Академический Документы
Профессиональный Документы
Культура Документы
SIEMENS SIPROTEC
The 7SD52/53 relay provides full scheme differential protection and
incorporates all functions usually required for the protection of power lines. It is
designed for all power and distribution levels and protects lines with two up to
six line ends. The relay is designed to provide high-speed and phase-selective
fault clearance. The relay uses fiber-optic cables or digital communication
networks to exchange telegrams and includes special features for the use in
multiplexed communication networks. Also pilot wires connections can be
used with an external converter. This contributes toward improved reliability
and availability of the electrical power system. The relay is suitable for single
and three-phase tripping applications for two up to six line ends.
The protected differential zone may be easily extended from 2 up to 6 line ends.
Complex system configurations receive clearly defined protection zones and
maximum fault coverage.The high-speed distance relay operates fully independent
from the differential relay. Back-up zones provide remote back-up for upstream and
downstream lines and other power system components. Contrary to traditional
measurement approaches, the distance-to-fault locator uses measurement quantities
from both line terminals. This results in precise readings,even under difficult system
conditions, e.g. parallel lines or resistive line faults fed from both line terminals. The
readings are available right after fault clearance for quickline clearance and system
restoration
The high-speed distance relay operates fully independent from the differential relay.
Back-up zones provide remote back-up for upstream and downstream lines and other
power system components
Contrary to traditional measurement approaches, the distance-to-fault locator uses
measurement quantities from both line terminals. This results in precise readings, even
under difficult system conditions, e.g. parallel lines or resistive line faults fed from both
line terminals. The readings are available right after fault clearance for quick line
clearance and system restoration
The relays provide optical ports for relay-to-relay (R2R). The adjustment to other
communication media takes place via media converter. They accept all traditional
and modern communication media, i.e. fibers, comms networks and pilot wires. The
relays remain unchanged
The 7SD52/53 has the following features:
– IEC 60870-5-103
Direct fi ber-optic connection offers high-speed data exchange with 512 kbit/s
Connection techniques and housing with many advantages
Together with the SICAM power automation system, SIPROTEC 4 can be used with
PROFIBUS-FMS. Over the low-cost electrical RS485 bus, or interference-free via the optical
double ring, the units exchange information with the control system.
Units featuring IEC 60870-5-103 interfaces can be connected to SICAM in parallel via the
RS485 bus or radially by fi ber-optic link. Through this interface, the system is open for the
connection of units of other manufacturers.
Because of the standardized interfaces, SIPROTEC units can also be integrated into
systems of other manufacturers or in SIMATIC. Electrical RS485 or optical interfaces are
available. The optimum physical data transfer medium can be chosen thanks to
optoelectrical converters. Thus, the RS485 bus allows low-cost wiring in the cubicles and
an interference-free optical connection to the master can be established.
For IEC 61850, an interoperable system solution is offered with SICAM PAS. Via the 100
Mbits/s Ethernet bus, the units are linked with PAS electrically or optically to the station PC.
The interface is standardized, thus also enabling direct connection of units of other
manufacturers to the Ethernet bus. With IEC 61850, however, the units can also be used in
other manufacturers' systems
Via modem and service interface, the protection engineer has access to the protection
devices at all times. This permits remote maintenance and diagnosis (cyclic testing).
Mob No:
Mr. Piyush Rathi- +91-9819614841
Website:
www.reliservsolution.com
Email-ID:
piyush@reliserv.in
sales1@reliserv.in
Address:
Office No: 9, Space Heights,
Plot No. 53/54 , Sector 34,
Kamothe,Navi Mumbai- 410209