Вы находитесь на странице: 1из 4

Module: ELEC 2 Total questions: 100 Total recorded: 89

1) What is the voltage regulation when no-load 14) What separates the positive and negative
voltage is equal to full-load voltage? plates of battery?
0% Voltage Regulation Separator

2) In an R-S Flip Flop; when R=0 and S=0 what 15) Silver-cadmium battery has a open circuit
are the states? voltage of
The state remains the same 1.05V

3) What is the feedback element of an 16) Damping is used to prevent


integrator? It prevents hunting
Capacitor

4) Thin windings are commonly found in? 17) What alternator is the least to hunt
In shunt motors Steam Turbine

5) What is the efficiency of Class D amplifier? 18) What type of battery that can’t be charged?
It is over 90% Primary Cell

6) What is the efficiency of transistorized Class 19) What advantage when the IC has high
C amplifier? component density?
It is 33% Increase switching speed

7) Eccles/Jordan Circuit is also called as? 20) What component that needs to be removed
Bistable Multivibrator before you can reprogram it?
EPROM
8) If x is low; X AND Y what is Y
Y is low 21) What do you call an op-amp that has a
characteristic of 2000V/m and 50MHz?
9) Where does positive edge triggering High slew rate and High frequency
happens?
From low to high 22) If the source-gate is conducting?
It is a sign of improper bias
10) How does the mutual inductance affects the
total inductance? 23) What is not a characteristic of air core?
It vary depending on its phase angle Air coil does not contain or confine
magnetic flux
11) What happens to the Zo of a coaxial cable if
the core diameter gets smaller? 24) An amplifier that only conducts only at the
The Zo increases 50% of the draining current?
Class B amplifier
12) What is a bleeder resistor?
It is a resistor paralleled to a capacitor 25) Voltage produced by heat?
Thermoelectricity
13) What is a toroidal core?
It is essentially self shielding 26) A battery which has an output voltage of
1.2V?
Edison Cell Stage with gain

27) A battery also known as dry cell and uses gel 41) In parallel alternator, how to change the
or paste? output frequency?
Leclanche Cell Change the rpm of the prime mover

28) What is the advantage of a pot core? 42) In parallel alternator, how to change the
Small volume with high inductance output voltage?
Change the field of excitation
29) What device used in changing one
frequency of an AC voltage vice versa? 43) What packaging is suitable for high
Frequency Converter component density?
SMT
30) What is the outline in Dual in Line (DIL)
package? 44) An oscillator should have what?
TO-116 Positive feedback

31) Zener diode in a regulator is connected in? 45) What class has the highest efficiency?
Parallel and reverse bias Class C amplifier

32) Q point of Class A is where to be found? 46) What type of configuration is use in
At the center multivibrator?
Commone Source or Common Emitter
33 Estimate the noise gain of an op-amp with 5 configuration
inputs
6 47) ratio of differential gain to common mode
gain?
34) An op-amp that compares only a band of Common mode rejection ratio
voltage?
Window comparator 48) brief periods of extreme voltage
Transient Spikes
35) What will happen to the susceptance when
the frequency is increased? 49) Maximum rate at which the amplifier
It will increase output can change?
Slew Rate
36) What is cluster?
Data on the hard drive 50) What tube is used to generate microwave
signals?
37) How many poles in an electric motor Magnetron
Even (always in pair)
51) Why does common collector is used in op-
38) Most commonly used in semiconductor? amp?
Silicon It has low output resistance

39) What is platter? 52) Transconductance gain


Part of the hard drive It is the ratio of Current drain to gate
voltage
40) An oscillator has?
53) What is the type of current that is used in
test instrument with 0.01 ohm load? 66) In a reverse bias diode the capacitance
Flash current depends on what
The width of depletion region
54) It compose of gate drain and has channel?
FET 67) Power supply must have what
All of the choices
55) Zero degrees of a sine wave is?
When the amplitude is zero and going 68) What is the disadvantage of voltage
positive doubler?
Poor regulation
56) In RC ckt, R increases and C remains
constant and non zero? 69) In a frequency domain
It gets longer and rotates counter Signal strength vs. Frequency
clockwise
70) In an oscilloscope where do you put the
57) R and Xc varies from 0 to infinity with a ratio probe to get a signal
of 3:1 Vertical plate of the cathode
Ray of unlimited length
71) Screen grid reduces what?
58) derivative of sine wave Reduces plate capacitance
Leads the original signal by 90 degrees
72) What loop gain is need in a window
59) The difference of two vectors comparator?
Phase difference Open loop gain

60) cavity klystron 73) What is not true for a sine wave?
Electrons have variable speed Electrons flow in the same direction

61) Lan that allows the PC to save its own data 74) What is the advantage of discrete
Peer to peer LAN components over IC?
Greater power capability
62) Directly two coupled transistor and has a
high current gain 75) What IC used to combine multiple signals?
Darlington configuration Multiplexer/demultiplexer

63) It uses NPN and PNP in the output of a 76) What is the disadvantage of CMOS?
regulator with complementary symmetry? Susceptible to noise
Quasi complementary push pull
amplifier 77) What is the difference of tube to FET?
It needs greater gate voltage
64) It uses NPN and PNP in the output of a
regulator 78) main difference between N-channel and
Transformer push pull amplifier triodes
Triodes needs more voltage
65) amplifier that is used because of high 79) what is the output of a regulator
stability pulsating dc
Class B amplifier
80) two transistor that turns on and off
alternately
Multivibrator
81) what is the horizontal part of an
oscilloscope
Time per division
82) when the diode is forward bias
Anode is positive relative to cathode
83) employs N-channel and P-channel in a single
CMOS
84) what device needs a filter in the final stage
Regulator
85) not an essential part of an oscillator
Resistor IC part
86) highest gain configuration
Common source
87) when the output voltage has value even
when there is no input voltage
Output offset voltage
88) when the bias stops the conduction of
current
Pinch off
89) when the amplifier is pinch off there is no
input
Class B

Вам также может понравиться