Вы находитесь на странице: 1из 51

15” LCD Color Monitor LENOVO D153A

Service
Service
Service

Horizontal Frequency
30-60 kHz
TABLE OF CONTENTS
Description Page Description Page
Table Of Contents.......……..............................…........1 6.Schematic…………………...................................…17
Revision List.…........................................……......2 6.1.Main Board.................................................17
Important Safety Notice.…….........................……......3 6.2.Power Board....……….…....................................22
1.Monitor Specification..............................………........4 6.3.Audio Board....……….……....................................24
2.LCD Monitor Description…………………………….......5 7.PCB Layout..……………….......................................25
3.Operation Instruction……………...............……...........6 7.1.Main Board……………........................................25
3.1.General Instructions………..........................…...........6 7.2.Power Board…....................................... 27
3.2.Control Button…………….…..............……...............6 7.3.Audio Board…......................................................28
3.3.Adjusting the Picture...........................…............7 7.4.Key Board…………...…….....................................29
4.Input/Output Specification............……………............9 8.Maintainability…………….........................................30
4.1 Input Signal Connector............………….................9 8.1 Equipments and Tools Requirement.....................30
4.2 Factory Preset Display Modes.........................10 8.2 Trouble Shooting…………….................................31
N
4.3 Panel Specification.....……...……………..................11 9.White-Balance Luminance adjustment………….....37
5.Block Diagram………...................…………................13 10.Monitor Exploded View……………………….........39
5.1.Software Flow Chart………………………...........13 11.BOM List……….....................................................40
5.2.Electrical Block Diagram…………………..….......15

SAFETY NOTICE
ANY PERSON ATTEMPTING TO SERVICE THIS CHASSIS MUST FAMILIARIZE HIMSELF WITH THE
CHASSIS AND BE AWARE OF THE NECESSARY SAFETY PRECAUTIONS TO BE USED WHEN SERVICING
ELECTRONIC EQUIPMENT CONTAINING HIGH VOLTAGES.

CAUTION: USE A SEPARATE ISOLATION TRANSFOMER FOR THIS UNIT WHEN SERVICING

R FOR TH
1

UNIT WHEN S
15” LCD Color Monitor LENOVO D153A
Revision List
Revision Date Revision History TPV Model
A00 Nov-26-07 First Version Release T57VMXHQACH16N

2
15” LCD Color Monitor LENOVO D153A
Important Safety Notice
Proper service and repair is important to the safe, reliable operation of all AOC Company Equipment. The service
procedures recommended by AOC and described in this service manual are effective methods of performing service
operations. Some of these service operations require the use of tools specially designed for the purpose. The
special tools should be used when and as recommended.

It is important to note that this manual contains various CAUTIONS and NOTICES which should be carefully read in
order to minimize the risk of personal injury to service personnel. The possibility exists that improper service
methods may damage the equipment. It is also important to understand that these CAUTIONS and NOTICES ARE
NOT EXHAUSTIVE. AOC could not possibly know, evaluate and advise the service trade of all conceivable ways in
which service might be done or of the possible hazardous consequences of each way. Consequently, AOC has not
undertaken any such broad evaluation. Accordingly, a servicer who uses a service procedure or tool which is not
recommended by AOC must first satisfy himself thoroughly that neither his safety nor the safe operation of the
equipment will be jeopardized by the service method selected.
Hereafter throughout this manual, AOC Company will be referred to as AOC.

WARNING
Use of substitute replacement parts, which do not have the same, specified safety characteristics may create shock,
fire, or other hazards.

Under no circumstances should the original design be modified or altered without written permission from AOC.
AOC assumes no liability, express or implied, arising out of any unauthorized modification of design.
Servicer assumes all liability.

FOR PRODUCTS CONTAINING LASER:


DANGER-Invisible laser radiation when open AVOID DIRECT EXPOSURE TO BEAM.
CAUTION-Use of controls or adjustments or performance of procedures other than those specified herein may
result in hazardous radiation exposure.
CAUTION -The use of optical instruments with this product will increase eye hazard.

TO ENSURE THE CONTINUED RELIABILITY OF THIS PRODUCT, USE ONLY ORIGINAL MANUFACTURER'S
REPLACEMENT PARTS, WHICH ARE LISTED WITH THEIR PART NUMBERS IN THE PARTS LIST SECTION OF
THIS SERVICE MANUAL.
Take care during handling the LCD module with backlight unit
-Must mount the module using mounting holes arranged in four corners.
-Do not press on the panel, edge of the frame strongly or electric shock as this will result in damage to the screen.
-Do not scratch or press on the panel with any sharp objects, such as pencil or pen as this may result in damage to
the panel.
-Protect the module from the ESD as it may damage the electronic circuit (C-MOS).
-Make certain that treatment person’s body is grounded through wristband.
-Do not leave the module in high temperature and in areas of high humidity for a long time.
-Avoid contact with water as it may a short circuit within the module.
-If the surface of panel becomes dirty, please wipe it off with a soft material. (Cleaning with a dirty or rough cloth may
damage the panel.)

3
15” LCD Color Monitor LENOVO D153A
1. Monitor Specifications

Items Descriptions

Driving system TFT Color LCD

Type SVA150XG10TB

Size 38.1cm (15.0")


LCD Panel
Pixel pitch 0.297mm( H )x 0.297mm( V )

Viewable angle 150˚ (H) 130˚ (V)

Response time (type) 8 ms for SVA panel

Sync. Type H/V TTL

Analog Direct Drive, 75 ohm


Input signal
Input 0.7 V

H-Frequency 30kHz – 60kHz

V-Frequency 50-75Hz

ON Mode ≤23W

Power Consumption Standby/Suspend ≤2W

OFF Mode ≤1W

Contrast Ratio 600:1(typ)

Clock frequency 80 MHz

2
White Luminance 250cd/m

Max. Resolution 1024 x768

Display Color 16,777,216 colors (6bit+FRC)

Plug & Play VESA DDC2BTM

Power Source 100~240VAC,47~63Hz

Horizontal : 306mm
Maximum Screen Size
Vertical: 230 mm
Operating Temp: 10°C to 35°C
Environmental
Storage Temp: -20°C to 60°C
Considerations
Operating Humidity: 10% to 80%

4
15” LCD Color Monitor LENOVO D153A
2. LCD Monitor Description
The LCD MONITOR will contain a main board, a power board, an audio board and a key board which house the flat
panel control logic, brightness control logic and DDC.
The power board will provide AC to DC Inverter voltage to drive the backlight of panel and the main board chips
each voltage.

Monitor Block Diagram

Flat Panel and


CCFL Drive.
CCFL backlight

RS232 Connector
Power board
Main Board For white balance
(Include: adapter, inverter)
adjustment in factory
mode
Audio board Key board

Video signal, DDC


AC-IN
100V-240V
HOST Computer

5
15” LCD Color Monitor LENOVO D153A
3. Operating Instructions
3.1 General Instructions
Press the power button to turn the monitor on or off. The control buttons are located at front panel of the monitor.
By changing these settings, the picture can be adjusted to your personal preferences.
- The power cord should be connected.
- Connect the video cable from the monitor to the video card.
- Press the power button to turn on the monitor, the power indicator will light up.

3.2 Control Buttons

Item Name Within OSD Without OSD

1 Auto/Exit Exit OSD or back to previous menu Auto configuration

1.Move the cursor to left


2 VOL/ Activate the volume menu
2.Decrease the value of the selected
item
3 Power Power On / Off Power On / Off

1.Move the cursor to right


4 VOL / Activate the volume menu
2.Increase the value of the selected item

5 Menu Select Function or select Sub menu Activate OSD main menu

6
15” LCD Color Monitor LENOVO D153A
3.3 Adjusting the Picture

OSD functions

Main Menu Main Menu Sub Menu Sub Menu


Description
Item Icon Item Icon

Contrast Contrast from Digital-register.


Luminance
Brightness Backlight Adjustment

Adjust Picture Phase to reduce


Focus
Horizontal-Line noise
Image Setup
Adjust picture Clock to reduce
Clock
Vertical-Line noise.
Adjust the horizontal position of the
H. Position
Image picture.
Position
V. Position Adjust the vertical position of the picture.

Recall warm Color Temperature from


Warm N/A
EEPROM.
Recall cool Color Temperature from
Cool N/A
EEPROM.

Color Temp. User / Red Red Gain from Digital-register.

User / Green Green Gain from Digital-register.

User / Blue Blue Gain from Digital-register.

Auto Adjust the H/V Position, Focus and


Auto Config Yes N/A
Clock of picture.
(Analog-Only
Do not execute Auto Config, return to main
Model) No N/A
menu.

OSD Setup H. Position Adjust the horizontal position of the OSD.

7
15” LCD Color Monitor LENOVO D153A

V. Position Adjust the vertical position of the OSD.

OSD Timeout Adjust the OSD timeout.

Language Language N/A Select the language you like.

Show the resolution, H/V frequency and


Information Information N/A
input port of current input timing.
Clear each old status of Auto-configuration
Yes N/A
Reset and set the color temperature to Cool.

No N/A Do not execute reset, return to main menu.

Exit N/A N/A Exit OSD

8
15” LCD Color Monitor LENOVO D153A
4. Input/Output Specification
4.1 Input Signal Connector

Pin No. Description Pin No. Description

1. Red 9. +5V
2. Green 10. Logic Ground
3. Blue 11. RS-232RX
4. RS232-TX 12. DDC-Serial Data
5. DDC-Return 13. H-Sync
6. R-Ground 14. V-Sync
7. G-Ground 15. DDC-Serial Clock
8. B-Ground

VGA connector layout

1 5
6 10
11 15

9
15” LCD Color Monitor LENOVO D153A
4.2 Factory Preset Display Modes

Addressability Vertical Frequency (Hz)


640 x 480 60
640 x 480 66
640 x 480 72
640 x 480 75
640 x 350 70
720 x 400 70
800 x 600 60
800 x 600 72
800 x 600 75
1024 x 768 60
1024 x 768 70
1024 x 768 75

4.3 Panel Specification


4.3.1 Structure And Principle
SVA150XG10TB module is composed of the amorphous silicon thin film transistor liquid crystal display (a-Si TFT
LCD) panel structure with driver LSIs for driving the TFT (Thin Film Transistor) array and a backlight. The a-Si TFT
LCD panel structure is injected liquid crystal material into a narrow gap between the TFT array glass substrate and a
color-filter glass substrate. Color (Red, Green, Blue) data signals from a host system (e.g. PC, signal generator, etc.)
are modulated into best form for active matrix system by a signal processing board, and sent to the driver LSIs
which drive the individual TFT arrays.
The TFT array as an electro-optical switch regulates the amount of transmitted light from the backlight assembly,
when it is controlled by data signals. Color images are created by regulating the amount of transmitted light through
the TFT array of red, green and blue dots.

10
15” LCD Color Monitor LENOVO D153A
4.3.2 General Specification

11
15” LCD Color Monitor LENOVO D153A

4.3.3 Electrical Characteristics


1. TFT LCD Module:

2. Back Light Unit:

12
15” LCD Color Monitor LENOVO D153A
5. Block Diagram
5.1 Software Flow Chat

Y
2 3

5 N

N
7 8

10 N
11

N N
12 13

Y Y

14 15 16

17

N
18 19

13
15” LCD Color Monitor LENOVO D153A

1) MCU initialize.
2) Is the EPROM blank?
3) Program the EPROM by default values.
4) Get the PWM value of brightness from EPROM.
5) Is the power key pressed?
6) Clear all global flags.
7) Are the AUTO and SELECT keys pressed?
8) Enter factory mode.
9) Save the power key status into EPROM.
Turn on the LED and set it to green color.
Scalar initializes.
10) In standby mode?
11) Update the lifetime of back light.
12) Check the analog port, are there any signals coming?
13) Does the scalar send out an interrupt request?
14) Wake up the scalar.
15) Are there any signals coming from analog port?
16) Display "No connection Check Signal Cable" message. And go into standby mode after the message
disappear.
17) Program the scalar to be able to show the coming mode.
18) Process the OSD display.
19) Read the keyboard. Is the power key pressed?

14
15” LCD Color Monitor LENOVO D153A
5.2 Electrical Block Diagram
5.2.1 Main Board

EEPROM
M24C16-WMN6T
LCD Interface

MCU Scaler MST8011B


Crystal
(W78E65P) (Include: ADC, OSD etc) 14.318MHZ

OSD Control D-SUB


Interface (Keypad) Connector

EEPROM
AT24C02N

15
15” LCD Color Monitor LENOVO D153A
5.2.2 Inverter/Power Board

16
15” LCD Color Monitor LENOVO D153A
6. Schematic
6.1 Main Board
715G1237-3-3
VCC5V+
VCC5V

D202 SOT-252
VCC12V U201
R202 GS1D VCC2.5
VCC12V 6
AZ1117D-1.8-E1
CN201 10K 1/16W 3 2
VI VO VCC2.5 4
GND 1 2 ON_OFF R201 4.7K 1/16W

GND
GND 3 4 DIM C210 + C211 C212
VCC12V 5 6 VCC12V 47uF/16V

3
GND 7 8 GND C201 R212 4.7K 1/16W 0.1uF 0.1uF
VCC5V 9 10 VCC5V 1

1
onBACKLITE 6
GND 11 12 GND 0.1uF Q201
PMBS3904

2
D201 SS14
CONN
VCC5V+

VCC5V
VCC5V
FB202 FB203 FB205
NC NC NC
R203 C218 C219
VCC5V 3,4,6
1K 1/16W
NC NC
VCPU
Brightness FB201 FB204 VCC3.3
600 OHM NC
R204
10K 1/16W VCPU 6 VCC3.3 4
3

R205 4.7K 1/16W VCC5V+


4 AdjBACKLITE
1 Q202
PMBS3904
C206
C202
+ C203 +
C204
C205 TO-263
1uF/25V
0.1uF 220uF/25V 0.1uF U202 VAA1
2

220uF/25V AIC1084-33M
3 2
VIN VOUT VAA1 4
1
ADJ
C214 C215 + C216 VAA2

0.1uF 47uF/16V 0.1uF


VAA2 4
VAA3

VAA3 4
VAA4

VAA4 4

NEW
Circuit
VCC5V VCC5V VLCD
VLCD 5
VCC5V VCC3.3 VCC12V
R206
R214 delete R208

10K 1/16W 10K 1/16W


R209 R210 R213
R216 R215 Q203 NC
AO3401 0Ω 1/10W NC
3

R207 NC 100K 1/16W C217


1 Q204
6 onPanel_5V/3.3V
0.068uF
4.7K 1/16W PMBS3904
C207 + C208 R211 Title
2

10uF/16V POWER
0.1uF 50V 10K 1/16W
Size Document Number Rev
B
G1237-3-3-X-21-070105 5
Date: Thursday , September 20, 2007 Sheet 2 of 6

17
15” LCD Color Monitor LENOVO D153A
CN301
RXD 6
DB15 R301 150Ω 1/10W
TXD 6
11 1 FB301 0 1/16W C304 0.047uF
RIN 4
6 R302 150Ω 1/10W
12 2 FB302 0 1/16W C305 0.047uF
GIN 4
7 R303 150Ω 1/10W
13 3 FB303 0 1/16W C306 0.047uF
BIN 4
8

75 1/16W

75 1/16W
14 4 R304 470 1/16W C307 0.001uF
SOG 4

R326

R327
9 PC5V R325 C301 C302 C303
15 5
10 VGA_CON 75 1/16W NC NC NC
R305 150Ω 1/10W
D322 D323 C308 0.047uF
GNDR 4
TZMC5V6-GS08 R306 150Ω 1/10W
TZMC5V6-GS08 C309 0.047uF
GNDG 4
R307 150Ω 1/10W
C310 0.047uF
GNDB 4

3
D301 D302 D303
BAV99 BAV99 BAV99 VCC5V

VCC5V
R308

10K 1/16W

1
R309 100 1/16W VCC5V PC5V
ST_DET1 6
FB304 150 OHM

2
HSI 1 2 R310 1K 1/16W
HSY NC 4
D304

VSI R312 100 1/16W R311 1K 1/16W BAV70


VSY NC 4

D319 D320 R313 C311 R314 C312 D317

1
TZMC5V6-GS08 TZMC5V6-GS08 TZMC5V6-GS08
2.2K 1/16W 33pF 10K 1/16W 220pF R317 R318 C313
4.7KΩ 1/10W U301
4.7KΩ 1/10W 8 1 0.1uF
7 VCC A0 2
CLK_DDC 6 WP A1 3
DAT_DDC 5 SCL A2 4
R315 33Ω 1/10W SDA GND
R316 33Ω 1/10W M24C02WMN6
CN302
D321 D318
6 DDC_DAT
25 TZMC5V6-GS08 TZMC5V6-GS08
R 6 DDC_CLK
26
G 27 VCC5V DVI5V
B 29

2
RGB GND 28
HSY NC 8 D305
VSY NC 15 R319 NC
SY NC GND 6 CLK_DDC2 DVI5V NC
DDC SCL 7 DAT_DDC2 R321
DDC SDA 14 R320 NC NC
+5V 16 R322 NC
HPD ST_DET2 6

1
11
1/3shield 3 D314 D315 D316 C314 R323 R324 C315
2/4shield 19 NC NC NC NC NC U302
0/5shield 22 NC 8 1 NC
clk shield 7 VCC A0 2
18 R328 NC 6 WP A1 3
DAT0+ B+ 4 SCL A2
17 R329 NC 5 4
DAT0- B- 4 SDA GND
10 R330 NC
DAT1+ G+ 4
9 R331 NC NC
DAT1- G- 4
2 R332 NC
DAT2+ R+ 4
1 R333 NC
DAT2- R- 4
13
DAT3+ 12
DAT3- 5
DAT4+ 4
DAT4- 21
DAT5+ 20
DAT5- 23
clk+ CLK+ 4
24
clk- CLK- 4
3

NC D306 D307 D308 D309 D310 D311 D312 D313


NC NC NC NC NC NC NC NC

VCC5V
Title
2

INPUT
Size Document Number Rev
B
G1237-3-3-X-21-070105 5
Date: Monday , January 08, 2007 Sheet 3 of 6

18
15” LCD Color Monitor LENOVO D153A
VCC3.3 FB401 VPO VCC2.5 FB402 VDD

2 VCC3.3 2 VCC2.5
600 OHM 600 OHM
C405 +
10uF/16V C414 +
10uF/16V
VAD VPLLVDVI VDPLL VPO VDD
C406C407C408C409C410C411C412C413 C415C416C417C418
0.1uF0.1uF0.1uF0.1uF0.1uF0.1uF0.1uF0.1uF 0.1uF0.1uF0.1uF0.1uF

104
114
126

117
55
65

35

45
51

53

11
21
84
94

18
87
97
U401

AVDD_PLL

VDDP
VDDP
VDDP
VDDP
VDDP
VDDP
VDDP
AVDD_MPLL
AVDD
AVDD

VDDC
VDDC
VDDC
VDDC
AVDD_DVI
AVDD_DVI
102 PA0
63 LVA3P 103 PA1
3 RIN RIN0 LVA3M
3 GNDR 62 106 PA2
60 RIN0M LVACKP 107 PA3
3 GIN GIN0 LVACKM
3 GNDG 59 108 PA4
61 GIN0M LVA2P 109 PA5
3 SOG SOGIN0 LVA2M
3 BIN 58 110 PA6
57 BIN0 LVA1P 111 PA7
3 GNDB BIN0M LVA1M
3 HSY NC 37 112 PA8
38 HSY NC0 LVA0P 113 PA9 VAA1 FB403 VAD
3 VSY NC VSY NC0 LVA0M
29 PA[0..9]
DDC1_CLK/GPO8 PA[0..9] 5
28
DDC1_DAT/GPO7 2 VAA1
600 OHM
C421

0.1uF 50V
+ C419
40 10uF/16V
3 R+ R+
3 R- 41
43 R- C420
3 G+ G+
3 G- 44 118 PB0 0.1uF
46 G- NC/LVB3P 119 PB1 PB[0..9]
3 B+ B+ NC/LVB3M PB[0..9] 5
3 B- 47 120 PB2
49 B- NC/LVBCKP 121 PB3
3 CLK+ CK+ NC/LVBCKM
3 CLK- 50 122 PB4
52 CK- NC/LVB2P 123 PB5
VDVI REXT NC/LVB2M
R403 390 1/16W 124 PB6
NC/LVB1P 125 PB7
NC/LVB1M 128 PB8 VAA2 FB404 VPLL
NC/LVB0P 1 PB9
66 NC/LVB0M
REFP 2 VAA2
C401 600 OHM
TSU16AK-LF
0.1uF 67 + C422
REFM
10uF/16V
C423
0.1uF

6 CSZ 69
71 CSZ
6 SCL SCL
6 SDA 70
32 SDA VAA3 FB405 VDVI
6 HWRESET HWRESETZ
72 VCC5V
6 INT INT
2 VAA3
600 OHM

R407 R405 R404 R406 + C424


10uF/16V
10K 1/16W 10K 1/16W
73 10K 1/16W 10K 1/16W C425C426
2 AdjBACKLITE PWM0
74 VCC3.3 0.1uF0.1uF
6 Volume PWM1

C402 22pF 33 30
XIN ADO/NC AD0 6
77
AD1/NC AD1 6
X401 78 R402
AD2/NC AD2 6
31 VAA4 FB406 VDPLL
14.318MHz AD3/NC AD3 6 100 1/16W
34
XOUT 2 VAA4
C403 22pF 6 600 OHM
BUS TY PE/NC
C404 0.1uF 3 + C427
2 BY PASS R401 10uF/16V
AVSS_LPLL NC
AVSS_MPLL

AVSS_PLL

AVSS_DVI
AVSS_DVI
AVSS_DVI

C428
0.1uF
GNDC
GNDC
GNDC
GNDC
GNDP
GNDP
GNDP
GNDP
GNDP
GNDP
GNDP
AVSS
AVSS
AVSS

R401 R402

Direct Bus NC 4.7K


Title
105
115
127

116
68
56
64

36

54

39
42
48

10
20
85
95

19
86
96

3-WIRE 4.7K NC SCALER


Size Document Number Rev
B
G1237-3-3-X-21-070105 5
Date: Monday , January 08, 2007 Sheet 4 of 6

19
15” LCD Color Monitor LENOVO D153A
PA[0..9]
由33G8043-24-H改为33G802724B-H(061227)
4 PA[0..9]
PA0 LVA3P
PA1 LVA3M CN503
PA2 LVACKP
PA3 LVACKM LVB0M RXO0- 1 2 RXO0+ LVB0P
PA4 LVA2P LVB1M RXO1- 3 4 RXO1+ LVB1P
PA5 LVA2M LVB2M RXO2- 5 6 RXO2+ LVB2P
LVBCKM RXOC- 7 8 RXOC+ LVBCKP
PA6 LVA1P LVB3M RXO3- 9 10 RXO3+ LVB3P
PA7 LVA1M LVA0M RXE0- 11 12 RXE0+ LVA0P
LVA1M RXE1- 13 14 RXE1+ LVA1P
PA8 LVA0P LVA2M RXE2- 15 16 RXE2+ LVA2P
PB[0..9] PA9 LVA0M LVACKM RXEC- 17 18 RXEC+ LVACKP
4 PB[0..9]
PB0 LVB3P LVA3M RXE3- 19 20 RXE3+ LVA3P
PB1 LVB3M 21 22
PB2 LVBCKP 23 24
PB3 LVBCKM

PB4 LVB2P
PB5 LVB2M CONN R502
PB6 LVB1P
PB7 LVB1M 0 1/16W
PB8 LVB0P VLCD
PB9 LVB0M
VLCD 2

+ C509 C510 C511


NC
0.1uF 0.1uF

Title
PANEL INTERFACE
Size Document Number Rev
A
G1237-3-3-X-21-070105 5
Date: Monday , January 08, 2007 Sheet 5 of 6

20
15” LCD Color Monitor LENOVO D153A
VCPU

2 VCPU

RN601

8
7
6
5
8
7
6
5
R601 R602 C601 RN602

4.7 KOHM +-5% 1/16W


10K 1/16W 0.1uF 4.7 KOHM +-5% 1/16W
10K 1/16W

1
2
3
4
1
2
3
4
C602 22pF

44
U601
X601 35 43 POWER

VCC
EA/VP P0.0 42 ENTER
21 P0.1 41 RIGHT
XTAL1 P0.2
+ C603 20MHz 40 LEFT
VCPU NC P0.3 39 AUTO
U603 MAX810STR 20 P0.4 38 LED_B
C604 22pF XTAL2 P0.5 37 LED_O
3 2 10 P0.6 36 LED_G
VCC RST RESET P0.7
GND

24 R636 0Ω+-5% 1/10W


P2.0 HWRESET 4
D601 R603 12 25
P4.3 P2.1 onPANEL_5V/3.3V 2
14 26
4 INT INT0/P3.2 P2.2 onBACKLITE 2
NC NC 15 27
1

INT1/P3.3 P2.3 CSZ 4


Reset 28
P2.4 SCL 4
Circuit VCPU 33 29
ALE/P P2.5 SDA 4
32 30 R606 10K 1/16W
PSEN P2.6 VCPU
R604 10K 1/16W R608 100 1/16W 2 31 R607 10K 1/16W
R605 10K 1/16W R609 100 1/16W 3 P1.0 P2.7
C605. U602 4 P1.1 16
P1.2 T0/P3.4 AD0 4
0.22UF16V 1 8 5 17
AD1 4
2 A0 VCC 7 R639 100 1/16W 6 P1.3 T1/P3.5 18
AD2 4
3 A1 WP 6 7 P1.4 P3.6/WR 19
AD3 4
4 A2 SCL 5 8 P1.5 P3.7/RD 13 R610 NC

VSS
GND SDA P1.6 P3.1/TXD DDC_DAT 3
9 11 R611 NC
P1.7 P3.0/RXD DDC_CLK 3
M24C16-WMN6TP R638 NC R634 100 1/16W
TXD 3
R615 10K 1/16W W78E65P-40 R635 100 1/16W
RXD 3

22
R614 10K 1/16W
VCC12V
FB601 NC
VCC5V
VCPU CN603
CN601
VCC12V 2
FB602 NC VCPU 1 R612R613
2 1 C618
1 2 3 2
VCC5V 2,3,4 3
3 4 R632 R631 4 0.1uF
5 6 R627 NC Standby 4 NC 10K 1/16W
7 8 R626 NC Mute NC NC
9 10 NC
3 ST_DET1
OUT-L+ 11 12 OUT-R+ R630 NC DVI-DSUB SELECT
3 ST_DET2
OUT-L- 13 14 OUT-R- VCC5V R633 NC Mute_key
C613 C612 VCC5V

NC NC R643
NC R640 NC C614 C615
NC
NC NC
Q604
3

NC
1
Volume 4 VCPU
R641 NC
VCPU VCPU
2

FB603 R642 NC R628


NC R625 NC R617 NC R618

C617 C611 120 1/16W 120 1/16W


Q603
R629

2
NC NC PMBS3906 Q602
2

2
R616 1 LED_B PMBS3906
LED_G 1 Q601 CN602 1 R619 LED_O
R637
4.7K 1/16W PMBS3906
DVI-DSUB SELECT 1 2 LED_BLUE NC 4.7K 1/16W

3
LED_GRN 3 4 LED_ORANGE NC
3

3
AUTO R620 470 1/16W 5 6 R621 470 1/16W ENTER
RIGHT R622 470 1/16W 7 8 R623 470 1/16W LEFT
POWER R624 470Ω 1/10W 9 10
11 12 Mute_key
OUT-L+ 13 14 OUT-R+
C606 C608 C610 OUT-L- 15 16 OUT-R- C616 C609
1000pF 1000pF 1000pF NC C607 1000pF
1000pF

CONN Title
MCU
Size Document Number Rev
B
G1237-3-3-X-21-070105 5
Date: Monday , January 08, 2007 Sheet 6 of 6

21
15” LCD Color Monitor LENOVO D153A
6.2 Power Board
715G1034-1-AO

22
15” LCD Color Monitor LENOVO D153A

23
15” LCD Color Monitor LENOVO D153A
6.3 Audio Board
715G1144-1-IO

24
15” LCD Color Monitor LENOVO D153A
7. PCB Layout
7.1 Main Board
715G1237-3-3

25
15” LCD Color Monitor LENOVO D153A

26
15” LCD Color Monitor LENOVO D153A
7.2 Power Board
715G1034-1-AO

27
15” LCD Color Monitor LENOVO D153A

7.3 Audio Board


715G1144-1-IO

28
15” LCD Color Monitor LENOVO D153A

7.4 Key Board


715G1244-1-2

29
15” LCD Color Monitor LENOVO D153A
8. Maintainability
8.1 Equipments and Tools Requirement
1. Voltmeter.

2. Oscilloscope.

3. Pattern Generator.

4. DDC Tool with an IBM Compatible Computer.

5. Alignment Tool.

6. LCD Color Analyzer.

7. Service Manual.

8. User Manual.

30
15” LCD Color Monitor LENOVO D153A
8.2 Trouble Shooting
8.2.1 Main Board
No power

No power

Press power key and look


if the picture is normal

NG

Please reinsert and make sure


the AC of 100-240 is normal

Reinsert or check the


NG
OK Adapter/Inverter
section

Measure U201 PIN2=2.5V


U202 PIN2=3.3V

NG Check CN201 or replace


OK U201, U202

X601 and X401 oscillate


waveforms are normal

NG
OK Replace X601, X401

Replace U601

NG

Replace U401

31
15” LCD Color Monitor LENOVO D153A
No picture (LED orange)

No picture

The button if NG
X601 oscillate NG
Replace X601
under control waveform is normal

OK

OK
Check reset circuit of NG Check Correspondent
U601 is normal component
Measure U201 PIN2=2.5V
U202 PIN2=3.3V OK

NG Replace U601
Replace
U201, U202
OK

X401 oscillate
waveform is normal

OK NG
Replace X401

Check HS/VS from


CN301 is normal
Replace U401

NG
Check Correspondent
OK component

Replace U401

32
15” LCD Color Monitor LENOVO D153A
White screen

White screen

NG
Measure Q204 base X601 oscillate
is high level? waveform is normal

OK NG Replace X601
OK

Check Q204 is broken or Check reset circuit of


CN503 solder? U601 is normal

NG NG
Check Correspondent
component. Check Correspondent
component.
OK OK

Replace PANEL Replace U601

33
15” LCD Color Monitor LENOVO D153A
8.2.2 Power/Inverter Board
1) No power

No power

Check AC line volt 110V or 220V

NG
OK Check AC line

Check the voltage of C905(+)

NG Check F901, BD901


OK

Check start voltage for the pin3 of IC901=16V

NG
Check R906, R907, IC901
OK

The auxiliary voltage (pin 7) is between 10V-16V jumping

NG (Stable)
OK Check D910, D912,

ZD902,ZD903
1) Check IC901,T901
2) Check ZD902, ZD903, ZD904
3) Check IC902, IC903

34
15” LCD Color Monitor LENOVO D153A
2) W / LED, No Backlight

Check C201 (+) =12V

NG
Check F201
OK Check D201/Q209/Q210
Check D202/Q211/Q212
Check ON/OFF signal

NG
OK Check Interface board

Check U201 pin9=12V voltage

NG
Change Q201 or Q202
OK

Check the pin7/10 of U201 if have waveforms

NG

Short Q203/Q204 if the picture normal

OK
Change U201
NG

Connect PIN15 of U201 to the ground and check Q209/Q210 collector waveforms

NG
Change Q209/Q210/PT201
OK

Check feedback circuit


NG

Check connecter & lamp

35
15” LCD Color Monitor LENOVO D153A
8.2.3 Keypad Board

OSD is unstable or not working

N
Is Key Pad Board connecting normally? Connect Key Pad Board

N
Is Button Switch normally? Replace Button Switch

N
Is Key Pad Board normally? Replace Key Pad Board

Check Main Board

36
15” LCD Color Monitor LENOVO D153A
9. White-Balance, Luminance Adjustment
Approximately 30 minutes should be allowed for warm up before proceeding White-Balance adjustment.

1. How to do the Chroma-7120 MEM. Channel setting

A. Reference to chroma 7120 user guide

B. Use “SC” key and “NEXT” key to modify XyY value and use “ID” key to modify the

TEXT description Following is the procedure to do white-balance adjust

2. Setting the color temp. you want

A. MEM.CHANNEL 3 (Warm color):

6500 color temp. parameter is x = 313±20, y = 329 ±20, Y =150 cd/m2

B. MEM.CHANNEL 4 (Cool color):

7800 color temp. parameter is x = 296 ±20, y = 311 ±20, Y = 150 cd/m2 ,

3. Into factory mode of LENOVO D153A

Turn on power, press the MENU button, pull out the power cord, and then plug the power cord. Then the factory

OSD will be at the panel.

4. Bias adjustment:

Set the Contrast to 50; Adjust the Brightness to 80.

5. Gain adjustment:

Move cursor to “-F-” and press MENU key

A. Adjust Warm color-temperature

1. Switch the chroma-7120 to RGB-Mode (with press “MODE” button)

2. Switch the MEM.channel to Channel 3 (with up or down arrow on chroma 7120)


2
3. The LCD-indicator on chroma 7120 will show x = 313 ±20, y = 329 ±20, Y = 150 cd/m

4. Adjust the RED on factory window until chroma 7120 indicator reached the value R=100

5. Adjust the GREEN on factory window until chroma 7120 indicator reachedthe value G=100

6. Adjust the BLUE on factory window until chroma 7120 indicator reached the value B=100

7. Repeat above procedure (item 4,5,6) until chroma 7120 RGB value meet the tolerance =100±2

37
15” LCD Color Monitor LENOVO D153A
B. Adjust Cool color-temperature

1. Switch the Chroma-7120 to RGB-Mode (with press “MODE” button)

2. Switch the MEM. Channel to Channel 4 (with up or down arrow on chroma 7120)
2
3. The LCD-indicator on chroma 7120 will show x = 296 ±20, y = 311 ±20, Y =150 cd/m

4. Adjust the RED on factory window until chroma 7120 indicator reached the value R=100

5. Adjust the GREEN on factory window until chroma 7120 indicator reached the value G=100

6. Adjust the BLUE on factory window until chroma 7120 indicator reached the value B=100

7. Repeat above procedure (item 4,5,6) until chroma 7120 RGB value meet the tolerance =100±2

C. Turn the Power-button off to quit from factory mode.

38
15” LCD Color Monitor LENOVO D153A
10. Monitor Exploded View

39
15” LCD Color Monitor LENOVO D153A
11. BOM List
T57VMXHQACH16N
Location Part No. for TPV Description
015G5791 1 VESA BKT
015G5908 2 BRACKET
033G4694 1 C POWER LENS
044G3231 15 EVA WASHER
044G3231 15528 EVA WASHER
044G3525615 6A CARTON
M044A 044G3553 1 EPS(L)
M044B 044G3553 2 EPS(R)
045G 77500 BARCODE RIBBON
052G 1174 2A 3M 69#
052G 1186 SMALL TAPE
052G 1191 GLASS CLOTH
052G 1192 GLASS CLOTH
052G 1211 A 165MINIUM TAPE
052G 192 3 BIG TAPE FOR CARTON
E07801 078G 314 2 4028 SPEAKER 8OHM 1W
E07801 078G 314 2 G SPEAKER
E07801 078G 314 2 K SPEAKER
085G 654 3 SHIELD
089G 17356C553 AUDIO CABLE 1800MM
PE089B1 089G 725GAA DB D-SUB
PE089B1 089G 725HAA DB D-SUB
PE089B1 089G 725LAA DB D-SUB
089G402A18NLS3 POWER CORD
095G8014 16584 WIRE HARNESS
E09501 095G8018 14507 HARNESS
0M1G 330 4120 SCREW 42A9930008
0M1G 330 4120 SCREW 42A9930008
0M1G 330 6 47 CR3 SCREW 42-D005390
0M1G1140 5120 SCREW
0M1G1730 6120 SCREW
0Q1G 330 6120 SCREW 42A9930001
0Q1G 330 10 47 CR3 SCREW
705GQ734502 15" LCD STAND COVER ASS'Y
E750L 750GLD5010T11N PANEL SVA150XG10TB A SH SVA
AM1G1740 10 47 CR3 SCREW
AUPC3QA1P8 AUDIO BOARD
CBPC7VMXG8Q2 MAIN BOARD
KEPC3QA1P8 KEY BOARD
PK1521SVE1P POWER BOARD
Q15G5935 30CKD MAIN FRAME
Q33G4693AAF 1L KEY PAD
40
15” LCD Color Monitor LENOVO D153A
Q34G1274AAF 1B BASE
Q34G1295AAFA1B BEZEL(L503A-C1)
Q34G1298AAFA2B REAER COVER(L503A-C1)
Q40G 15N608 3A RATING LABEL
Q40G0001608 7A CARTON LABEL
Q41G780060852A qsg
Q45G 76 28CK2 R PE BAG
Q45G 88609121 EPE COVER
Q70G500A608 2B cd manual
E09501 S95G801814507 LVDS ASS'Y
Q45G 99606 24 ESD insulating pe bag
012G 394 1 FOOT PORON
033G4695 1 C CLAMP
037G 495 1 HINGE ASS'Y
0Q1G1030 8120 SCREW
0Q1G1030 10120 SCREW 42-D003792
Q34G1273AAF 1B STAND
CN202 033G802414C H 2*7PIN DUAL ROW RIGHT ANGLE H
U201 056G 616 1 IC E-TDA7496L ST
090G6059 1 HEAT SINK
CN204 095G8014 3503 WIRE HARNESS
CN601 033G801714A BH CONNECTOR
CN201 033G8027 12 WAFER 2*6P 2.0MM R/A
CN503 033G8027 14 H WAFER 14P 2.0MM DIP
CN602 033G8027 16 WAFER 16PIN 2.0mm DIP
040G 45762412B CBPC LABEL
C202 067G215B2214HV LOW ESR 220UF 25V 8*11
C204 067G215B2214HV LOW ESR 220UF 25V 8*11
C422 067G305V100 3 10UF +-20% 16V
C208 067G305V100 3 10UF +-20% 16V
C405 067G305V100 3 10UF +-20% 16V
C414 067G305V100 3 10UF +-20% 16V
C419 067G305V100 3 10UF +-20% 16V
C424 067G305V100 3 10UF +-20% 16V
C427 067G305V100 3 10UF +-20% 16V
C509 067G305V100 3 10UF +-20% 16V
C211 067G305V470 3 147UF +-20% 16V
C215 067G305V470 3 47UF +-20% 16V
CN301 088G 35315F HS D-SUB 15P
CN301 088G 35315FHSJ D-SUB 15PIN CONNECTOR
X401 093G 22 53 TAL 14.318MHzHC-49US
X401 093G 22 53 J 14.31818MHZ/32PF/49US
X601 093G 22 55 CRYSTAL 20MHZ HC-49US
X601 093G 22 55 J 20MHz/20PF/49US
CN103 033G3802 2H WAFER 2P RIGHT ANGLE
CN104 033G3802 2H WAFER 2P RIGHT ANGLE

41
15” LCD Color Monitor LENOVO D153A
CN101 033G801712A H PIN HEADER 2*6 R/A
SW101 077G 603 2 CJ TACT SWITCH
SW102 077G 603 2 CJ TACT SWITCH
SW103 077G 603 2 CJ TACT SWITCH
SW105 077G 603 2 CJ TACT SWITCH
SW104 077G 603 2 CJ TACT SWITCH
DP101 081G 12 2 GP GP36032ME/50-ZO
CN102 088G 30211K PHONE JACK 5PIN
CN302 033G3278 3 3P PLUG B3B-XHA/JST
CN201 033G8020 2D U WAFER
CN202 033G8020 2D U WAFER
IC902 056G 139 3 PC123FY2 BY SHARP
IC902 056G 139 7 1 IC EL817MA M-TYPE
IC902 056G 139 3A IC PC123Y22FZ0F
IC902 056G 139 3B IC PC123Y82FZ0F
IC901 056G 379 77 IC LD7552BPN DIP-8
Q903 057G 723 3B 2SK2761-01MR
Q903 057G 724 4 MOSFET 2SK2996
Q903 057G 724 4A STP9NK60ZFP TO-220FP BY ST
Q209 057G 761 6 2SC5706-P-E
Q210 057G 761 6 2SC5706-P-E
NR901 061G 58080 WT 8 OHM NCT
R903 061G152M104 64 100KOHM 5% 2W
C904 063G 10747410V 0.47UF 275VAC ARCO
C904 063G107K474 US 0.47UF +-10%
C213 063G210J2242AC FILM CAP 0.22UF J 250V
C906 065G 2K152 5E6052 1500 PF 10% 2KV Y5P
C906 065G 2K152 5E6285 1500 PF 10% 2KV Y5P
C906 065G 2K152 5E6921 1500 PF 10% 2KV Y5P
C215 065G 6J2206E3 R 22PF J 6KV NP0
C216 065G 6J2206E3 R 22PF J 6KV NP0
C901 065G305M1022BP Y2 1000PF M 250VAC Y5P
C902 065G305M1022BP Y2 1000PF M 250VAC Y5P
C901 065G305M1022E2 1000P 400VAC/250VAC
C902 065G305M1022E2 1000P 400VAC/250VAC
C913 065G306M4722BM 4700PF +-20% 400VAC
C913 065G306M4722BP 4700PF +-20% 400VAC
C922 067G215S1023KV 105℃ 1000UF M 16V
C925 067G215S1023KV 105℃ 1000UF M 16V
C922 067G215V102 3N GP KY10VB1000M-CC3 10*16
C925 067G215V102 3N GP KY10VB1000M-CC3 10*16
C201 067G215Y4713NV KY16VB470M-CC3 8*15MM
C924 067G215Y4713NV KY16VB470M-CC3 8*15MM
C926 067G215Y4713NV KY16VB470M-CC3 8*15MM
C201 067G215Y4713RV LOW E.S.R 470UF +-20% 16V
C924 067G215Y4713RV LOW E.S.R 470UF +-20% 16V

42
15” LCD Color Monitor LENOVO D153A
C926 067G215Y4713RV LOW E.S.R 470UF +-20% 16V
C905 067G215Z10115K ELCAP 100UF M 450V
L202 073G 174 30LSA FILTER
L202 073G 174 30YSA FILTER
L904 073G 253 91 H CHOKE COIL
L903 073G 253 91 H CHOKE COIL
L904 073G 253 91 L CHOKE BY LI TA
L903 073G 253 91 L CHOKE BY LI TA
L903 073G 253 91 LS CHOKE BY LI SHIN
L904 073G 253 91 LS CHOKE BY LI SHIN
L201 073G 253139 HA CHOKE COIL
L201 073G 253139 SA CHOKE COIL
L201 073G 253139 YA CHOKE COIL
L201 073G 253139LSA CHOKE COIL
L902 073L 174 26LSG LINE FILTER 27mH
L902 073L 174 26T1G LINE FILTER 27mH
PT201 080LL15T 7DNG X'FMR
T901 080LL17T 2 LG ADAPTOR BY LITAI
T901 080LL17T 2 TG X'FMR
T901 080LL17T 2LSG ADAPTOR BY LISHIN
F901 084G 7H200 SL 250V/2A LIHEL FUSE
CN301 088G 30229C PHINE JACL
BD901 093G 50460509 2KBP06M 2A 600V
D912 093G3006 1 1 31DQ06FC3 NIHON INTER
CN102 095G8021 12520 WIRE HARNESS
705G 560 61 09 R919 ASS'Y (ROHS)
705G 780 57 02 CN901 ASS'Y
705G 780 57 06 D910 ASS'Y (ROHS)
L202 S73G17430VA FILTER ASS'Y
L902 S73L17426VG LINE FILTER ASS'Y
T901 S80LL17T2VGW TRANSFORMER ASS'Y
033F 206 14 DF11-14DS-2C
033F206T 24 DF11-2428SCF
033F303SM24H20 P240420
033F303STM24T2 2404PS-2
071FW100001007 19*12*6.5*1.5+热缩套管
R208 061G0603102 RST CHIP 1K 1/10W 5%
R207 061G0603102 RST CHIP 1K 1/10W 5%
R203 061G0603183 RST CHIPR 18 KOHM +-5% 1/10W
R201 061G0603183 RST CHIPR 18 KOHM +-5% 1/10W
R211 061G0603203 RST CHIPR 20 KOHM +-5% 1/10W
R210 061G0603203 RST CHIPR 20 KOHM +-5% 1/10W
C211 065G0805101 31 CHIP 100PF 50V NPD 0805
C212 065G0805101 31 CHIP 100PF 50V NPD 0805
C203 065G0805104 32 CHIP 0.1U 50V X7R
C213 065G0805104 32 CHIP 0.1U 50V X7R

43
15” LCD Color Monitor LENOVO D153A
C204 065G0805474 22 CHIP 0.47UF 25V X7R 0805
C206 065G0805474 22 CHIP 0.47UF 25V X7R 0805
040G 457624 1B LABEL-CPU
U401 056G 562 57 MST8011B-LF PQFP-128
U202 056G 563 7 IC AIC1084-33PMTR-R AIC
U201 056G 585 7A AZ1117D-2.5-E1
U603 056G 643 9 EM6353BZ2SP3B-2.9
U603 056G 643 5A MAX810 STRG
056G1125137 X
U601 (LLNMXW5EAQ1) W78E065A40PL PLCC44
U301 056G1133 34 M24C02-WMN6TP
U602 056G1133 56 M24C16-WMN6TP
U301 056G1133 84 AF24BC02-S1
U602 056G1133 89 IC AF24BC16-SI 16K SOIC-8
Q201 057G 417 4 PMBS3904/PHILIPS-SMT(04)
Q202 057G 417 4 PMBS3904/PHILIPS-SMT(04)
Q204 057G 417 4 PMBS3904/PHILIPS-SMT(04)
Q601 057G 417 6 PMBS3906/PHILIPS-SMT(06)
Q602 057G 417 6 PMBS3906/PHILIPS-SMT(06)
Q203 057G 763 1 A03401 SOT23 BY AOS(A1)
RN601 061G 125472 8 RST CHIP AR 8P4R 4.7 KOHM +-5% 1/16W
RN602 061G 125472 8 RST CHIP AR 8P4R 4.7 KOHM +-5% 1/16W
R642 061G0603000 RST CHIPR 0 OHM +-5% 1/10W
R636 061G0603000 RST CHIPR 0 OHM +-5% 1/10W
R502 061G0603000 RST CHIPR 0 OHM +-5% 1/10W
R210 061G0603000 RST CHIPR 0 OHM +-5% 1/10W
FB303 061G0603000 RST CHIPR 0 OHM +-5% 1/10W
FB302 061G0603000 RST CHIPR 0 OHM +-5% 1/10W
FB301 061G0603000 RST CHIPR 0 OHM +-5% 1/10W
R301 061G0603101 RST CHIPR 100 OHM +-5% 1/10W
R302 061G0603101 RST CHIPR 100 OHM +-5% 1/10W
R303 061G0603101 RST CHIPR 100 OHM +-5% 1/10W
R305 061G0603101 RST CHIPR 100 OHM +-5% 1/10W
R306 061G0603101 RST CHIPR 100 OHM +-5% 1/10W
R307 061G0603101 RST CHIPR 100 OHM +-5% 1/10W
R309 061G0603101 RST CHIPR 100 OHM +-5% 1/10W
R312 061G0603101 RST CHIPR 100 OHM +-5% 1/10W
R322 061G0603101 RST CHIPR 100 OHM +-5% 1/10W
R402 061G0603101 RST CHIPR 100 OHM +-5% 1/10W
R608 061G0603101 RST CHIPR 100 OHM +-5% 1/10W
R609 061G0603101 RST CHIPR 100 OHM +-5% 1/10W
R634 061G0603101 RST CHIPR 100 OHM +-5% 1/10W
R635 061G0603101 RST CHIPR 100 OHM +-5% 1/10W
R639 061G0603101 RST CHIPR 100 OHM +-5% 1/10W
R624 061G0603102 RST CHIP 1K 1/10W 5%
R311 061G0603102 RST CHIP 1K 1/10W 5%

44
15” LCD Color Monitor LENOVO D153A
R310 061G0603102 RST CHIP 1K 1/10W 5%
R203 061G0603102 RST CHIP 1K 1/10W 5%
R206 061G0603103 RST CHIPR 10 KOHM +-5% 1/10W
R208 061G0603103 RST CHIPR 10 KOHM +-5% 1/10W
R211 061G0603103 RST CHIPR 10 KOHM +-5% 1/10W
R308 061G0603103 RST CHIPR 10 KOHM +-5% 1/10W
R314 061G0603103 RST CHIPR 10 KOHM +-5% 1/10W
R317 061G0603103 RST CHIPR 10 KOHM +-5% 1/10W
R318 061G0603103 RST CHIPR 10 KOHM +-5% 1/10W
R321 061G0603103 RST CHIPR 10 KOHM +-5% 1/10W
R404 061G0603103 RST CHIPR 10 KOHM +-5% 1/10W
R405 061G0603103 RST CHIPR 10 KOHM +-5% 1/10W
R406 061G0603103 RST CHIPR 10 KOHM +-5% 1/10W
R407 061G0603103 RST CHIPR 10 KOHM +-5% 1/10W
R601 061G0603103 RST CHIPR 10 KOHM +-5% 1/10W
R602 061G0603103 RST CHIPR 10 KOHM +-5% 1/10W
R604 061G0603103 RST CHIPR 10 KOHM +-5% 1/10W
R605 061G0603103 RST CHIPR 10 KOHM +-5% 1/10W
R606 061G0603103 RST CHIPR 10 KOHM +-5% 1/10W
R607 061G0603103 RST CHIPR 10 KOHM +-5% 1/10W
R613 061G0603103 RST CHIPR 10 KOHM +-5% 1/10W
R625 061G0603103 RST CHIPR 10 KOHM +-5% 1/10W
R626 061G0603103 RST CHIPR 10 KOHM +-5% 1/10W
R204 061G0603103 RST CHIPR 10 KOHM +-5% 1/10W
R202 061G0603103 RST CHIPR 10 KOHM +-5% 1/10W
R627 061G0603103 RST CHIPR 10 KOHM +-5% 1/10W
R215 061G0603104 RST CHIPR 100 KOHM +-5% 1/10W
R618 061G0603121 RST CHIPR 120 OHM +-5% 1/10W
R617 061G0603222 RST CHIPR 2.2 KOHM +-5% 1/10W
R313 061G0603222 RST CHIPR 2.2 KOHM +-5% 1/10W
R316 061G0603330 RST CHIPR 33 OHM +-5% 1/10W
R315 061G0603330 RST CHIPR 33 OHM +-5% 1/10W
R403 061G0603390 0F RST CHIPR 390 OHM +-1% 1/10W
C510 061G0603391 RST CHIPR 390 OHM +-5% 1/10W
R623 061G0603471 RST CHIPR 470 OHM +-5% 1/10W
R622 061G0603471 RST CHIPR 470 OHM +-5% 1/10W
R621 061G0603471 RST CHIPR 470 OHM +-5% 1/10W
R620 061G0603471 RST CHIPR 470 OHM +-5% 1/10W
R304 061G0603471 RST CHIPR 470 OHM +-5% 1/10W
R205 061G0603472 RST CHIPR 4.7KOHM +-5% 1/10W
R207 061G0603472 RST CHIPR 4.7KOHM +-5% 1/10W
R212 061G0603472 RST CHIPR 4.7KOHM +-5% 1/10W
R616 061G0603472 RST CHIPR 4.7KOHM +-5% 1/10W
R201 061G0603472 RST CHIPR 4.7KOHM +-5% 1/10W
R619 061G0603472 RST CHIPR 4.7KOHM +-5% 1/10W
R327 061G0603750 RST CHIPR 75 OHM +-5% 1/10W

45
15” LCD Color Monitor LENOVO D153A
R326 061G0603750 RST CHIPR 75 OHM +-5% 1/10W
R325 061G0603750 RST CHIPR 75 OHM +-5% 1/10W
C617 065G0603101 31 CER1 0603 NP0 50V 100P PM5 R
C307 065G0603102 32 1000PF +-10% 50V X7R
C606 065G0603102 32 1000PF +-10% 50V X7R
C607 065G0603102 32 1000PF +-10% 50V X7R
C608 065G0603102 32 1000PF +-10% 50V X7R
C609 065G0603102 32 1000PF +-10% 50V X7R
C610 065G0603102 32 1000PF +-10% 50V X7R
C612 065G0603104 12 CER2 0603 X7R 16V 100N P
C613 065G0603104 12 CER2 0603 X7R 16V 100N P
C201 065G0603104 32 CHIP 0.1UF 50V X7R
C203 065G0603104 32 CHIP 0.1UF 50V X7R
C205 065G0603104 32 CHIP 0.1UF 50V X7R
C210 065G0603104 32 CHIP 0.1UF 50V X7R
C212 065G0603104 32 CHIP 0.1UF 50V X7R
C214 065G0603104 32 CHIP 0.1UF 50V X7R
C216 065G0603104 32 CHIP 0.1UF 50V X7R
C313 065G0603104 32 CHIP 0.1UF 50V X7R
C401 065G0603104 32 CHIP 0.1UF 50V X7R
C404 065G0603104 32 CHIP 0.1UF 50V X7R
C406 065G0603104 32 CHIP 0.1UF 50V X7R
C407 065G0603104 32 CHIP 0.1UF 50V X7R
C428 065G0603104 32 CHIP 0.1UF 50V X7R
C426 065G0603104 32 CHIP 0.1UF 50V X7R
C425 065G0603104 32 CHIP 0.1UF 50V X7R
C423 065G0603104 32 CHIP 0.1UF 50V X7R
C421 065G0603104 32 CHIP 0.1UF 50V X7R
C420 065G0603104 32 CHIP 0.1UF 50V X7R
C418 065G0603104 32 CHIP 0.1UF 50V X7R
C417 065G0603104 32 CHIP 0.1UF 50V X7R
C416 065G0603104 32 CHIP 0.1UF 50V X7R
C415 065G0603104 32 CHIP 0.1UF 50V X7R
C413 065G0603104 32 CHIP 0.1UF 50V X7R
C412 065G0603104 32 CHIP 0.1UF 50V X7R
C411 065G0603104 32 CHIP 0.1UF 50V X7R
C410 065G0603104 32 CHIP 0.1UF 50V X7R
C409 065G0603104 32 CHIP 0.1UF 50V X7R
C408 065G0603104 32 CHIP 0.1UF 50V X7R
C601 065G0603104 32 CHIP 0.1UF 50V X7R
C618 065G0603104 32 CHIP 0.1UF 50V X7R
C511 065G0603104 32 CHIP 0.1UF 50V X7R
C207 065G060310432T MLCC 0603 CAP 0.1UF K 50V X7R
C402 065G0603220 31 CER1 0603 NP0 50V 22P PM
C403 065G0603220 31 CER1 0603 NP0 50V 22P PM
C602 065G0603220 31 CER1 0603 NP0 50V 22P PM

46
15” LCD Color Monitor LENOVO D153A
C604 065G0603220 31 CER1 0603 NP0 50V 22P PM
C312 065G0603221 31 CER1 0603 NP0 50V 220P P
C605 065G0603224 17 CAP:CER 0.22UF-20%-80% 16V
C605 065G0603224 32 CHIP 0.22UF 50V X7R
C311 065G0603330 31 CER1 0603 NP0 50V 33P PM
C304 065G0603473 32 CHIP 0.047UF 50V X7R
C305 065G0603473 32 CHIP 0.047UF 50V X7R
C306 065G0603473 32 CHIP 0.047UF 50V X7R
C308 065G0603473 32 CHIP 0.047UF 50V X7R
C309 065G0603473 32 CHIP 0.047UF 50V X7R
C310 065G0603473 32 CHIP 0.047UF 50V X7R
C217 065G0603683 32 CHIP 0.068UF 50L X7R
C611 065G0805105 17 chip ceramic cap 1UF 16V
C206 065G0805105 22 CHIP 1UF 25V X7R 0805
FB304 071G 56G151 A TB160808G151
FB601 071G 56K121 M CHIP BEAD
FB603 071G 56Z601 CHIP BEAD 600 OHM 0805
FB406 071G 56Z601 CHIP BEAD 600 OHM 0805
FB405 071G 56Z601 CHIP BEAD 600 OHM 0805
FB404 071G 56Z601 CHIP BEAD 600 OHM 0805
FB403 071G 56Z601 CHIP BEAD 600 OHM 0805
FB402 071G 56Z601 CHIP BEAD 600 OHM 0805
FB401 071G 56Z601 CHIP BEAD 600 OHM 0805
FB201 071G 56Z601 CHIP BEAD 600 OHM 0805
FB201 071G 56Z601 M CHIP BEAD 600OHM
FB401 071G 56Z601 M CHIP BEAD 600OHM
FB402 071G 56Z601 M CHIP BEAD 600OHM
FB403 071G 56Z601 M CHIP BEAD 600OHM
FB404 071G 56Z601 M CHIP BEAD 600OHM
FB405 071G 56Z601 M CHIP BEAD 600OHM
FB406 071G 56Z601 M CHIP BEAD 600OHM
FB603 071G 56Z601 M CHIP BEAD 600OHM
D317 093G 39147 TZMC5V6
D318 093G 39147 TZMC5V6
D319 093G 39147 TZMC5V6
D320 093G 39147 TZMC5V6
D321 093G 39147 TZMC5V6
D322 093G 39147 TZMC5V6
D323 093G 39147 TZMC5V6
D317 093G 39149 MLL5232B BY FULL POWER SMT
D318 093G 39149 MLL5232B BY FULL POWER SMT
D319 093G 39149 MLL5232B BY FULL POWER SMT
D320 093G 39149 MLL5232B BY FULL POWER SMT
D321 093G 39149 MLL5232B BY FULL POWER SMT
D322 093G 39149 MLL5232B BY FULL POWER SMT
D323 093G 39149 MLL5232B BY FULL POWER SMT

47
15” LCD Color Monitor LENOVO D153A
D304 093G 64 42 P BAV70 SOT23 BY PAN JIT
D304 093G 64 42 PP BAV70 SOT-23
D301 093G 6433P BAV99
D302 093G 6433P BAV99
D303 093G 6433P BAV99
D201 093G1004 3 SS14
D202 093G1020 1 S GS1D
715G1237 3 3 MAIN BOARD PCB
R101 061G172S51152T 510OHM 1/6W
R102 061G172S51152T 510OHM 1/6W
715G1244 1 2 KEY BOARD PCB
R919 061G 2J39858G 0.39 OHM 5% 2W
096G 29 6 H.S. TUBE
CN901 087G 501 12 CJ AC SOCKET
CN901 087G 501 12 RF AC SOCKET
095G205S354022 HARNESS
096G 29 6 H.S. TUBE
D910 093G3010 1 A 31DQ10
Q90G 410 4 HEAT SINK
Q203 056G 566 10 SI4431DY-T1-SMT
U201 056G 622 1 BA9741F-SMT
Q202 057G 760 4 DTA144WKA BY ROHM SMT
Q201 057G 760 5 DTC144WKA BY ROHM SMT
Q202 057G 760 4B PDTA144WK SOT346
Q201 057G 760 5B PDTC144WK SOT346
Q203 057G 763 3 AO4411 SO-8
Q203 057G 763 4 RSS050P03
R208 061G0603000 RST CHIPR 0 OHM +-5% 1/10W
R929 061G0603000 RST CHIPR 0 OHM +-5% 1/10W
RJ901 061G0603000 RST CHIPR 0 OHM +-5% 1/10W
R218 061G0603101 RST CHIPR 100 OHM +-5% 1/10W
R931 061G0603102 RST CHIP 1K 1/10W 5%
R204 061G0603103 RST CHIPR 10 KOHM +-5% 1/10W
R222 061G0603103 RST CHIPR 10 KOHM +-5% 1/10W
R238 061G0603123 RST CHIPR 12 KOHM +-5% 1/10W
R216 061G0603221 RST CHIPR 220 OHM +-5% 1/10W
R214 061G0603222 RST CHIPR 2.2 KOHM +-5% 1/10W
R212 061G0603392 RST CHIPR 3.9 KOHM +-5% 1/10W
R236 061G0603511 RST CHIPR 510 OHM +-5% 1/10W
R240 061G0603513 RST CHIPR 51 KOHM +-5% 1/10W
R234 061G0603911 RST CHIPR 910 OHM +-5% 1/10W
R210 061G0603912 RST CHIPR 9.1 KOHM +-5% 1/10W
R927 061G0805102 RST CHIPR 1KOHM +-5% 1/8W
R928 061G0805102 RST CHIPR 1KOHM +-5% 1/8W
R940 061G0805221 RST CHIPR 220 OHM +-5% 1/8W
R926 061G0805240 1F RST CHIPR 2.4KOHM +-1% 1/8W

48
15” LCD Color Monitor LENOVO D153A
R924 061G0805330 2F RST CHIPR 33 KOHM +-1% 1/8W
R925 061G0805360 1F RST CHIPR 3.6KOHM +-1% 1/8W
R916 061G1206100 3F RST CHIPR 100 KOHM +-1% 1/4W
R912 061G1206101 100 1206
R219 061G1206102 RST CHIPR 1 KOHM +-5% 1/4W
R232 061G1206102 RST CHIPR 1 KOHM +-5% 1/4W
R915 061G1206103 RST CHIPR 10 KOHM +-5% 1/4W
R901 061G1206105 1M 1206
R902 061G1206105 1M 1206
R904 061G1206105 1M 1206
R905 061G1206105 1M 1206
R224 061G1206242 RST CHIPR 2.4 KOHM +-5% 1/4W
R225 061G1206242 RST CHIPR 2.4 KOHM +-5% 1/4W
R226 061G1206242 RST CHIPR 2.4 KOHM +-5% 1/4W
R227 061G1206242 RST CHIPR 2.4 KOHM +-5% 1/4W
R911 061G1206472 RST CHIPR 4.7 KOHM +-5% 1/4W
R910 061G1206472 RST CHIPR 4.7 KOHM +-5% 1/4W
R909 061G1206472 RST CHIPR 4.7 KOHM +-5% 1/4W
R907 061G1206684 RST CHIPR 680 KOHM +-5% 1/4W
R906 061G1206684 RST CHIPR 680 KOHM +-5% 1/4W
C399 065G0603471 32 CHIP 470PF 50V X7R
C398 065G0603471 32 CHIP 470PF 50V X7R
C205 065G0805104 22 0.1UF +-10% 25V X7R 080
C202 065G0805104 22 0.1UF +-10% 25V X7R 080
C936 065G0805104 32 CHIP 0.1U 50V X7R
C928 065G0805104 32 CHIP 0.1U 50V X7R
C927 065G0805104 32 CHIP 0.1U 50V X7R
C910 065G0805104 32 CHIP 0.1U 50V X7R
C219 065G0805105 27 CHIP 1UF Y5V 0805
C225 065G0805105 27 CHIP 1UF Y5V 0805
C209 065G0805105 27 CHIP 1UF Y5V 0805
C211 065G0805105 27 CHIP 1UF Y5V 0805
C203 065G0805105 27 CHIP 1UF Y5V 0805
C208 065G0805331 31 CHIP 330pF 50V NPO
C940 065G0805471 31 CHIP 470PF 50V NPO
C221 065G0805474 27 CHIP 0.47UF 25V Y5V
D203 093G 39S 3 T BZT52-C11
D203 093G 39S 8 T RLZ11B LLDS
ZD904 093G 39S 16 T SML4737A/1
ZD904 093G 39S 19 T PTZ7.5B
ZD901 093G 39S 20 T RLZ22B LLDS
ZD901 093G 39S 23 T GLZ22B
D201 093G2004 1 SMAL240LVXRO-SMT
D201 093G2004 3 SSM24PT
D201 093G2004 2A SM240A DO-214AC
D201 093G3004 1 SMAL340XXXRO 3A 40V SMA FULL P

49
15” LCD Color Monitor LENOVO D153A
D201 093G3004 2 SR34 PAN JIT
R212 061G 60220152T CFR 200 OHM +-5% 1/6W
C205 067G 3054713XT 470 uf 16v
C202 067G 3054713XT 470 uf 16v
C201 067G 3054713XT 470 uf 16v
C208 067G 3054713XT 470 uf 16v
C207 067G 3054713XT 470 uf 16v
C209 067G 3091097XT 1.0uF +-20% 50V
C210 067G 3091097XT 1.0uF +-20% 50V
715G1144 1 IO AUIDO BOARD PCB
CN901 006G 31500 EYELET
C905 006G 31502 1.5MM RIVET
L902 006G 31502 1.5MM RIVET
NR901 006G 31502 1.5MM RIVET
PT201 006G 31502 1.5MM RIVET
T901 006G 31502 1.5MM RIVET
IC903 056G 158 4 T H431BA
Q207 057G 414 2 MPS3906
Q205 057G 417 3 T MPS3904
Q902 057G 419 PP T 2PC945P
Q901 057G 420 PP T 2PA733P
R917 061G 17210052T 100HM 5% 1/4W
R930 061G 17210152T 100 OHM 5% 1/4W
R918 061G 17210352T CFR 10KOHM +-5% 1/4W
R908 061G 17268952T 6.8OHM 5% 1/4W
R920 061G 20747052T 47 OHM 1/2W
R922 061G 20747052T 47 OHM 1/2W
R220 061G 60218352T 18KOHM 5% 1/6
R205 061G 60247352T 47KOHM 5% 1/6W
R201 061G 60275352T 75KOHM 5%1/6W
C911 064G700J1020AT 1000PF 50V PEN
C909 064G700J1040AT 0.1UF 50V PEN
C204 064G700J1040AT 0.1UF 50V PEN
C908 065G 450104 7T 0.1UF +80-20% 50V Y5V
C921 065G517K102 5T6921 1000PF +-10% 500V Y5P
C920 065G517K102 5T6921 1000PF +-10% 500V Y5P
C907 067G 2152207NT KY50VB22M-TP5 5*11
C207 067G 2154797NT LOW ESR 4.7UF+-20% 50V BY CHEM
FB903 071G 55 19 T FERRITE BEAD D9X3. 5X0.8
FB901 071G 55 29 FERRITE BEAD
ZD902 093G 39 5452T HZ12B2-E
ZD903 093G 39 7752T HZ5C1-E
ZD903 093G 3957652T GDZJ5.1B BY PANJIT
D901 093G 6026W52T FR107
D902 093G 6038P52T PS102R
D903 093G 64 1152T 1N4148

50
15” LCD Color Monitor LENOVO D153A
D209 093G 64 1152T 1N4148
D207 093G 64 1152T 1N4148
D205 093G 64 1152T 1N4148
715G1034 1 AO POWER BOARD PCB

51

Вам также может понравиться