clauses
of Section-500.
Rev-04 PAGE 4 OF 26
MP ROAD DEVLOPMENT CORPORATION
Widening and reconstruction of Rampayali Garra Chouki Road
LIMITED
Bill of Quantities of ADB-V
Item Amount
Item Unit Quantity Rate (Rs.)
No. (Rs.)
5.04 Providing and laying dense bituminous macadam with hot mix plant
using crushed aggregates of specified grading, premixed with
bituminous binder, transporting the hot mix to work site, laying with
sensor paver finisher to the required grade, level and alignment,
rolling with smooth wheeled, vibratory and tandem rollers to
achieve the desired compaction complete in all respects and as per
relevant clauses of Section-500. (Only cement will be used as filler).
(i) for Grading II ( 30-40 mm thickness ) with (VG-30) Cum 0.00 9901.00 0
5.06 Construction of dry lean cement concrete Sub- base over a prepared
sub-grade with coarse and fine aggregate conforming to IS: 383, the
size of coarse aggregate not exceeding 25 mm, aggregate cement
ratio not to exceed 15:1, aggregate gradation after blending to be as
per table 600-1, cement content not to be less than 150 kg/ cum,
optimum moisture content to be determined during trial length
construction, concrete strength not to be less than 10 Mpa at 7 days,
mixed in a batching plant, transported to site, laid with paver with
electronic sensor, compacting with 8-10 tonnes vibratory roller,
finishing and curing and as per relevant clauses of Section-600
(including cost of all types of formworks). Cum 9459.45 2714.00 25672947.3
Rev-04 PAGE 5 OF 26
MP ROAD DEVLOPMENT CORPORATION
Widening and reconstruction of Rampayali Garra Chouki Road
LIMITED
Bill of Quantities of ADB-V
Item Amount
Item Unit Quantity Rate (Rs.)
No. (Rs.)
5.08 Filling Pot- holes and Patch Repairs with open - graded Premix
surfacing, 20mm. including removal of all failed material, trimming
of completed excavation to provide firm vertical faces, cleaning of
surface, painting of tack coat on the sides and base of excavation as
per clause 503, back filling the pot holes with hot bituminous
material as per clause 510, compacting, trimming and finishing the
surface to form a smooth continuous surface, all as per clause Sqm 0.00 153.00 0
3004.2.(For maintenance of road only).
5.09 Repair of pot holes/ patch repair with Grading - IV granular material
meeting requirement in the Table 400-1 & 400-2 of the specification
including its maintenance as directed by the Engineer. (For Cum 0 777.19 0
maintenance of road only).
Item Amount
Item Unit Quantity Rate (Rs.)
No. (Rs.)
6.02 Providing and laying in position plain cement concrete of grade M-15
in levelling course below open foundation, pile caps, approach slabs,
retaining walls, return walls/wing wall, cut off walls, CC drain and
inspection ladders etc. complete as per drawing and relevant clauses
of Section 1100, 1500, 1700, 2100 & 2700 (including cost of all types
of formworks). Cum 0.00 4777.00 0
6.03 Providing and laying plain cement concrete for foundation and
substructure of piers, abutment, retaining wall, return wall, wing
wall, head wall, pillar, guard wall and CC drain etc.excluding cost of
skin reinforcement, but including treatment of joints between
existing & new structures with all leads and lifts as per drawings and
relevant clauses of Sections 1500, 1700, 2100, 2200, and 2900
(including cost of all types of formworks).
Rev-04 PAGE 7 OF 26
MP ROAD DEVLOPMENT CORPORATION
Widening and reconstruction of Rampayali Garra Chouki Road
LIMITED
Bill of Quantities of ADB-V
Item Amount
Item Unit Quantity Rate (Rs.)
No. (Rs.)
6.08 Providing Back filling behind abutment, return wall, wing wall and
Hume pipe trench with Granular Material complete as per drawing
and Technical specification and as per relevant clauses 305 of
specifications and as per appendix 6 of IRC-78. Cum 0.00 978.00 0
6.09 Providing and laying of Filter media with Crusher Broken Metal
satisfying the requirements laid down in clause 2504.2.2. of MORTH
specifications to a thickness of not less than 600 mm with smaller
size towards the soil and bigger size towards the wall and provided
over the entire surface behind abutment, wing wall and return wall
to the full height compacted to a firm condition complete as per Cum - 1241.00 0
drawing and technical specification.
6.10 Providing and fixing in position bearings true to line and level
including all accessories complete as per drawings and technical
specification Section 2000.
Rev-04 PAGE 8 OF 26
MP ROAD DEVLOPMENT CORPORATION
Widening and reconstruction of Rampayali Garra Chouki Road
LIMITED
Bill of Quantities of ADB-V
Item Amount
Item Unit Quantity Rate (Rs.)
No. (Rs.)
6.12 Providing and laying of asphaltic plug joint to provide for horizontal
(a) movement of 25 mm and vertical movement of 2 mm, depth of
joint varying from 75 mm to 100 mm, width varying from 500 mm
to 750 mm (in traffic direction), covered with a closure plate of
200mm x 6mm of wieldable structural steel conforming to IS: 2062,
asphaltic plug to consist of polymer modified bitumen binder,
carefully selected single size aggregate of 12.5 mm nominal size and
a heat resistant foam caulking/backer rod, all as per approved
drawings and specifications and as per relevant clauses of Section meter 1345.00 0
2600.
(b) Providing and fixing 2mm thick corrugated copper plate expansion
joint with 20mm thick compressible fiber board below the copper
plate to protect the edges, filling with 20mm thick pre-moulded joint
filler over copper plate and sealed with joint sealing compound
consisting of coarse sand and 6% bitumen by weight as per drawings
and relevant technical specification complete. RM 4410.00 0
6.14 Providing and fixing RCC railing of M30 Grade with 12 mm nominal
size aggregate, true to line and grade, tolerance of vertical RCC post
not to exceed 1 in 500, centre to centre spacing between vertical
post not to exceed 2000 mm, leaving adequate space between
groove in vertical post and horizontal rail for expansion, complete
as per approved drawings and technical specifications and as per
relevant clauses of Sections 1500, 1600, 1700 and clause 2703 of
specifications (as per MORT & H specification drawing SD/201 or RM - 2142.00 0
SD/304).
6.15 Providing and fixing 40mm dia steel pipe (medium weight) railing in
3 rows on steel channel ISMC-100mmx50mm and 0.95 in height and
fixed at 1.8m. center to center and duly painted etc. complete as per
standard drawing No.STD-33R. RM 1520.00 0
Rev-04 PAGE 9 OF 26
MP ROAD DEVLOPMENT CORPORATION
Widening and reconstruction of Rampayali Garra Chouki Road
LIMITED
Bill of Quantities of ADB-V
Item Amount
Item Unit Quantity Rate (Rs.)
No. (Rs.)
6.17 Testing of span of bridge for deflection due to live load with
platforms for loading arrangements, apparatus for meaurement
including required loading, unloading etc. complete as per approved Ton 905.00 0
drawing.
6.18 Providing and laying boulders apron/toe wall on river bed for
protection against scour with stone boulders weighing not less than
40 kg each complete as per drawing and Technical specification and
as per relevant clauses of Section 2500.Technical specifications and
as directed by the Engineer-in-charge. Cum 2259.00 0
6.19 Providing and laying Pitching on slopes laid over prepared filter
media, Dry boulder toe wall complete as per drawing and Technical
specifications and as per relevant clauses of Section 2500.
6.21 Providing and laying Flooring comprising of 150mm thk Flat stone
laid over 300mm thk cement concrete M15 complete as per drawing
and Technical specifications bedding and as per relevant clauses of
Section 1400, 1700 & 2500. sqm - 5080.00 0
Rev-04 PAGE 10 OF 26
MP ROAD DEVLOPMENT CORPORATION
Widening and reconstruction of Rampayali Garra Chouki Road
LIMITED
Bill of Quantities of ADB-V
Item Amount
Item Unit Quantity Rate (Rs.)
No. (Rs.)
6.25 Providing and inserting nipples with approved fixing compound after
drilling holes for grouting as per Technical specifications including
subsequent cutting/removal of nipples and sealing of the hole as
necessary after completion of grouting and as per relevant clauses of No - 109.00 0
Section 2800.
a) Epoxy kg - 2009.00 0
b) Cement mortar (1:1) grouting Kg 144.00 0
c) Cement grouting kg 70.00 0
6.27 Patching of damaged concrete surface to the required thickness with
polymer concrete and curing compounds, initiator and promoter,
available in present formulations, to be applied as per instructions
of manufacturer and as approved by the Engineer and as per
relevant clauses of Section 2800. sqm 1930.00 0
6.30 Providing and Applying 10mm thick (Average) epoxy mortar over
leached, honey combed and spalled concrete surface and exposed
steel reinforcement complete as per Technical specification and as
per relevant clauses of Section 2800. sqm 1025.00 0
Rev-04 PAGE 11 OF 26
MP ROAD DEVLOPMENT CORPORATION
Widening and reconstruction of Rampayali Garra Chouki Road
LIMITED
Bill of Quantities of ADB-V
Item Amount
Item Unit Quantity Rate (Rs.)
No. (Rs.)
6.32 Providing and laying new drainage spout including making the joint
of drainage spout with slab water tight with non shrink, free flow
cement grout and drilling hole in RCC slab and cutting chaases in
slab of required size for fixing drainage spout complete as per
drawings and technical specificaions section 2700 and 2800. Nos. 1327.00 0
6.33 Providing Stone masonry work in cement mortar 1:3 for foundation,
substructure, superstructure complete as per drawing and Technical
Specifications and as per relevant clauses of Sections 1400.
Rev-04 PAGE 12 OF 26
MP ROAD DEVLOPMENT CORPORATION
Widening and reconstruction of Rampayali Garra Chouki Road
LIMITED
Bill of Quantities of ADB-V
Item Amount
Item Unit Quantity Rate (Rs.)
No. (Rs.)
6.39 Painting two coats after filling the surface with synthetic enamel
paint in all shades on new/old plastered/concrete surfaces and as
per relevant clauses of section-800 & I.R.C.-67 including cost of paint
etc. complete. sqm - 59.00 0
6.41 Providing and filling annular space around foundation in rock with
lean cement concrete M-15 nominal mix with crushed stone
agreegate 40m nominal size and as per relevant clauses of sec. 1500,
1700 & 2100. cum 4777.00 0
Rev-04 PAGE 13 OF 26
MP ROAD DEVLOPMENT CORPORATION
Widening and reconstruction of Rampayali Garra Chouki Road
LIMITED
Bill of Quantities of ADB-V
Item Amount
Item Unit Quantity Rate (Rs.)
No. (Rs.)
i ) 90 cm equilateral triangle
Cautionary/Warning Sign each 200.00 4063.00 812600
Rev-04 PAGE 14 OF 26
MP ROAD DEVLOPMENT CORPORATION
Widening and reconstruction of Rampayali Garra Chouki Road
LIMITED
Bill of Quantities of ADB-V
Item Amount
Item Unit Quantity Rate (Rs.)
No. (Rs.)
iii) 60 cm circular
'Mandatory/Regulatory Signs each 14.00 3657.00 51198
iv) 80 cm x 60 cm rectangular
Informatory Signs each 32.00 4849.00 155168
v) 60 cm x 45 cm rectangular
Informatory Signs/Cheveron Sign each 66.00 3579.00 236214
vi) 60 cm x 60 cm square
Informatory Signs each 6.00 4123.00 24738
7.02 Direction and Place Identification signs upto 0.9 sqm size board.
(Providing and erecting direction and place identification retro-
reflectorised sign as per IRC:67 made of encapsulated lens type
reflective sheeting vide clause 801.3, fixed over aluminium sheeting,
2 mm thick with area not exceeding 0.9 sqm supported on a mild
steel single angle iron post 75 x 75 x 6 mm (height from crown level
of the road and bottom of the sign board shall not be less than 1.5
m.) firmly fixed to the ground by means of properly designed
foundation with M20 grade cement concrete 45 x 45 x 60 cm, 90 cm
below ground level as per approved drawing including painting of sqm 3.36 8199.00 27548.64
vertical post as per specification.
7.03 Direction and Place Identification signs with size more than 0.9 sqm
size board. (Providing and erecting direction and place identification
retro- reflectorised sign as per IRC :67 made of encapsulated lens
type reflective sheeting vide clause 801.3, fixed over aluminium
composite sheet 3mm thick supported on two pultruded composite
channel sections 50 x 100 x 50 x 5mm / aluminium sheeting, 2 mm
thick with area exceeding 0.9 sqm supported on a mild steel channel
post 35mm x 75 mm x 35 mm x 6 mm (height from crown level of
the road and bottom of the sign board shall not be less than 1.5 m.) ,
2 Nos. firmly fixed to the ground by means of properly designed
foundation with M-20 grade cement concrete45 cm x 45 cm x 60
cm, 90 cm below ground level as per approved drawing including
painting of vertical post as per specification. sqm. 3.60 14324.00 51566.4
Rev-04 PAGE 15 OF 26
MP ROAD DEVLOPMENT CORPORATION
Widening and reconstruction of Rampayali Garra Chouki Road
LIMITED
Bill of Quantities of ADB-V
Item Amount
Item Unit Quantity Rate (Rs.)
No. (Rs.)
ii) The sign board made out of 2 mm thick alluminium sheet, face to be
fully covered by high intensity grade white retro reflective sheeting
of encapsulated lens type. The
background/border/simples/legend/arrows shall be made by
transparent overlay film of desired colour as per sign details except
those in black which shall be of non reflective type. The sign place
shall be fixed with 6 mm dia alluminium rebate on MS angle iron
frame. The angle iron frame shall be made with angle of size 75 mm
x 75 mm x 6 mm with additional bracing at every 600 mm c/c, if any
dimension in more than 1200 mm. sqm 96.00 7679.06 737189.76
Rev-04 PAGE 16 OF 26
MP ROAD DEVLOPMENT CORPORATION
Widening and reconstruction of Rampayali Garra Chouki Road
LIMITED
Bill of Quantities of ADB-V
Item Amount
Item Unit Quantity Rate (Rs.)
No. (Rs.)
ii) Directional arrows, lettering, etc., as per drawings of MORT & H type
design and interSection for National Highways. Nos. 112.00 743.85 83311.2
c) Providing and fixing of 1 m RCC guide post 200 mm dia of NP-2 type
HP confirming to IS:458-2003 for guard stone, formation indicators,
etc. duly filled with earth except 0.15 m from top, cement concrete
of M-15 topping in 0.075 m and 0.075 m in pipe embedded in
cement concrete block of M-15 size 450 mm x 450 mm x 500 mm
complete in all respects including cost of painting with white and each 3343.00 1023.91 3422931.13
black paint.
Rev-04 PAGE 17 OF 26
MP ROAD DEVLOPMENT CORPORATION
Widening and reconstruction of Rampayali Garra Chouki Road
LIMITED
Bill of Quantities of ADB-V
Item Amount
Item Unit Quantity Rate (Rs.)
No. (Rs.)
7.10 Road Markers/Road Stud with Lense Reflector (Providing and fixing
of road stud 100x 100 mm, die cast in aluminium, resistant to
corrosive effect of salt and grit, fitted with lense reflectors, installed
in concrete or asphaltic surface by drilling hole 30 mm upto a depth
of 60 mm and bedded in a suitable bituminous grout or epoxy
mortar, all as per BS 873 part 4:1973). each 1639.00 672.00 1101408
7.11 Construction of cement concrete kerb with top and bottom width
115 and 165 mm respectively, 250 mm high in M 20 grade PCC on
M-10 grade foundation 150 mm thick, foundation having 50 mm
projection beyond kerb stone, kerb stone laid with kerb laying
machine, foundation concrete laid manually, all complete and as per meter 0.00 260.00 0
clause 408 of specifications.
Rev-04 PAGE 18 OF 26
MP ROAD DEVLOPMENT CORPORATION
Widening and reconstruction of Rampayali Garra Chouki Road
LIMITED
Bill of Quantities of ADB-V
Item Amount
Item Unit Quantity Rate (Rs.)
No. (Rs.)
7.14 Providing and fixing sign boards made out of 2mm aluminum sheet/
composite panel size 60x45 cms rectangle plus 30x25 cms additional
plate as per the drawing attached (IRC). Pretreated with phospheting
process and acid etching; coated with one coat of epoxy premier and
two coats of best quality epoxy paint; reflectorised with retro
reflective sheeting as per latest M.O.S.T. Specifications; 3.1 m long
Stand post and frame fabricated from suitable size iron angle of
35x35x3 mm & NB65 MS Pipe as required, painted with best quality
epoxy coating in black and white bends. The details of numerals for
each board shall be as per the instruction of the engineer incharge.
The fixing at site shall be in 1:2:4 CC block of size 45x45x60 cms for
each leg. including excavation curing etc. complete under the
supervision of engineer in charge. Nos. 0.00 7676.00 0
7.15 Providing and laying 80mm thick factory made cement concrete
interlocking paver block of M -40 grade made by block making
machine with strong vibratory compaction and of approved size and
design/ shape laid in required colour and pattern over and
including 50mm thick laid compacted bed of course sand, filling
the joints with coarse sand, cement mortar/concrete etc. with all
lead and lifts complete as per the direction of Engineer. Sqm 13500.00 644.60 8702100
8.02 Providing, fixing, laying and jointing 150 mm dia. medium class PVC
Pipe as per relevant IS code including excavation of trenches in
grade and level including cost of couplers and testing of pipes at
factory as per the stipulation in relevant IS codes etc. complete.
Rev-04 PAGE 19 OF 26
MP ROAD DEVLOPMENT CORPORATION
Widening and reconstruction of Rampayali Garra Chouki Road
LIMITED
Bill of Quantities of ADB-V
Item Amount
Item Unit Quantity Rate (Rs.)
No. (Rs.)
8.04 Shifting and relocating utility services such as water supply line,
sewer line, OFC or telecom or electric underground cables as per
Utility relocation plans and with the approval and technical
specifications of concerned authority including salvage value of
dismantled materials.
i) Water supply line of all types and sizes metre 0.00 1708.14 0
ii) Underground OFC, telecom/electric cables metre 0.00 857.48 0
8.05 Constructing lined drains as shown in drawing including cost of
excation, material, transportation etc. complete as per Technical
specification section 300 & 2500 and as directed by the Engineer. metre 0.00 15220.72 0
8.06 Planting of Trees and their Maintenance for three years: Providing,
planting of trees (Avenue trees), height not less than 1.80 meter,
digging a hole 0.60 meter in dia and 1.0 meter deep in the ground by
the road side, mixing the soil with decayed farm yard/sludge
mannure, planting the saplings, backfilling the trench, watering,
fixing the tree guard and maintaining the plants for three years. 50%
payment for this item will be made after one year and remaining
after three years for the plants servive at that time. The payment
made after one year shall be deducted for plants found dead after Each 300.00 703.00 210900
three years.
Rev-04 PAGE 20 OF 26
MP ROAD DEVLOPMENT CORPORATION
Widening and reconstruction of Rampayali Garra Chouki Road
LIMITED
Bill of Quantities of ADB-V
Item Amount
Item Unit Quantity Rate (Rs.)
No. (Rs.)
9.02 Supply and erection of stay set on existing pole made of GI stay wire
19 mm dia 1.8 m long stay rod anchor plate of size 300 X 300 X 6.4
mm timable stay clamp turn buckle 7/4.00 mm dia GI stay wire etc.
Concrete in cement (1:3:6) 1course cement 3 course sand 6 graded
metal 40 mm nominal size including foundation including excavation 0
and refilling etc. as required as per MPSEB specifications.
9.03 Supply and erection of insulator on existing pole with its hard ware
for LT/11KV/33KV line etc. complete as per MPSEB Specifications 0
Each 328 0
9.04 Supply and erection of angle /channel/flat iron fitting for existing
over head lines poles such as cross arms clamps brackers nuts bolts
required holes welding and necessary material including priming
with red oxide and painting with alluminium plant etc. complete as 0
per MPSEB Specification
Item Amount
Item Unit Quantity Rate (Rs.)
No. (Rs.)
9.08 Supply and laying Spiral -earthing coil made of 13 sqmn (4mm dia )
GI wire having spiral dia 50 mm with 115 truns continuous laead up
to 2.5m fixing on existing pole with nuts and bolts as per MPSEB Each 157.95 0
specification .
9.09 Supply and fixing of denger caution board enameiled marked for 11
KV and 33 KV on existing pole. Each 72.9 0
9.1 Supply and erection of drop out fuse unit (Set of 3 nos) suitable for
11 KV as per MPSEB specification.
Set 1652.4 0
Rev-04 PAGE 22 OF 26
MP ROAD DEVLOPMENT CORPORATION
Widening and reconstruction of Rampayali Garra Chouki Road
LIMITED
Bill of Quantities of ADB-V
Item Amount
Item Unit Quantity Rate (Rs.)
No. (Rs.)
9.13 Supply and erection of air break switch with hndle and
mechanicallocking arrangment 3 phase of multi capacity (1 set of 3
nos ) 3 insulator type complete as per MPSEB specifications. 0
Rev-04 PAGE 23 OF 26
MP ROAD DEVLOPMENT CORPORATION
Widening and reconstruction of Rampayali Garra Chouki Road
LIMITED
Bill of Quantities of ADB-V
Item Amount
Item Unit Quantity Rate (Rs.)
No. (Rs.)
9.2 Providing and fixing of LT AB Cable Fitting for laying cable on the
pole as per MPSEB specification 0
(N) Spring loaded three Phase bus-bar in insulated box 1in 3 out
No. 1517 0
(O) Al. Lugs for 150 Sq. Mm. Cable No. 38.88 0
(P)LT XLPE A.B. cable 3x150+1x95+1x35 sqmm. 1100 v km. 450425 0
(Q)LT XLPE A.B. cable 3x95+1x16+1x50 sqmm. 1100 v km. 212588.55 0
(R)LT XLPE A.B. cable 3x70+1x16+1x35 sqmm. 1100 v km. 168581.25 0
9.21 Supply and laying under ground 11/33KV cable for road crossing 0
with all fitting fixing on existing pole with nuts and bolts as per
(A)33 kvspecification
MPSEB xlpe armoured
. cable 3x300 sq.mm km. 1846800 0
(B) 33 kv Arial Bunch cable 200 sq.mm km. 1357641 0
(C ) Bimetallic clamp for 33 kv ME Terminal No. 534.6 0
(D) Indoor heat shrinkable cable jointing kit with lugs for 33kv xlpe 3
core 300sq.mm Set 31152.6 0
Rev-04 PAGE 24 OF 26
MP ROAD DEVLOPMENT CORPORATION
Widening and reconstruction of Rampayali Garra Chouki Road
LIMITED
Bill of Quantities of ADB-V
Item Amount
Item Unit Quantity Rate (Rs.)
No. (Rs.)
9.23 Supply erecting and testing of PVC/ XLPE insulated heavy duty
power cable conforming to (IS 1554-1964) of alluminum standerd
solid conductor of 1100 V grade armoured/ unarmoured. 0
Rev-04 PAGE 25 OF 26
MADHYA PRADESH ROAD DEVELOPMENT CORPORATION LIMITED
Widening & Reconstruction of Bheemgarh to Chhapara Road
Lane: Intermediate Lane Length= 12.600 Kms.
SUMMARY,
ORIGINAL CONTRACT
Bill Description
Amount in Figure
No. Amount in Words (INR)
(INR)
A Civil Works
1 Geneal Provision 1,106,606.88
2 SiteClearance 522,119.90
3 Earthwork 19,484,145.92
4 Subbase, Base Courses 22,370,713.56
5 Bituminious & Cement Concrete Pavement 237,739,401.90
6 CrossDrainage structures (Bridges & Culverts) 0.00
7 Traffic Signs, Marking and Road Appurtenances 19,056,638.22
(A) Total Cost of Civil Works 300,279,626.38
Modifications, if any
Subtotal for Civil Works (A) 300,279,626.38
Cost per km for Civil Works 23,831,716.38
(B) Noncivil Works
8 Miscellaneous Items 1,972,750.00
9 Electric Item 11,085,614.40
10 Forest and Environment Clearance
Subtotal for Noncivil Works (B) 13,058,364.40
Cost per km 1,036,378.13
C Total Cost (A+B) 313,337,990.78
D Centages
Provision for variation (Physical Contingencies)@ 5% 15,666,899.54
Provision for Escalation (Price Contingencies)@11.25% 35,250,523.96
Total Cost of (D) 50,917,423.50
E Total Cost (C+D) 364,255,414.28
F Maintenace @0.75% per Year of E for 5 Years 13,659,578.04
G Total Cost (E+F) 377,914,992.32
H Supervision Charges @ 5% of E 18,895,749.62
Grand Total (G+H) 396,810,741.93
Cost per km 31,492,916.03
Rev-04