Академический Документы
Профессиональный Документы
Культура Документы
Design Conditions
Design Fluid Temperature °F 400
p Design Fluid Pressure psi. 200
S Allowable Stress for Branch pipe from Table A-1 psi. 16000
E Branch pipe Joint Quality Factor from Table A-1A or Table A-1B 1
Other Inputs
The sum of the mechanical allowances (thread or groove depth) plus corrosion and erosion allowances.
For threaded components, the nominal thread depth (dimension h of ASME B1.20.1, or equivalent) shall
c in. 0.1
apply. For machined surfaces or grooves where the tolerance is not specified, the tolerance shall be
assumed to be 0.5 mm (0.02 in.) in addition to the specified depth of the cut.
β smaller angle between axes of branch and run Degree 90
β smaller angle between axes of branch and run Radians 1.57
Weld Thickness mm 6
Tr Minimum thickness of reinforcing ring or saddle made from pipe (use nominal thickness if made from plate)
in. 0.39
= 0, if there is no saddle
Calculations
Weld Thickness in inches in. 0.24
1 of 2
12:30:12 11/25/2010
L4 Height of reinforcement zone outside of run pipe = 2.5 x (Tb-c)+Tr' in. 0.66
L4 Minimum of the above two values in. 0.45
Required Area
(b) Required Reinforcement Area.
Required Reinforcement Area, A1=th.d1.(2-sin β) sq. in. 0.23
Available Areas
(1) Area A2 is the area resulting from excess thickness in the run pipe wall:
Conclusion
Reinforcement is not required
2 of 2