Академический Документы
Профессиональный Документы
Культура Документы
MULTI-FUNCTIONABLE WARNING Warnings are indicated when mishandling this product might result in death or serious injury
to user.
DIGITAL VOLTAGE CONTROLLER Cautions are indicated when mishandling this product might result in minor injury to the user,
CAUTION or only physical damage to the timer.
User's Manual
WARNING
RESTRICTIONS ON USE
ΘNote this incorrect wiring of this product can damage it and lead to other hazards. Make sure the product has
When using this product in applications been correctly wired before turning the power ON.
that require particular safety or when ΘBefore wiring, or removing / mounting the product, be sure to turn the power OFF. Failure to do so might cause
using this product in important facilities, electric shock.
please pay attention to the safety of the ΘDo not touch electrically charged parts such as the power terminals. Doing so might cause electric shock.
overall system and equipment. Install fail- ΘDo not disassemble the product. Doing so might cause electric shock or faulty operation.
safe mechanisms, perform redundancy
checks and periodic inspections and CAUTION
adopt other appropriate safety measures ΘUse the product within the operating ranges recommended in the specification (temperature, humidity, voltage,
when it is necessary. shock, mounting direction, atmosphere and etc.). Failure to do so might cause fire or faulty operation.
ΘMake sure the product is firmly connected to the socket. Failure to do so might cause electric shock or fire.
Ambient temperature -10 ~ +50 °C Setting values display TEST OFF RESET Manual reset
Ambient humidity MAX 85% RH
SETTING PROCEDURE
1. Over voltage Setting 3. Over voltage tripping delay setting 5. The function of DIP switches 6. Setting values display
R V R
S
V UNBAL. AUTO
By pressing "TEST" button, all setting value
S
T S OVER
VOLT
T S OVER
TIME
REV. 5S will be shown ordinally as follows. The display
1S
Set the desired value for over voltage. Set the tripping delay for over voltage. will show existing 3-phase voltages after 10
The display will show existing 3-phase The display will show existing 3-phase OFF seconds.
voltages after 10 seconds. voltages after 10 seconds.
ON Reverse phase protected R V OVER VOLTAGE
S
REV. T S SETTING VALUE
2. Under voltage Setting 4. Under voltage tripping delay setting OFF Reverse phase unprotected
ON Unbalance protected R V UNDER VOLTAGE
S
R V R V UNBAL. T S SETTING VALUE
S
T S UNDER
S
T S UNDER OFF Unbalance unprotected
VOLT TIME
ON Auto reset R V
OVER VOLTAGE DELAY
Set the desired value for under voltage. Set the tripping delay for under voltage. AUTO
S
T S
R V R V R V
N.C. ( 1-4 )
S S S
T S T S T S
CONNECTION
3-Phase 3-Wire 3-Phase 4-Wire 1-Phase 2-Wire DC Voltage
MG.SW 1C 2b
Bottom View LINE
MOTOR MG.SW
R Bottom View LINE LINE LINE
MOTOR ~ LINE
M S R AC
~
~ DC
AC
T
M S
4 5 4 5 ~ 4 5
T 3 6 3 6 3 6
N
2 7 2 7 2 7
4 5 1 8 1 8 1 8
3 6
4 5
2 7 3 6
1 8
2 7 SOURCE SOURCE SOURCE
1 8 AC/DC 100~240V AC/DC 100~240V AC/DC 100~240V
SOURCE
AC/DC 100~240V
M-AEVR-D-B
ANLY ELECTRONICS CO., LTD.
http://www.anly.com.tw Printed in Taiwan