Академический Документы
Профессиональный Документы
Культура Документы
Installation Instructions
070
The flange bolt dimensions provided here are based on
nominal dimensions and are intended only as a guide.
Bolt length in any given installation may vary due to
manufacturing tolerances of valves, flanges, flange bolts,
Wafer Swing Check Valve gaskets, and any additional auxiliary equipment.
Sizes 3 through 12 inch, ANSI Class 150 Unless otherwise noted, stud and bolt lengths are based
on the following data: Minimum flange thickness of weld-
Fully lined wafer swing check valves are ideal for use in ing neck flanges per ANSI B16.5 and heavy hex nuts.
totally lined piping systems or to replace costly high alloy
valves in corrosive applications. The valve can be Wafer Style (Flangeless) Figure 070, Class 150
mounted horizontally or vertically with upward flow.
*
Tufline wafer swing check valves are of two piece con-
struction with only one moving part. Integral hinge pins
fit into the valve body recess; there are no springs or
pins to corrode or wear.
Read Carefully.
The following procedures and
illustrations have been prepared to Valve Torque** Hex Head Bolt Stud Length
assist you in the installation, mainte- Size Quantity Ft. Lbs. Length (L1) (L2)*
nance and repair of your Tufline valves. 2" 4 75 5/8-11 x 4.50 5/8-11 x 5.50
Please read these instructions
carefully. 3" 4 110 5/8-11 x 4.75 5/8-11 x 5.75
Please note that mating pipe I.D. must meet the installa- * Note: Pressure vessel studs are measured from the
tion requirement. (See Dimensions chart). If the mating first full thread to the last full thread - NOT from end to end.
pipe/flange I.D. is outside of this requirement a spacer is
required for proper disc retention.
Dimensions (inches)
Mating Pipe I.D.+
Size A B C D F G Wt. Lbs. Min. Max.
3 1.81 2.28 1.65 2.20 5.04 7.00 7 2.88 3.23
4 1.81 3.31 2.56 3.20 6.38 8.88 13 3.74 4.17
6 2.25 5.02 4.37 4.90 8.35 11.00 28 5.71 6.22
8 2.63 6.91 5.24 6.77 10.51 13.50 50 7.56 7.87
10 2.67 8.74 7.24 8.70 12.48 15.50 63 9.53 10.23
12 3.07 10.71 9.13 10.50 14.45 17.40 93 11.50 12.20
CP-XOMOX-070-IOM-IM-EN-CI-8/03 - PN335696
www.flowoffluids.com
CRANE ChemPharma Flow Solutions Include: Pipe - Valves - Fitting - Actuators - Pumps
Crane Co., and its subsidiaries cannot accept responsibility for possible errors in catalogues, brochures, other printed materials, and web-
site information. Crane Co. reserves the right to alter its products without notice, including products already on order provided that such
alteration can be made without changes being necessary in specifications already agreed. All trademarks in this material are property of
the Crane Co. or its subsidiaries. The Crane and Crane brands logotype (DEPA®, ELRO®, Krombach®, PSI®, Resistoflex®, ResistoPure™, Revo®,
Saunders®, and XOMOX®) are registered trademarks of Crane Co. All rights reserved.