Академический Документы
Профессиональный Документы
Культура Документы
The machines with the Processor Control PCB (J390878-01) may detect the power supply frequency as 60 Hz by
mistake even in the 50 Hz areas. So, we will release the patch software to improve the accuracy of detecting the
frequency. When this detection failure occurs, the replenishment amount and water supply (only SM specification) will
decrease to five sixth of each amount.
The possibility this problem occurs in the “J380878-00” of the Processor Control PCB and the Processor PCB used in
QSS-28 to 31 is very rare and we will not release the patch software for them.
Moreover, this problem is not applied to the 60 Hz areas and the patch software is unnecessary in the areas.
The machines (serial numbers) this modification is necessary are listed in another file.
Refer to another file.
Permanent countermeasure
We will modify this problem in the next software version.
1/3
How to install the patch software to modify the misdetection of frequency (50/60 Hz)
in QSS-32 and QSS-33 processors:
The system version of QSS main body needs to be the following one to install this patch software.
Before installing this software, verify the system version of QSS main body.
* 1 The patch software for Ver. 2.00 of QSS-33xx or QSS-33xx PRO is different from the one
for 3.00. So, be sure to confirm the version name in the label on the floppy disk
before installing.
8. Verify each pump output amount of replenishment pump and water supply (only in SM specification).
9. End
3/3