Академический Документы
Профессиональный Документы
Культура Документы
1907/2006
Saraya-Europe
Revision date: 24.03.2010 Revision no.: 1,04
ALSOFT E
00811-0003
2. Hazards identification
Classification
Indications of danger : Irritant
R-phrases:
Flammable.
Risk of serious damage to eyes.
Harmful to aquatic organisms, may cause long-term adverse effects in the aquatic environment.
Vapours may cause drowsiness and dizziness.
3. Composition/information on ingredients
General information
Remove contaminated soaked clothing immediately.
If you feel unwell, seek medical advice.
After inhalation
Move to fresh air in case of accidental inhalation of vapours.
In the event of symptoms refer for medical treatment.
After contact with skin
No specific precautions required.
After contact with eyes
Rinse immediately with plenty of water, also under the eyelids, for at least 15 minutes.
Seek medical treatment by eye specialist.
GB - EN Page 1 of 7
Safety Data Sheet according to Regulation (EU) No. 1907/2006
Saraya-Europe
Revision date: 24.03.2010 Revision no.: 1,04
ALSOFT E
00811-0003
After ingestion
Do not provoke vomiting. Consult physician. Attention in case of vomiting - acute danger of suffocating,
produced by foaming ingredients. Rinse mouth. Make drink some glasses of water. The decision whether to
provoke vomiting is to be taken by a physician.
5. Fire-fighting measures
Personal precautions
In case of vapour formation use respirator.
Keep away from heat and sources of ignition.
Do not smoke.
Ensure adequate ventilation.
Environmental precautions
Do not discharge into the drains/surface waters/groundwater.
Methods for cleaning up/taking up
Soak up with inert absorbent material (e.g. sand, silica gel, acid binder, universal binder).
Shovel into suitable container for disposal.
7. Handling and storage
Handling
Advice on safe handling
Ensure adequate ventilation.
Keep container tightly closed in a dry, cool and well-ventilated place.
When using, do not eat, drink or smoke.
Avoid contact with eyes.
Advice on protection against fire and explosion
Keep product and empty container away from heat and sources of ignition.
Do not smoke - volatile.
Storage
Requirements for storage rooms and vessels
Keep container tightly closed in a dry, cool and well-ventilated place.
Ensure adequate ventilation, especially in confined areas.
Advice on storage compatibility
Incompatible with:
GB - EN Page 2 of 7
Safety Data Sheet according to Regulation (EU) No. 1907/2006
Saraya-Europe
Revision date: 24.03.2010 Revision no.: 1,04
ALSOFT E
00811-0003
Oxidizing agents.
Alkaline metals and earth alkaline metals.
Further information on storage conditions
Keep away from food, drink and animal feeding stuffs.
General information
Physical state: Liquid
Colour: Colourless
Odour: Alcoholic
Important health, safety and environmental information
Test method
Changes in the physical state
Boiling point: 82 °C *)
GB - EN Page 3 of 7
Safety Data Sheet according to Regulation (EU) No. 1907/2006
Saraya-Europe
Revision date: 24.03.2010 Revision no.: 1,04
ALSOFT E
00811-0003
Ecotoxicity
Polyaminopropyl biguanide
LC50/Oncorhynchus mykiss/96 h = 0,026 mg/l
EC50/Daphnia magna/48 h = 0,09 mg/l [OECD 202]
ErC50/Pseudokirchneriela subcapitata/72 h = 0,0191 mg/l [OECD 201]
Other adverse effects
Low hazard to waters.
Further information
This concentrate is not allowed to be released into the sewerage, surface water or groundwater.
Low hazard to waters.
Harmful to aquatic organisms, may cause long-term adverse effects in the aquatic environment.
Ecological injuries are not known or expected under normal use.
Advice on disposal
Can be incinerated, when in compliance with local regulations.
Where possible recycling is preferred to disposal.
GB - EN Page 4 of 7
Safety Data Sheet according to Regulation (EU) No. 1907/2006
Saraya-Europe
Revision date: 24.03.2010 Revision no.: 1,04
ALSOFT E
00811-0003
GB - EN Page 5 of 7
Safety Data Sheet according to Regulation (EU) No. 1907/2006
Saraya-Europe
Revision date: 24.03.2010 Revision no.: 1,04
ALSOFT E
00811-0003
Xi - Irritant
R phrases
10 Flammable.
41 Risk of serious damage to eyes.
52/53 Harmful to aquatic organisms, may cause long-term adverse effects in the aquatic environment.
67 Vapours may cause drowsiness and dizziness.
S phrases
07 Keep container tightly closed.
16 Keep away from sources of ignition - No smoking.
26 In case of contact with eyes, rinse immediately with plenty of water and seek medical advice.
39 Wear eye/face protection.
60 This material and its container must be disposed of as hazardous waste.
61 Avoid release to the environment. Refer to special instructions / Safety data sheets.
Special labelling for certain preparations
Contains Polyaminopropyl biguanide. May produce an allergic reaction.
EU regulatory information
1999/13/EC (VOC): < 80 %
National regulatory information
Employment restrictions: Observe employment restrictions for young people. Observe
employment restrictions for child bearing mothers and nursing.
Water contaminating class (D): 1 - slightly water contaminating
(The data for the hazardous ingredients were taken respectively from the last version of the sub-contractor's
safety data sheet.)
GB - EN Page 7 of 7