Академический Документы
Профессиональный Документы
Культура Документы
Technical knowledge
1. Throat thickness.
2. Leg lengths. ( answer )
3. Penetration depths.
4. Both 1 and 3.
4) Heavy porosity on the surface of some MMA welds made on a construction site
is most likely to be caused by :
8) Which of the following fillet welds is the strongest assuming they are all made
using the same material and welded using the same WPS?
9) A typical included angle for MMA welding a full penetration pipe butt is:
1. 350 .
2. 700. ( answer )
3. 900.
4. Dependent on the pipe diameter.
10) A fillet weld has an actual throat thickness of 8mm and a leg length of 7mm,
what is the excess weld metal?
1. 2.1mm
2. 1.8mm
3. 3.1mm ( answer )
4. 11.4mm
From leg length 7mm –> design throat thickness is 7*0.7 = 4.9mm
12) If the Visual Welding Inspector detects a type of imperfection not allowed by
the application Standard he must:
13) BS EN 970 allows the use of a magnifying glass for visual inspection but
recommends that the magnification is:
1. X2
2. X2 to X5. ( answer )
3. X5 to X10.
4. Not greater than X20.
14) The majority of welder qualification tests are carried out using unbacked
joints, because:
15) If submerged arc welding is to be used to make butt welds, which would you
be most critical of?
Thanks!!!