Академический Документы
Профессиональный Документы
Культура Документы
SAFETY ALERT
MONSOON PRECAUTIONS
Prior to the onset of rains, following checks should be carried out to prevent hazards that
could result into personal injury, property damage or delays:
• Cleaning of all drains in and around project site and labour camp.
• Backfilling of unwanted pits and barricading, shoring / benching & regular de-watering
in all balance pits where work is going on.
• Repair of approaches to site offices, stores and storage yards etc, if required.
• Rain protection during welding / gas cutting.
• Stacking of material over sleepers.
• Safe approaches for cranes, vehicles etc.
• Restrict erection work at heights.
• Ensure daily check for stability of scaffoldings before commencement of work.
• Arrange tarpaulin to protect the material at site.
• Proper and safe storage arrangements for fuel / oil drums.
• All PPE's and tools to be stored in a dry place.
• Adequate materials for monsoon repair work etc.
• Cover the motors, gears, wire rope drums of cranes / hoists.
• Procure antidote for poisonous insects / snake bite.
• Maintain adequate medicines at the first aid centre.
• Carry out de-fogging / spray of DDT etc. through local authorities to prevent spread of
any epidemic.
• Inform all drivers / operators for not moving closer to the excavated area.
• Tell all to avoid using slippery roads, if unavoidable, use with utmost care.
• Provide rest place for workers during rain.
• Ensure wind ties / anchoring of roofs, wherever required.
• Check for water accumulation around electrical installation like meter room, main
distribution board, DG sheds, etc., if required elevate the level for safer approach.
• Caution all for keeping away from any installation in or near meter room if the wall is
wet.
• Strengthen all sub-distribution boards (DB) with props / anchors.
• Inspect installed ELCB & check earth resistance continuously.
• Ensure all temporary DB’s are provided with proper earthing & ensure continuity of
earthling loop to all DB’s.
• Provide shed / cover over all distribution & sub-distribution boards.
• Check all the temporary joints and make them waterproof to the extent possible and
never allow any temporary joint in water.
• Poles installed for overhead cabling - make them rigid / more stable.
• Provide glass cover for Halogen fittings for avoiding water entry.
• Avoid / arrest water leakage in all offices / buildings as this may cause electrical faults /
short-circuit in the electrical system.
• Provide lightning arrestor on tower cranes.
• Only licensed / authorised electricians shall handle live electric wires, switches or
connections. While carrying out repair work, a rubber mat will be used by all
electricians.
• All poles should be well driven into ground to prevent these falling down due to wet
and loose earth.
HEIGHT WORK
• Provision of additional / stand - by pumps to drain out flood water from site / labour
camp.
• Electric supply must be switched off in flooded area immediately.
• Additional adequate measures shall be taken in case of flooding at site / labour camp.
Sites may take other additional actions to suit their site conditions.
Corporate Safety