Академический Документы
Профессиональный Документы
Культура Документы
Assessment System
Time Remaining:
Object1
1 If the configuration register is currently set to 0x2102, what is the first action that a router will take after the
bootstrap program loads successfully?
load the IOS from flash
load the IOS from NVRAM
load the IOS from the TFTP server
load the startup configuration file from flash
load the startup configuration file from NVRAM
load the startup configuration file from the TFTP server
Refer to the exhibit. R1 and R2 are configured with the commands that are displayed. All interfaces are prop
configured, but neither router is receiving routing updates. What two things can be done to solve the problem
(Choose two.)
Configure the routing protocol on R1 for network 10.0.0.0.
Configure the routing protocol on R2 for network 10.0.0.0.
Configure the routing protocol on R1 for network 192.168.4.0.
Configure the routing protocol on R1 for network 192.168.2.0.
Configure the routing protocol on R2 for network 192.168.1.0.
Configure the routing protocol on R2 for network 192.168.3.0.
3 A user reports being able to access the Internet but not being able to download e-mail from the mail server a
ISP. What should the user check on the user workstation?
the POP3 and SMTP server settings in the e-mail application
the patch cable connections at the back of the workstation and at the wall plate
the DHCP settings in the operating system
the IP address, mask, and default gateway values
the NIC drivers
5 What routing protocol would be appropriate to use for exchanging routes between ISPs?
RIPv2
BGP
OSPF
EIGRP
Refer to the exhibit. Router Left is unable to ping router Right. The show interfaces serial 0/0/0 command
indicates that the interface is up but the line protocol is down on both routers. Which action could be taken to
establish connectivity between the two routers?
Configure S0/0/1 instead of S0/0/0 on router Right.
Enter the encapsulation hdlc command on router Right.
Contact the service provider to report that the circuit is down.
Contact the service provider to enable PPP on the WAN circuit.
Enter the no encapsulation ppp command on router Left S0/0/0.
7 What is the maximum unrepeated distance set by industry standards for UTP cable?
10 meters
75 meters
100 meters
325 meters
The show ip route command was executed on one of the routers shown in the graphic and the following out
was displayed:
9 Which two services are required to enable a computer to receive dynamic IP addresses and access the Intern
using domain names? (Choose two.)
DNS
WINS
HTTP
DHCP
SMTP
10 Which type of cable may be used for backbone cabling between data centers that are located on different flo
and that are separated by a distance of 1640 feet (500 meters)?
STP
UTP
coaxial
fiber-optic
11 A network engineer is planning a new horizontal cable installation in an office building. What advantage wo
UTP cable have over fiber optic cable for this installation?
lower installation costs
better protection from EMI
higher transmission speeds
longer unrepeated distance between endpoints
12
13 In an IPv4 environment, what information is used by the router to forward data packets from one interface o
router to another?
destination network address
source network address
source MAC address
well known port destination address
14 A user is unable to connect to the Internet. The network administrator decides to use the top-down
troubleshooting approach. Which action should the administrator perform first?
Run the tracert command to identify the faulty device.
Check the patch cable connection from the PC to the wall.
Enter an IP address in the address bar of the web browser to determine if DNS has failed.
Run the ipconfig command to verify the IP address, subnet mask, and gateway on the PC.
15 A small company has contracted with its ISP for web hosting. Which two items would be included in the SL
for this service? (Choose two.)
performance
web server cost
service availability
operating system on the web server
web server model and configuration
Close Window
All contents copyright 1992-2010 Cisco Systems, Inc. Privacy Statement and Trademarks.
Close Window
Assessment System
Time Remaining:
Object2
16 Which combination of network address and subnet mask allows 62 hosts to be connected in a single subnet?
Network address 10.1.1.4 Subnet mask 255.255.255.240
Network address 10.1.1.0 Subnet mask 255.255.255.252
Network address 10.1.1.0 Subnet mask 255.255.255.192
Network address 10.1.1.4 Subnet mask 255.255.255.248
19 A network technician is configuring port security on a LAN switch interface. The security policy requires ho
MAC addresses to be learned dynamically, stored in the address table, and saved to the switch running
configuration. Which command does the technician need to add to the following configuration to implement
policy?
20
Refer to the exhibit. While configuring the serial interface of a router, the network administrator sees the
highlighted error message. What is the reason for this?
The serial interface is administratively down.
The serial interface is already configured with an IP address.
The network administrator has attempted to configure the serial interface with a broadcast address.
The same IP address has been configured on another interface.
21
Refer to the exhibit. If the show cdp neighbors command is issued on RTB, which devices will appear in th
output if all devices use the Cisco IOS and have CDP enabled?
RTA, RTC
RTA, RTC, Sw2
RTA, RTC, Sw1, Sw2, Sw3
RTA, RTC, Sw1, Sw2, Sw3, PC1, PC2
22
Refer to the exhibit. A network administrator has an extra router and wishes to use it as shown to passively
monitor network traffic. Which IOS feature should be implemented on router EXTRA?
ACLs
CDP
IDS
IPS
24
Refer to the exhibit. A network administrator is unable to ping H1 from the router and is checking the cablin
along the network. Which segment is incorrectly cabled?
Segment A
Segment B
Segment C
Segment D
25
Refer to the exhibit. A technician uses the SDM application to configure router R1. Which step should be tak
by the technician to enable the Fa0/0 interface on R1 to participate on the connected local network?
Enable a DHCP server on the Fa0/0 LAN interface.
Configure the appropriate IP address on the Fa0/0 interface.
Configure IP addresses for the primary and secondary DNS server.
Configure the starting and ending IP addresses for the DHCP pool but exclude the Fa0/0 IP
address.
26 To protect the data of its customers, an ISP applies the security principle of least privilege within its organiz
and network. What is the principle of least privilege?
Encrypt only mission-critical data.
Give employees access only to the resources that they need.
Restrict file and folder access to system administrators only.
Use the smallest possible number of servers to share files and folders.
27 Which AAA process requires users to prove their identity with a username and password to gain access to a
network?
accounting
authorization
authentication
acknowledgment
28 What is used by a routing protocol to determine the best path to include in the routing table?
Convergence time
Default distance
Metric
Type of router
29 A company is developing an Internet store for its website. Which protocol should be used to transfer credit c
information from customers to the company web server?
FTPS
HTTP
HTTPS
WEP2
TFTP
30 A building has experienced a power outage. When the power returns, none of the devices on one floor can
access the Internet. The network administrator checks the switch in the IDF that these devices are connected
and notes that the SYST LED on the front of the switch is amber.
Close Window
All contents copyright 1992-2010 Cisco Systems, Inc. Privacy Statement and Trademarks.