Академический Документы
Профессиональный Документы
Культура Документы
7
Change Delivery 1
& FIU 19E 3.2, v.3
Ordering
DN03509501
Ordering
The information in this document is subject to change without notice and describes only the
product defined in the introduction of this documentation. This documentation is intended for the
use of Nokia Siemens Networks customers only for the purposes of the agreement under which
the document is submitted, and no part of it may be used, reproduced, modified or transmitted
in any form or means without the prior written permission of Nokia Siemens Networks. The
documentation has been prepared to be used by professional and properly trained personnel,
and the customer assumes full responsibility when using it. Nokia Siemens Networks welcomes
customer comments as part of the process of continuous development and improvement of the
documentation.
The information or statements given in this documentation concerning the suitability, capacity,
or performance of the mentioned hardware or software products are given "as is" and all liability
arising in connection with such hardware or software products shall be defined conclusively and
finally in a separate agreement between Nokia Siemens Networks and the customer. However,
Nokia Siemens Networks has made all reasonable efforts to ensure that the instructions
contained in the document are adequate and free of material errors and omissions. Nokia
Siemens Networks will, if deemed necessary by Nokia Siemens Networks, explain issues which
may not be covered by the document.
Nokia Siemens Networks will correct errors in this documentation as soon as possible. IN NO
EVENT WILL NOKIA SIEMENS NETWORKS BE LIABLE FOR ERRORS IN THIS DOCUMEN-
TATION OR FOR ANY DAMAGES, INCLUDING BUT NOT LIMITED TO SPECIAL, DIRECT,
INDIRECT, INCIDENTAL OR CONSEQUENTIAL OR ANY LOSSES, SUCH AS BUT NOT
LIMITED TO LOSS OF PROFIT, REVENUE, BUSINESS INTERRUPTION, BUSINESS
OPPORTUNITY OR DATA,THAT MAY ARISE FROM THE USE OF THIS DOCUMENT OR
THE INFORMATION IN IT.
This documentation and the product it describes are considered protected by copyrights and
other intellectual property rights according to the applicable laws.
The wave logo is a trademark of Nokia Siemens Networks Oy. Nokia is a registered trademark
of Nokia Corporation. Siemens is a registered trademark of Siemens AG.
Other product names mentioned in this document may be trademarks of their respective
owners, and they are mentioned for identification purposes only.
Copyright © Nokia Siemens Networks 2009. All rights reserved.
2 DN03509501
Issue: 6-1 Issue date: November 2009
Ordering
Table of Contents
This document has 32 pages.
1 Unit alternatives . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
4 FIU 19E 2M, Aux, power, LMP cables and connectors product codes . 11
DN03509501 3
Issue: 6-1 Issue date: November 2009
Ordering
List of Tables
Table 1 Outdoor units . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
Table 2 Antenna and alignment units . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Table 3 FIU 19E 19-inch indoor unit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Table 4 FIU 19E plug-in units . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Table 5 FIFA Flexbus Transmission Sub-module for Flexi EDGE BTS . . . . . . . . 7
Table 6 FTFA Flexbus Transmission Sub-module for Flexi WCDMA BTS . . . . . . 7
Table 7 MetroSite and UltraSite indoor units . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Table 8 UltraSite WCDMA and MetroSite WCDMA indoor units . . . . . . . . . . . . . 8
Table 9 FIU 19E indoor units . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Table 10 FIU 19E complementary mounting items . . . . . . . . . . . . . . . . . . . . . . . . 10
Table 11 FIU 19E 2M, Aux, power, LMP cables and connectors . . . . . . . . . . . . . 11
Table 12 Flexbus cables, connectors, and accessories . . . . . . . . . . . . . . . . . . . . 12
Table 13 IDU/ODU Cable Reel, connectors, and accessories . . . . . . . . . . . . . . . 12
Table 14 FIU 19E outdoor installation items . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Table 15 FlexiHopper 4E1 outdoor units . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
Table 16 FlexiHopper outdoor units . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
Table 17 FlexiHopper (Plus) outdoor units . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22
Table 18 FlexiHopper (Plus) alignment unit and antenna accessories . . . . . . . . . 26
Table 19 FlexiHopper (Plus) antennas . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27
Table 20 Node manager programs and accessories . . . . . . . . . . . . . . . . . . . . . . 29
Table 21 Optional 16-state modulation (32 TCM) licence key for FlexiHopper and
FlexiHopper 4E1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
Table 22 Capacity upgrade licence keys for FlexiHopper 4E1 . . . . . . . . . . . . . . . 30
Table 23 FIU 19E licences . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
Table 24 Software maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
Table 25 FlexiHopper (Plus) documentation product codes . . . . . . . . . . . . . . . . . 31
4 DN03509501
Issue: 6-1 Issue date: November 2009
Ordering Unit alternatives
1 Unit alternatives
Product Description for FlexiHopper (Plus) 2.7 covers Nokia Siemens Networks
products FlexiHopper Plus, FlexiHopper, FlexiHopper 4E1, and the supporting indoor
units. The following rules apply:
• FlexiHopper Plus enables 2 x E1 to 16 x E1 transmission capacity and selectable
modulation ( π /4-DQPSK and 32 TCM).
• π /4-DQPSK = 4-state
• 32 TCM = 16-state
• FlexiHopper enables 2 x E1 to 16 x E1 transmission capacity in the 4-state modula-
tion mode.
• FlexiHopper 4E1 enables 2 x E1 to 4 x E1 transmission capacity in the 4-state mod-
ulation mode and can be upgraded to 16E1 by software licensing.
• Selectable modulation is an option for both FlexiHopper and FlexiHopper 4E1.
In this documentation, FlexiHopper Plus and FlexiHopper refer to the modulation in use.
FlexiHopper (Plus) refers to all FlexiHopper products.
The different unit alternatives available for the FlexiHopper (Plus) product family are
described below.
All included unit alternatives may not be supported at the time of publication. Some
features may require new hardware and/or software versions that will be available in
future.
The frequencies currently available for FlexiHopper (Plus) are: 7, 8, 13, 15, 18, 23, 26,
and 38 GHz.
The indoor unit interface capacity does not limit the outdoor unit radio transmission
capacity.
DN03509501 5
Issue: 6-1 Issue date: November 2009
Unit alternatives Ordering
6 DN03509501
Issue: 6-1 Issue date: November 2009
Ordering Unit alternatives
Indoor units
Plug-in units and expansion units are ordered separately to compose versions included
in the FIU 19E configurations listed above. For example, Table 1 lists FIU 19E single
use (1 + 0) configuration with 8 x 2M 120 Ω interfaces. This configuration is composed
of a FIU 19E main unit and two 4 x 2M 120 Ω interface plug-in units.
FIFA Flexbus Transmission Sub-module for Flexi EDGE BTS, 2 Flexbus interfaces
FTFA Flexbus Transmission Sub-module for Flexi WCDMA BTS, 2 Flexbus interfaces
DN03509501 7
Issue: 6-1 Issue date: November 2009
Unit alternatives Ordering
Accessories
• Flexbus cable reel, 500 m
Node managers
• Hopper Manager
• FlexiHub Manager
• AXC-FB Hopper Manager
• RRI Manager
Customer documents
• FlexiHopper (Plus) 2.7 & FIU 19E 3.2 Release Content
• Product Description for FlexiHopper (Plus) 2.7 & FIU 19E 3.2
• Installing Hardware for FlexiHopper (Plus) 2.7 & FIU 19E 3.2
• Installing and Upgrading Software for FlexiHopper (Plus) 2.7 & FIU 19E 3.2
• Commissioning FlexiHopper (Plus) 2.7 with FIU 19E
• Monitoring FlexiHopper (Plus) 2.7 & FIU 19E 3.2
• Administering FlexiHopper (Plus) 2.7 & FIU 19E 3.2
• Troubleshooting FlexiHopper (Plus) 2.7 & FIU 19E 3.2
• FlexiHopper (Plus) 2.7 with FIU 19E Alarms & FIU 19E 3.2
• FlexiHopper (Plus) 2.7 Outdoor Unit Alarms & FIU 19E 3.2
• Ordering FlexiHopper (Plus) 2.7 & FIU 19E 3.2 and Accessories
• Legal and Safety Statements for FlexiHopper (Plus) 2.7 & FIU 19E 3.2
• Declaration of Conformity, FlexiHopper
• Declaration of Conformity, FlexiHopper (Plus)
• Declaration of Conformity, FlexiHopper 4E1
8 DN03509501
Issue: 6-1 Issue date: November 2009
Ordering FIU 19E indoor unit product codes
For example, to get a 12 x 2M 1 + 0 configuration, place an order for one main unit and
three 4 x 2M plug-in units. For 16 x 2M 1 + 0 you have to order a main unit and a suitable
upgrade kit (T55246.4x).
Upgrade kits T55246.4x contain an expansion unit and a backplane (no FIU 19E main
unit).
FIU 19E Ethernet 10/100BaseT plug-in unit (T55320.01) can be upgraded with FIU 19E
Ethernet QoS licence (L55341.07).
FIU 19E Ethernet 10/100BaseT plug-in unit with QoS (T55320.02) has QoS factory
installed.
DN03509501 9
Issue: 6-1 Issue date: November 2009
FIU 19E accessories Ordering
10 DN03509501
Issue: 6-1 Issue date: November 2009
Ordering FIU 19E 2M, Aux, power, LMP cables and connectors
product codes
Table 11 FIU 19E 2M, Aux, power, LMP cables and connectors
Note that these cables and connectors are for FIU 19E indoor installations only.
DN03509501 11
Issue: 6-1 Issue date: November 2009
Flexbus cables, connectors, and accessories product Ordering
codes
In alternative, for lower distance, the IDU/ODU cable reel is recommended. In this case,
the jumper cables are not used.
12 DN03509501
Issue: 6-1 Issue date: November 2009
Ordering FIU 19E outdoor installation product codes
Note that cables with length of 3,5 m are designed to be used with Flexi BTS.
DN03509501 13
Issue: 6-1 Issue date: November 2009
FlexiHopper (Plus) outdoor unit product codes Ordering
14 DN03509501
Issue: 6-1 Issue date: November 2009
Ordering FlexiHopper (Plus) outdoor unit product codes
DN03509501 15
Issue: 6-1 Issue date: November 2009
FlexiHopper (Plus) outdoor unit product codes Ordering
16 DN03509501
Issue: 6-1 Issue date: November 2009
Ordering FlexiHopper (Plus) outdoor unit product codes
DN03509501 17
Issue: 6-1 Issue date: November 2009
FlexiHopper (Plus) outdoor unit product codes Ordering
18 DN03509501
Issue: 6-1 Issue date: November 2009
Ordering FlexiHopper (Plus) outdoor unit product codes
DN03509501 19
Issue: 6-1 Issue date: November 2009
FlexiHopper (Plus) outdoor unit product codes Ordering
20 DN03509501
Issue: 6-1 Issue date: November 2009
Ordering FlexiHopper (Plus) outdoor unit product codes
DN03509501 21
Issue: 6-1 Issue date: November 2009
FlexiHopper (Plus) outdoor unit product codes Ordering
22 DN03509501
Issue: 6-1 Issue date: November 2009
Ordering FlexiHopper (Plus) outdoor unit product codes
DN03509501 23
Issue: 6-1 Issue date: November 2009
FlexiHopper (Plus) outdoor unit product codes Ordering
24 DN03509501
Issue: 6-1 Issue date: November 2009
Ordering FlexiHopper (Plus) outdoor unit product codes
DN03509501 25
Issue: 6-1 Issue date: November 2009
FlexiHopper (Plus) alignment unit and antenna acces- Ordering
sories product codes
26 DN03509501
Issue: 6-1 Issue date: November 2009
Ordering FlexiHopper (Plus) antenna product codes
DN03509501 27
Issue: 6-1 Issue date: November 2009
FlexiHopper (Plus) antenna product codes Ordering
28 DN03509501
Issue: 6-1 Issue date: November 2009
Ordering Node manager programs product codes
g An order must include both a software item and the appropriate licence.
DN03509501 29
Issue: 6-1 Issue date: November 2009
FlexiHopper (Plus) and FIU 19E licence keys Ordering
Table 21 Optional 16-state modulation (32 TCM) licence key for FlexiHopper and
FlexiHopper 4E1
g This software maintenance code is valid for all the software maintenance of Nokia
Siemens Networks Broad Connectivity Solution products.
30 DN03509501
Issue: 6-1 Issue date: November 2009
Ordering Customer documentation product codes
DN03509501 31
Issue: 6-1 Issue date: November 2009
Returning faulty units Ordering
32 DN03509501
Issue: 6-1 Issue date: November 2009