Академический Документы
Профессиональный Документы
Культура Документы
Pack
Base: R580-2058
Activator: R290-2081
USAGE Dulux Epoxy Holding Primer Two Pack is a two part primer for airless or
conventional spray application to blast cleaned steel at works or after
fabrication.It is suitable for use as an economical primer over blast cleaned
surfaces limited periods, prior to the application of the full protective
coating system
PACK SIZE 2.5 Litre unit comprising Base : 1.7 Litre and Activator : 0.8 Litre
COLOUR RANGE Red only
FILM PROPERTIES Chemical Resistance: Resistant against splashes and spillage of common
acids, alkalis, solvents and salt solutions
Water Resistance: Excellent
Heat Resistance: Can be used on heated surfaces above 120°C
COMPOSITION Pigment: Red Oxide
Binder: Polyamide Cured Epoxy
Solvent: Aromatic Hydrocarbon and Glycol Ethers
VOLUME SOLIDS 41-42% (nominal)
POT LIFE Up to 8 hours at 30°C
DRYING TIMES Single coat at standard thickness:
TOUCH DRY
RECOAT DRY
2-PACK PRODUCTS
CURING TIMES
RECOAT AT 30°C 3 hours minimum
FULL CURE 2 days
Please note that the reaction of epoxies commences immediately after the
two components are mixed. This reaction is temperatures related and so
the curing time will be approximately halved by 10°C increase in
temperature and doubled by a 10°C decrease in temperature
FILM THICKNESS Wet: 45-60 micro-metres
Dry: 18-25 micro-metres
THEORETICAL Practical coverage under normal conditions is 14-20 m²/litre
SPREADING
APPLICATION METHOD
MIXING RATIO 7 Parts Base to 3 part of Activator by volume
THINNING
Conventional spray: Satisfactory through most equipment (10%)
Airless Spray: Ready for use
SPRAY It is important that Base and Activator are at a minimum temperature of
RECOMMENDATION 15°C when mixed for satisfactory spray application
Airless Spray: A typical recommendation for airless spray application is a
minimum working pressure on paint of 140 Kg/cm² (2000 lb/sq. in) with a
spray tip size 0.45-0.53mm (18-21 thou) at an angle of 60-80°
CLEANING UP Clean all equipment with Dulux Thinner 850-761 or 850-1015 immediately
after use
SURFACE PREPARATION For optimum performance blast clean bare steel or surfaces in poor
condition to BS 7079 Part A1 :1989 Sa.2.5 to give an appropriate surface
profile
FLASH POINT Base and Activator 22°C
Dulux Epoxy Holding Primer Two
Pack
Base: R580-2058
Activator: R290-2081
Any advice, recommendations, information, assistance or service provided by ICI Paints in relation to goods manufactured or marketed by it
or their use or any application is given in good faith. However, any advice, recommendations, information, assistance or service provided
by ICI Paints is provided without expressed or implied warranties.
30 Apr 2002