Академический Документы
Профессиональный Документы
Культура Документы
MACHINE
FH0H3NDNL(0~9)2
FH0G7NDNL(0~9)2
FH2G7NDNL(0~9)2
FH0G7WDNL(0~9)2 MFL67584563
FH0G6WDNL(0~9)2
FH2G6HDNL(0~9)2
P/NO : MFL67584563 Copyright © 2017 LG Electronics. All rights reserved.
Rev. No.: 00_03/03/2017
Power Plug
If the supply cord is damaged,
it must be replaced by the
manufacturer or its service agents
Drawer or a similarly qualified person in
order to avoid a hazard.
(For detergent and
fabric softener)
Control Panel
Drum
6.0kg : [FH0H3NDNL(0~9)2/FH0G7NDNL(0~9)2/FH2G7NDNL(0~9)2]
6.5kg : [FH0G7WDNL(0~9)2/FH0G6WDNL(0~9)2]
7.0kg : [FH2G6HDNL(0~9)2]
No Spin/400/600/800/1000 : [FH0H3NDNL(0~9)2/FH0G7NDNL(0~9)2/
FH0G7WDNL(0~9)2/FH0G6WDNL(0~9)2]
No Spin/400/800/1000/1200 : [FH2G7NDNL(0~9)2/FH2G6HDNL(0~9)2]
100-1000kPa (1.0-10kgf/cm 2 )
carpeted floor.
subjected
in
caused
Unpacking
Cut the straps and open the upper flaps of Packing box & take out the Anti Rat Cover.
While taking out the Machine from packing, please take due care in removing packing
support given at centre of the base packing.
Packing Support
Anti Rat Cover installation
Machine.
5
adjustable legs
It is advisable to avoid, the usage of trolley & the movement of Washing Machine after installation.
As it may disturb the levelling of washer, which can create excessive noise & vibration.
6
Centre
(1.0~10kgf/cm²)
Rubber
seal
Break
PE Bags
getting wet
getting wet
/leakage
Cotton
Do not exceed the maximum fill line.
Cotton Large
95
4.5 kg
3.0 kg
1.5 kg
3.0 kg
3.0 kg
2
- Intensive
-
1.5 kg
2
specific
[FH0H3NDNL(0~9)2/
FH0G7NDNL(0~9)2/
FH0G7WDNL(0~9)2/
FH0G6WDNL(0~9)2]
[FH2G7NDNL(0~9)2/ 2
FH2G6HDNL(0~9)2]
2
(1) (10) (6) (2) (7) (3) (4) (8) (5) (9) (11)
Press &
hold Power button for 1 sec to turn power off.
[FH0H3NDNL(0~9)2/FH0G7NDNL(0~9)2/
FH0G7WDNL(0~9)2/FH0G6WDNL(0~9)2]
Cotton Program / Main wash /
Normal Rinse / 1000 rpm / 40 0C
[FH2G7NDNL(0~9)2/FH2G6HDNL(0~9)2]
Cotton Program / Main wash /
Normal Rinse / 1200 rpm / 400C Large
By Pressing the Option Button, all Option
functions may be selected.
so that moisture present inside the
Change the washer can dry.
desired
program
1000 1200
800 1000
600 800
400 400
No Spin No Spin
Rinse Hold Rinse Hold
Spin Spin
FH0H3NDNL(0~9)2 FH2G7NDNL(0~9)2
FH0G7NDNL(0~9)2 FH2G6HDNL(0~9)2
FH0G7WDNL(0~9)2
FH0G6WDNL(0~9)2
FH0H3NDNL(0~9)2/FH0G7NDNL(0~9)2/
FH0G7WDNL(0~9)2/FH0G6WDNL(0~9)2
Cotton Large
600 - 800- 1000
Cotton Large
1000 - 1200
(i roubleshooting guide
Symptom Possible Cause Solution
Washer does not start , Electrical power cord may not Make sure plug fits tightly in wall
be plugged in or connection outlet.
may be loose.
, House fuse blown, circuit Reset circuit breaker or replace fuse.
breaker tripped,or a power Do not increase fuse capacity.
outage has occurred. If problem is a circuit overload, have
, Water supply tap is not turned it corrected by a qualified electrician.
on. Turn on water supply tap.
Washer will not spin • Check that the door is firmly Close the door and press the
shut. StarVPause button. After pressing
the StarVPause button, it may take
a few moments before the clothes
washer begins to spin. The door
must lock before spin can be achieved.
Add 1 or 2 similar items to help balance
the load.
Rearrange load to allow proper spinning
Door does not open Once machine has started, the door
can not be opened for safety reasons.
Check if the "Door Lock" icon is
illuminated. You can safely open the
door after the "Door Lock" icon
turns off.
The washing time may vary by the
Wash cycle time
amount of laundry, water
delayed
pressure, water temperature and
other usage conditions.
If the imbalance is detected or if the
suds removing program works, the
wash time shall be increased.
Fabric softner • Too much softener may cause Follow softener guidelines to ensure
overflow an overflow. appropriate amount is used.
Do not exceed the maximum fill line.
2Z
Close the door and press
Start/Pause button two times.
*Still, if is not released , call for
service.
4. This product does not contain any of the hazardous substances as specied in rule 13(1) and (2) of the e-waste
( Management and Handling ) Rules, 2011.
5.
यह उ पाद ई-अपिश ( बंधन और हथालन) िनयम 2011 के अ तगत 13(1) एवं (2) के तहत िन द खतरनाक पदाथ क आव यकता का
पालन करता है
MFL67584563