Вы находитесь на странице: 1из 2

Trainer: SALAF HAYAT

1. Name the parameter to tune if we have high DL PRB utilization. __________________________


2. TCP or UDP, which test gives better results for testing DL tpt_____________________________
3. Counter to detect UL interference on PUCCH.________________________________________
4. Counter to detect UL interference on PUSCH.________________________________________
5. Best MTU size to avoid fragmentation even with S1 IPSec______________________________
6. Which HO event can help to classify cell edge and non cell edge users._____________________
7. For a given tpt, UL utilization is high compared to DL utilization. Why?
8. iBLER is function of
A. TBS B. coding rate C. modulation D. SINR
9. UL and DL BLER targets are defined by parameters. __________________________________
10. When you can see good CINR, good RSRP and very high BLER?
11. Which RF measurement can best predict the loading of serving cell.
A. RSRQ B. SINR C. RSSI D. RSRQ
12. Which RF measurement can best predict loading of neighbor cells.
A. RSRQ B. SINR C. RSSI D. RSRQ
13. CQI calculation is based on.
A. RSRQ B. SINR C. RSSI D. RSRQ
14. DL AMC is based on CQI and UL AMC is based on ____________________________
15. Which combination of P-a and P-b signify RS boost
A (0,1) B. (-3,1) C. (0,0)
16. Which combination of P-a and P-b signify PB boost
A (0,1) B. (-3,1) C. (0,0)
17. Which combination of P-a and P-b can improve DL tpt.
A (0,1) B. (-3,1) C. (0,0)
18. RS power for 25 RB, 50 RB and 100 RB are respectively.______________________________
19. Inputs to DL scheduler are A. QoS parameters B. LA output C. BSR
20. DL scheduling is done per Logical channel while UL scheduling is done on _______
21. Which HO parameter should be tuned together with qRxLevMin to balance cell border._______
22. Reported CQI is good(10 to 15) but throughput is still very low. How to troubleshoot further?
A. Check Amount of data in the DL buffer available B.Check CFI C.Check HARQ
23. HARQ process can be represented by
A.Feedback status B.TBS C.MCS D.RV
24. Feedback status could be. A.ACK B.NACK C.DTX D.Pending
25. RF is good. What mistake related to BLER setting can cause low tpt?
26. What is correct below with increasing velocity of UE.
A. DL tpt increase B.CQI decreases C.iBLER increases
27. Recommended value for tPollRetransmit is.________________
28. Number of DL grants are low. Reasons could be
A. Mobile in DRX state B.Downlink is not scheduled C.Missed detection of PDCCH
D.Unavailability of Resource clocks
29. Name the timer which can be tuned to improve S1 handover success rate.__________________
30. Name Normal release cause of an E-RAB._____________________________________________
31. Inter e-NB RRC connection reestablishment is possible or not?__________________________
32. Write Possible causes to start timer T311___________________________________________
33. Which timers can impact drop calls. Mark right options.
1.T300 2.T303 3.T304 4.T305 5.T310 6.T311 7.T301 8.T302 9.T320 10.T321
34. UE context enquiry procedure is needed in RRC reestablishment procedure of prepared or un-
prepared cell?____________________________________
35. Mention the value of tInactivityTimer in your network.____________________________
36. Mention the range of tInactivityTimer._________________________________________
37. What settings can shorten air interface latency. A. Change SR periodicity B.Enable
prescheduling C.Disable DRX
38. Name the message which e-NB sends to configure or modify measurements.________________
39. The average user plane interruption time during an X2 HO can vary from 100ms to 500 ms
depending on ____________________________________________________________.
40. In idle mode context of UE is maintained in A. e-NB B.MME C.SGW
41. Tick correct A3 event entry condition for intra-frequency.
A. RSRP neigh + cellIndOffNeigh > RSRPserv + cellIndOffServ +
a3Offset + hysA3Offset
B. RSRPneigh + cellIndOffNeigh + offsetFreqInter > RSRPserv +
cellIndOffServ + offsetFreqIntra + a3OffsetRsrpInterFreq +
hysA3OffsetRsrpInterFreq

Вам также может понравиться