Академический Документы
Профессиональный Документы
Культура Документы
Arrêter SIS
Ecran précédent
Essai et réglage
D6R Track-Type Tractor Power Train
Numéro d'imprimé -SENR9495-02 Date de publication -01/04/2004 Date de mise à jour -01/04/2004
i00976064
Speed Sensors
Six speed sensors:
Illustration 1 g00469973
(31) Engine speed sensor
(33) Locknuts
Note: All the transmissions are not equipped with the cover that is shown in the illustrations for access to the
sensors.
Illustration 2 g00469974
Transmission case assembly
(35) Cover
(36) Gasket
(37) Washers
(38) Bolts
1. Remove six bolts (38) and six washers (37) in order to remove cover (35) and gasket (36) .
Illustration 3 g00469975
Transmission case assembly
(39) Bolts
(40) Washers
(41) Bracket
Note: Mark connector assemblies (P) so that the connectors can be reconnected at the correct locations.
2. Remove two bolts (39) and two washers (40) in order to remove bracket assembly (41). Disconnect
receptacle assemblies (P) .
Illustration 4 g00469976
3. Position a gear tooth directly in the center of the opening for speed sensor (42) .
4. Loosen locknut (R). Turn speed sensor (42) in the clockwise direction until the end of speed sensor (42)
contacts the gear tooth.
5. Turn speed sensor (42) counterclockwise for a one-half turn (180 degrees).
Note: Do not allow speed sensor (42) to turn when locknut (R) is tightened.
6. Use wrench flats (T) in order to keep speed sensor (42) from turning. Tighten locknut (R) to a torque of 25 ±
5 N·m (18 ± 4 lb ft).
8. Replace bracket assembly (41) with two washers (40) and two bolts (39) .
9. Connect receptacle assemblies (P) in the original positions. If necessary, refer to Table 1.
Table 1
10. Use six washers (37) and six bolts (38) in order to replace gasket (36) and cover (35). Tighten bolts (37) to a
torque of 47 ± 9 N·m (35 ± 7 lb ft).
Copyright 1993 - 2008 Caterpillar Inc. Tue Jan 22 16:50:30 UTC 2008
Tous droits réservés.
Réseau privé pour utilisateurs autorisés de SIS.