Академический Документы
Профессиональный Документы
Культура Документы
1. Use the unit within the rated specifications. Control Output Diagram & Load Operation Model
Item
A B ℓ Ød m n
Failure to follow this instruction may result in fire or product damage. DC 3-wire type
2. Use dry cloth to clean the unit, and do not use water or organic solvent. CR18 48 54 20 54 24 54
Failure to follow this instruction may result in electric shock or fire. NPN output CR30 90 90 10 90 45 90
3. Do not use the unit in the place where flammable/explosive/corrosive gas, humidity, direct sunlight, radiant heat, Brown N.O. N.C.
+V
vibration, impact, or salinity may be present.
Failure to follow this instruction may result in fire or explosion.
Sensing target
Presence
Nothing Installation and Tightening Torque
4. Do not supply power without load. Load When tightening the nut, use the provided washer as [Figure 1]
Main circuit
10kΩ Load Operation [Table 1]
Failure to follow this instruction may result in fire or product damage. Black (Brown-Black) Return When installing the product, the tightening torque of the nut varies
according to the distance from the fore-end. Strength Front Rear
Output voltage H
Ordering Information (Black-Blue) L The front part of the product is from the fore-end to the dimension on
the below table, and the rear part is from the tip of the nut to the end
Model
CR18
Size
-
Torque
0.39N.m
Torque
2000
Connections ① Indoors (in the environment condition rated in 'Specifications')
② Altitude max. 2,000m
8 M18×1 2000 DC 3-wire type AC 2-wire type ③ Pollution degree 2
5 Black
M30×1.5 ④ Installation category II
Blue
Grounding Brown Major Products
The sensing distance will be changed by grounding status of capacity proximity sensor and the target [50×50×1mm (iron)]. Photoelectric Sensors Temperature Controllers
Brown Fiber Optic Sensors Temperature/Humidity Transducers
Please check the material when installing the sensor and selecting the target. Load
Door Sensors SSRs/Power Controllers
● CR18 ● CR30 Door Side Sensors Counters
Ground condition (switch b) ON OFF Ground Switch a ON OFF ON OFF Area Sensors Timers
100-240VAC
Operating distance (mm) 8 4 condition Switch b ON ON OFF OFF 50/60Hz Proximity Sensors Panel Meters
Operating distance (mm) 15 18 6 6 Pressure Sensors Tachometers/Pulse(Rate)Meters
Blue Rotary Encoders Display Units http://www.autonics.com
CR18-8A Load Connectors/Sockets Sensor Controllers HEADQUARTERS:
Target Target Switching Mode Power Supplies
18, Bansong-ro 513beon-gil, Haeundae-gu, Busan,
CR18-8DN ※Load can be connected to either wires. Control Switches/Lamps/Buzzers
South Korea, 48002
Switch a Switch b I/O Terminal Blocks & Cables
Switch b TEL: 82-51-519-3232
Stepper Motors/Drivers/Motion Controllers
Graphic/Logic Panels E-mail: sales@autonics.com
※The above specifications are subject to change and some models may be discontinued without notice. Field Network Devices DRW161147AB
※Be sure to follow cautions written in the instruction manual and the technical descriptions (catalog, PA10-U Laser Marking System(Fiber, CO₂, Nd:YAG)
homepage). Laser Welding/Cutting System