Академический Документы
Профессиональный Документы
Культура Документы
OWNER’S MANUAL
● Safety messages - preceded by a safety alert symbol ! and one of three signal
words: DANGER, WARNING, or CAUTION.
Reflector
fj¶ysDVj
Battery
cSVjh
Passenger footpeg
Engine oil drain plug Gearshift pedal Footpeg Side stand
Center stand ;k=h QqViSx
batu vkW;y Mªsu Iyx fx;j f”k¶V iSM+y QqViSx lkbZM LVSaM
lsaVj LVSaM
Honda Motorcycle & Scooter India Pvt. Ltd. 9
(A)
(3)
(B)
(1) (2) Rear brake adjusting nut ¼fj;j czsd ,MtfLVax uV½
(3) Brake arm joint ¼czsd vkeZ TokbaV½
(20-30 mm) (A) Decrease free play ¼aÝh Iys ?kVk,sa½
(B) Increase free play ¼Ýh Iys c<+k,sa½
(1)
Gap
Cut out
correctly seated
(10-20 mm)
(3)
(2)
(A)
(B)
OFF
With the fuel valve in the OFF position, fuel
cannot flow from the tank to the carburetor.
Turn the valve to OFF position whenever
the vehicle is not in use. ON ON ON
RES ON OFF RES
With the fuel valve in this RES position, fuel
will flow from the reserve fuel supply to the (1) Fuel valve ¼¶;wy okYo½
carburetor. Use the reserve fuel only when
the main supply is gone. Refill the tank as Fuel Tank
soon as possible after switching to RES. The fuel tank capacity including the reserve
The reserve fuel supply is: supply is:
1.7 Ltr. (0.45 US gal , 0.37 Imp gal) 12 Ltr. (3.17 US gal , 2.63 Imp gal)
(3)
(1)
Horn Button (5)
Press the button to sound the horn. (4)
(5) (2)
(A)
(B)
(1) (A)
(B)
(C)
(2)
(1)
FRAME NO.
(2)
NOTICE
Never use a spark plug with an improper (2)
heat range. Severe engine damage could
result.
1. Disconnect the spark plug cap (1) from (1) Spark plug cap¼LikdZ Iyx dSi½
the spark plug. (2) Spark Plug wrench ¼LikdZ Iyx jsap½
2. Clean any dirt from around the spark
plug base. 4. Check the spark plug gap (3)
using a wire-type feeler gauge.
Remove the spark plug using the spark If adjustment is necessary,
plug wrench (2) furnished in the tool kit. bend the side electrode (4) carefully.
3.
Inspect the electrodes and center The gap should be:
porcelain for deposits, erosion or
0.8-0.9 mm(0.03-0.04 in)
carbon fouling. If the erosion or deposit
is heavy, replace the plug. Clean a 5. With the plug washer attached, the
wetfouled plug with a plug cleaner, spark plug in by hand to prevent
cross-threading.
otherwise use a wire brush.
Honda Motorcycle & Scooter India Pvt. Ltd. 51
IDLE SPEED
(3) Spark plug gap ¼LikdZ Iyx xSi½ Refer to the Safety Precautions on page 42.
(4) Side electrode ¼lkbM bysDVªksM½ The engine must be at normal operating
temperature for accurate idle speed
6. Tighten the spark plug as follows:
adjustment. 10 minutes of stop-and-go
• Install the old plug if it is in good condition riding is sufficient.
and tighten it 1/8 turn after it seats.
Do not attempt to compensate for faults in
• If installing a new plug, tighten it twice other systems by adjusting idle speed. See
to prevent loosening:
your Honda dealer for regularly scheduled
a) Tighten the plug 1/2 turn after it carburetor adjustments.
seats.
1. Warm up the engine, and shift to
b) Loosen the plug. neutral, and place the vehicle on its
c) Tighten the plug again 1/8 turn center stand.
after it seats.
(1)
(1) (2)
(1)
Normal sprocket Teeth
(1) Drive chain ¼Mªkbo psu½ ¼lkekU; LizkWdsV VhFk½
Good
3. Rotate the rear wheel slightly and then ¼lgh½
stop to check the drive chain slackness If the drive chain or sprockets are
again. Repeat this procedure several excessively worn or damaged, they should
times at different positions. Drive chain be replaced. Never use a new chain with
slack should remain constant. If the worn sprockets; rapid chain wear will result.
chain is slack only in certain sections,
some links are kinked and binding,
kinking can be eliminated by lubrication.
(1)
(2)
(1) Chain slider ¼pSu LykbMj½
(2) Wear limit cutout ¼fo;j fyfeV dVvkmV½
60 Honda Motorcycle & Scooter India Pvt. Ltd.
(6)
(1)
(2) (5)
(4)
(2)
(3)
(1)
(3)
(2)
(5)
Blown Fuse
Fuse Box:
The fuse box (1) is located behind the left
side cover. (1) Fuse box ¼¶;wt ckWDl½
The specified fuse is: (2) Fuse box cover ¼¶;wt ckWDl doj½
15A & 5A (3) Spare fuse ¼Lis;j ¶;wt½
Honda Motorcycle & Scooter India Pvt. Ltd. 69
(2)
(1)
(2)
(1)
(4)
(A) (B)
(3)
(1) Main fuse ¼esu ¶;wt½
(2) Wire connector ¼ok;j dusDVj½
(3) Starter magnetic switch ¼LVkVZj eSxusfVd fLop½ (1) Stoplight switch ¼LVkWiykbV fLop½
(4) Spare main fuse ¼Lis;j esu ¶;wt½ (2) Adjusting nut ¼,MtfLVax uV½
70 Honda Motorcycle & Scooter India Pvt. Ltd.
(2)
(1)
(2)
(1) Licence plate light cover ¼ykblSal IysV ykbV doj½ (1) Turn signal lens ¼VuZ flXuy ysal½
(2) Screws ¼LØwl½ (2) Screw ¼LØw½
(3) Bulb ¼cYc½ (3) Bulb ¼cYc½
WEIGHT
Dry weight STD Model 128 kg (282.2 lbs)
CBS Model 130 kg (286.6 lbs)
CAPACITIES
Engine oil After draining 1.0 L (1.0 US qt, 0.9 lmp qt)
After disassembly 1.2 L (1.3 US qt, 1.1 lmp qt)
Fuel tank 12.0 L (3.17 US gal, 2.63 lmp gal)
Fuel tank reserve 1.7 L (0.45 US gal, 0.37 lmp gal)
Passenger capacity Operator and one passenger
Maximum weight capacity 170 Kg (374.7 lbs)
LIGHTS
Head light 12V-35/35W
Position light 12V-5W x 2
Stop/tail light LED
License plate lamp 12V-5W
Turn signal light 12V-10W x 4
Instrument lights LED
Neutral indicator LED
Turn signal indicator LED
High beam indicator LED
Fuse
Main fuse 20A
Sub fuse 15A
Sub fuse 5A
Where a defective part can replaced by part/s of alternative brand/s, which are normally
used by HMSI in the course of manufacturing, HMSI reserves the right to carry out the
replacement by a part or parts of any such alternative brands.
This warranty and any claim arising there from is subject to Gurgaon jurisdiction only.
No claim for exchange or repair can be consider unless the customer:
a.
Ensures that immediately upon Further this warranty is not applicable to:
discovery of the defect, he approaches 1. Any “CB Hornet” on which any free and
any nearest authorised dealer of HMSI paid services has not been carried
with the concerned vehicle and enables out, as per schedule given in Owner’s
him to remove and dispatch the part/ Manual.
parts attributing to manufacturing
defect to the company. 2. Normal maintenance operations like
valve adjustment, cleaning of fuel
b. Produces Owner’s Manual in original, to system, engine tune-up or such other
enable that dealer to verify the details. adjustments.
It must be expressly understood that
claims forwarded directly to us by the 3. HMSI does not warrant normal wear
Owner/customer will not be entertained and tear items like brake pad, brake
at all and such defective part/parts thus shoes, Clutch Disc, Chain, Chain
forwarded by them will lie at our factory Sprocket, Wheel Rim (in case of
at their own risk, and this warranty shall misalignment and bent), Bushes,
not be enforceable. Fasteners, Shims, Washers and
Electrical Items like Bulbs(LEDs are
covered under warranty), Rubber and
84 Honda Motorcycle & Scooter India Pvt. Ltd.