Академический Документы
Профессиональный Документы
Культура Документы
14. Melting point of ice 00C and 320F, 2730K respectively, boiling
point of water is 1000C then equivalent with :
A. 2120K.
B. 3730K.
C. A and B are correct.
15. Typical value of temperature at the tropopause are :
A. Equator -800C.
B. N/S -450C.
C. Equator -800C, 45 N/S -560, Poles -450C.
16. The altitude at which a given pressure occurs in the ISA is
called:
A. Pressure ratio.
B. Pressure absolute.
C. Pressure altitude.
17. In meteorology the unit of pressure is the millibar (mb), which
is equivalent to
A. 1000 dynes per square centimeter.
B. 1050 mb.
C. 950 mb.
18. The pressure on the surface of the body which causes the moving
air to stop is called:
A. Static pressure.
B. Dynamic pressure.
C. Thrust.
19. The pressure which exerts a force on all bodies is called:
A. Static pressure.
B. Dynamic pressure.
C. Thrust.
20. The phase change of a gas to a liquid. In the atmosphere the
change of water vapour to liquid water is called:
A. Dew point.
B. Condensation.
C. Freezing.
21. Some water in the form of invisible vapour is intermixed with
the air throughout the atmosphere is called:
A. Pressure.
B. Humidity.
C. Density.
22. The path traced out by single particle of airflow (that this
particle does not cross the path of any other) is called:
A. Streamline.
B. Aerofoil.
C. Chamber.
23. In the venturi tube, mass flow is always a constant even if the
tube is not constant diameter:
p1 a1 v 1 = p2 a 2 v2
A. That is wrong equation.
B. That is correct equation.
C. Not exactly.
24. Reference general figure, which
statement correct.
A. Air at the upper wing: V1 > V2, so
P2 < P1.
B. Air at the lower wing: V nearly constant, so P2 > P1.
C. P2 at the lower wing > P2 at the upper wing that creates lift.
25. Total pressure H1 = S1 + 1/2ρ1.V12 = constant, therefore
A. S1 + ½ ρ1.V12 > S2 + ½ρ2V22.
B. S1 + ½ ρ1.V12 < S2 + ½ρ2V22.
C. S1 + ½ ρ1.V12 = S2 + ½ρ2V22.
a. Calorie
b. Temperature
c. Calor
a. Specific Heat
b. Mass-Density
c. Specific Density
4. Ratio of the density of material compared with the density of water is called:
a. Specific Ratio
b. Specific Density
c. Specific Gravity
a. Kinetic Energy
b. Potensial Energy
c. Gravity Energy
a. Force
b. Work
c. Pressure
a. 15 celcius degree
b. 280 kelvin degree
c. 28.8 kelvin degree
14. The runway length of xyz airport is 3025 meter. The length of airport xyz in feet is:
a. 99.245 feet
b. 992.45 feet
c. 9924.5 feet
a. Line
b. Area
c. Volume
16. A 747-400 has been loaded with the 50000 gallon of fuel. The much fuel is in liters
units is:
a. 1892706 liters
b. 18927.06 liters
c. 189270.6 liters
a. Velocity
b. Speed
c. Acceleration
18. The speed of an object is 156 knots. The speed of this object in feet per second
is:
a. Average Velocity
b. Acceleration
c. Average Gravity
20. Ratio of an aeroplane's true speed to the speed of sound for the conditions at
which the aeroplane is flying is called:
a. Mach Number
b. Specific gas number
c. Reynold Number
a. Work
b. Force
c. Weight
22. An empty 737-300 is weighed, and recorded as 13 5000 pound. The airplane weight
in kilogram is:
a. 61234.97 kgf
b. 612.3497 kgf
c. 61.23497 kgf
a. Mass-Density
b. Weight-Density
c. Specific-Density
a. Momentum
b. Kinetics Energy
c. Pressure
a. 760 mm Hg
b. 760 cm Hg
c. 7.6 mm Hg
a. Isobaric
b. Isochoric
c. Isothermal
a. Isobaric
b. Isochoric
c. Isothermal
a. Isobaric
b. Isochoric
c. Isothermal
29. An aeroplane is park at sea level airport with the out side pressure is 768 mmHg.
Standard day air pressure is 1013.25 mb.In unit mb, the outside pressure is lower or
higher as much as:
a. 10.66 mb
b. 1.066 mb
c. 106.6 mb
30. An aeroplane is park at sea level airport with the out side pressure is 29.68inch-
Hg.
Standard day air pressure is 1013.25 mb.In unit mb, the outside pressure is lower or
higher as much as:
a. 8.127 mb
b. 81.27 mb
c. 812.7 mb
31. An aeroplane true air speed is 325 m/s. The speed sound is 330 m/s. In
Mach
Number the speed of TAS is:
a. 0.908 M
b. 0.98 M
c. 0.098M
a. Mass is constant
b. Weight is variation related to the position
c. a, and b correct
33. A property of fluid which create resistance to motion of an object through that
fluid
is called:
a. Density
b. Gravity
c. Viscosity
35. The air velocity in upper section of an aerofoil is ....... than in lower section for
subsonic area.
a. smaller
b. bigger
c. not known
a. Compressible Flow
b. Incompressible Flow
c. Steady State Flow
a. Compressible Flow
b. Incompressible Flow
c. Steady State Flow
a. Dynamic Pressure
b. Static Pressure
c. Dynamic Pressure and Static Pressure
39. A device that calculate the static and dynamic pressure is called:
a. Pitot-Static Probe
b. Dynamic Pressure Gauge
c. Static Pressure Gauge
a. Constant Pressure
b. Impact Pressure
c. Potensial Pressure
a. 0.75 M or below
b. 0.75 M or higher
c. 5 M or higher
a. 0.75 M or below
b. 0.75 M or higher
c. 5 M or higher
43. The degree of curvature of the mean line is called:
a. Chord line
b. Mean line
c. Chamber
a. Chord line
b. Mean line
c. Chamber
45. A straight line joining the intersections of the mean line with the leading edge and
trailing edges of the airfoils is called:
a. Chord line
b. Mean line
c. Chamber
46. The distance of the upper and lower surfaces from the chord line, usually
expressed
in percent of chord length is called:
47. The angle of the chord line of an aerofoil and the relative to the airflow direction is
called:
a. angle of attack
b. angle of incident
c. angle of stall
48. The angle of an airfoil that produce lift which is manufactured is called:
a. angle of attack
b. angle of incidence
c. angle of stall
49. The weight of the aircraft can be broken down into fundamental components:
53. In moving through the air the aircraft experiences a resistive drag force. The force
is
made up of several distinct components:
a. Friction Drag
b. Pressure Drag
c. a, and b are correct
54. During take-off run the imbalance in these forces will produce an acceleration
along
run way can be calculated by:
55. When the leading edge of wing is higher than trailing edge, the angle of incidence
is
said tobe:
a. Negative
b. Positive
c. Zero
56. When the leading edge of wing is lower than trailing edge, the angle of incidence
is
said tobe :
a. Negative
b. Positive
c. Zero
a. The Weight
b. The Thrust
c. The Drag
59. The force acts vertically and by so doing counteracts the effects of weight is
called:
a. The Weight
b. The Lift
c. The Drag
60. The force that produced by the powerplant inward force that overcomes the force
drag is called:
a. The Weight
b. The Thrust
c. The Drag
61. The force backward and is caused by disruption of the airflow by wings,fuselage
and
protruding objects is called:
a. The Weight
b. The Thrust
c. The Drag
a. Rolling
b. Pitching
c. Yawing
a. Rolling
b. Pitching
c. Yawing
a. Rolling
b. Pitching
c. Yawing
65. The motion of an aircraft about the longitudinal axis is controlled by:
a. Rudder
b. Aileron
c. Elevator
66. The motion of an aircraft about the lateral axis is controlled by:
a. Rudder
b. Aileron
c. Elevator
67. The motion of an aircraft about the vertical axis is controlled by:
a. Rudder
b. Aileron
c. Elevator
71. When an aircraft has a tendency to keep a constant angle of attack with reference
to
the relative wind is called:
a. Directional Stability
b. Longitudenal Stability
c. Lateral Stability
72. When an aircraft is in straight level flight even though the pilot takes his hands is
called:
a. Directional Stability
b. Lateral Stability
c. Static Stability
73. The motion of an aircraft about the vertical axis is controlled by:
a. Rudder
b. Aileron
c. Elevator
d. a,b and c are correct
a. Angle of Attack
b. Angle of Incidence
c. Angle of Lift
A
75. Which is the correct choice : (imagine in sub sonic motion)
a. Thrust
b. Drag
c. Lift
a. Thrust
b. Weight
c. The Resultant of Lift and Drag
a. Static pressure
b. Dynamic Pressure
c. Total Pressure
a. Lift
b. Drag
c. Thrust
d. Weight
a. Lift
b. Drag
c. Thrust
a. Reynold Number
b. Universal Gas Constant
c. Dynamic Pressure
84. If the velocity of the fluid is uniform from the surface to the bottom, the flow is
called:
a. Viscous Flow
b. Non Viscous Flow
c. Turbulence
85. If the velocity of the fluid is variation from the surface to the bottom, the flow is
called:
a. Viscous Flow
b. Non Viscous Flow
c. Turbulence
a. Aileron,Elevator,Rudder
b. Aileron,Tabs,Rudder
c. Rudder, Spoiler,Elevator
a. Aileron,Elevator,Rudder
b. Trim Tabs , Spring Tabs
c. Rudder and Spring Tabs
88. The Auxiliary flight control are:
90. The outside temperature will constant at -56.5 celcius degree at the zone :
a. Ionosphere
b. Atmospher
c. Stratospher
a. Density
b. Viscousity
c. Humidity
a. Speed
b. Velocity
c. Acceleration
a. Speed
b. Velocity
c. Acceleration
99. V1 . Below this speed the take off can be safely aborted is called: