Академический Документы
Профессиональный Документы
Культура Документы
P30304-E0731-K170-1-7617
The information in this document is subject to change without notice and describes only the
product defined in the introduction of this documentation. This documentation is intended for the
use of Nokia Siemens Networks customers only for the purposes of the agreement under which
the document is submitted, and no part of it may be used, reproduced, modified or transmitted
in any form or means without the prior written permission of Nokia Siemens Networks. The
documentation has been prepared to be used by professional and properly trained personnel,
and the customer assumes full responsibility when using it. Nokia Siemens Networks welcomes
customer comments as part of the process of continuous development and improvement of the
documentation.
The information or statements given in this documentation concerning the suitability, capacity,
or performance of the mentioned hardware or software products are given “as is” and all liability
arising in connection with such hardware or software products shall be defined conclusively and
finally in a separate agreement between Nokia Siemens Networks and the customer. However,
Nokia Siemens Networks has made all reasonable efforts to ensure that the instructions
contained in the document are adequate and free of material errors and omissions. Nokia
Siemens Networks will, if deemed necessary by Nokia Siemens Networks, explain issues which
may not be covered by the document.
Nokia Siemens Networks will correct errors in this documentation as soon as possible. IN NO
EVENT WILL NOKIA SIEMENS NETWORKS BE LIABLE FOR ERRORS IN THIS
DOCUMENTATION OR FOR ANY DAMAGES, INCLUDING BUT NOT LIMITED TO SPECIAL,
DIRECT, INDIRECT, INCIDENTAL OR CONSEQUENTIAL OR ANY LOSSES, SUCH AS BUT
NOT LIMITED TO LOSS OF PROFIT, REVENUE, BUSINESS INTERRUPTION, BUSINESS
OPPORTUNITY OR DATA,THAT MAY ARISE FROM THE USE OF THIS DOCUMENT OR
THE INFORMATION IN IT.
This documentation and the product it describes are considered protected by copyrights and
other intellectual property rights according to the applicable laws.
The wave logo is a trademark of Nokia Siemens Networks Oy. Nokia is a registered trademark
of Nokia Corporation. Siemens is a registered trademark of Siemens AG.
Other product names mentioned in this document may be trademarks of their respective
owners, and they are mentioned for identification purposes only.
Copyright © Nokia Siemens Networks 2009. All rights reserved.
2 P30304-E0731-K170-1-7617
Description of Output Data Trunk Group Measurement Data
Table of Contents
0 General Information 4
0.1 Glossary and Abbreviations...............................................................................4
0.2 Keyword/Descriptor ............................................................................................5
0.3 List of Figures and Tables ..................................................................................5
1 Introduction 6
1.1 Delimitation..........................................................................................................6
5 Field Description 18
5.1 Counter overview .............................................................................................. 18
5.2 Common REC TGRP Data................................................................................. 21
5.3 Data dependent of the index ............................................................................ 22
6 Operating Instructions 32
6.1 File Sizes ............................................................................................................ 32
7 Examples 33
P30304-E0731-K170-1-7617 3
Trunk Group Measurement Data Description of Output Data
0 General Information
4 P30304-E0731-K170-1-7617
Description of Output Data Trunk Group Measurement Data
0.2 Keyword/Descriptor
File Description
Postprocessing
Traffic Measurement
Traffic Data Recording
Traffic Data Administration
Recording of TGRP Traffic Measurement Data
REC TGRP
P30304-E0731-K170-1-7617 5
Trunk Group Measurement Data Description of Output Data
1 Introduction
This file description shall be used as basic information for the design of postprocessing tools for
the traffic measurement files of the traffic data recording functions.
Table 1: Measurement
1.1 Delimitation
In this document the specifications for recording of the traffic data are only described for REC
TGRP measurements. The general processes and conditions to process the data, collected by
traffic measurement (header records, common parts), are described in Error! Reference
source not found..
6 P30304-E0731-K170-1-7617
Description of Output Data Trunk Group Measurement Data
P30304-E0731-K170-1-7617 7
Trunk Group Measurement Data Description of Output Data
Subsystem TS
Measurement Variant Version Remarks
REC TGRP A3 50 Version number 50 remains unchanged for hiQ 9200
V6. There are no newly defined output fields. Only the
interpretation of the field ‘OPMODE/TGRPTYP’ has
changed in case of values ‘K’ and ‘L’ (see 3.4
Measurement specific hints).
If in a measurement order several objects are recorded, its number will remain constant. After
deletion of a recorded object, default values are output for this object.
In case of measurement of all trunk groups, a data output will be done for each trunk group
which is created, provided that its data are available at the moment of data reading.
Further general description of the data records see Error! Reference source not found..
8 P30304-E0731-K170-1-7617
Description of Output Data Trunk Group Measurement Data
3.3.2 Availability
IC - incoming
OG - outgoing
BW - bothway
To each trunk group a trunk group type is assigned, REC TGRP uses following values:
For data output control (quantity of the data) an additional trunk group sign is used. This sign
shows specific properties of the trunk group. See ‘Identifier’ in Table 10: Counter overview and
counter provision part 1 and Table 11: Counter overview and counter provision part 2 in chapter
5.1, Counter overview.
Example: NH for a NH-specific TGRP or CCS7 for a TGRP with CCS7-Signalling.
The data structures for trunk groups are prepared for trunk groups with opmode bothway. Data
fields which are not used for the current opmode, trunk group type or trunk group sign remain
unused, filled with spaces.
P30304-E0731-K170-1-7617 9
Trunk Group Measurement Data Description of Output Data
The traffic counters for RSU-specific Interface- (IF) respectively Sidedoor- (SD) trunk groups are
not distinguished between incoming (IC) and outgoing (OG) traffic. The counters for outgoing
(OG) traffic contain the total incoming and outgoing traffic; the counters for incoming traffic
remain unused with default values.
All counters corresponding to their opmode (IC or BW) for bearer independent signaling (BIS )
trunk groups, Media Gateway Controller (MGC/BICC/ISUP+), Session Initiation Protocol (SIP)
or SIP for Telephones (SIP-T) TGRPs are output. There is no special handling for these trunk
group types.
Subsystem TS
Measurement REC- Max. number of objects
incarna- per data per to be in the
tions record (1) task recorded system
REC TGRP (1) 8 3...28 4095 4095 4095
(1) With selection by the FORMAT-parameter as well as project or trunk group type specific, it
is possible that only a part of the counters will be filled into a data record. So the number of
trunk groups in a data record is variable.
It is possible that more than one data record will be written. The maximum size of a record after
reformatting for postprocessing is 2044 Bytes. All data parts for a trunk group are written in the
same data record.
Example:
An order (REC TGRP) is started to record 10 trunk groups (measurement objects), it is not
possible to make an output with a single data record for all trunk groups. So 3 data records will
be output every 15 minutes, the first and the second record contain 4 trunk groups each, the
third record contains 2 trunk groups.
10 P30304-E0731-K170-1-7617
Description of Output Data Trunk Group Measurement Data
P30304-E0731-K170-1-7617 11
Trunk Group Measurement Data Description of Output Data
By modification of the trunk group data (e.g. operation mode, trunk group sign, trunk group type)
during active traffic measurement, the number of the data segments written on MDD can
change at any time. This affects the file size calculation as well as the used space of the current
measurement file which must be extended dynamically.
12 P30304-E0731-K170-1-7617
Description of Output Data Trunk Group Measurement Data
P30304-E0731-K170-1-7617 13
Trunk Group Measurement Data Description of Output Data
14 P30304-E0731-K170-1-7617
Description of Output Data Trunk Group Measurement Data
P30304-E0731-K170-1-7617 15
Trunk Group Measurement Data Description of Output Data
16 P30304-E0731-K170-1-7617
Description of Output Data Trunk Group Measurement Data
P30304-E0731-K170-1-7617 17
Trunk Group Measurement Data Description of Output Data
5 Field Description
Ind - Counter blocks (Data control index which applies to the counter):
Data output is restricted to selective counter blocks corresponding to the entered FORMAT
parameter values with command REC TGRP. Assignment see: Table 9: Assignment of
FORMAT parameter values to counter blocks.
FORMAT = Assignment
No input all counters
ALL all counters
COMLONG all counter of Ind = 1 and Ind = 2
COMSHORT Counter package (see Identifier SEL)
(Part of the counter of Ind = 1 and Ind = 2)
UNSUCC all counter of Ind = 3 and Ind = 4
CCS7 all counter of Ind = 5
NH all counter of Ind = 6 and Ind = 7
MLPP all counter of Ind = 8
Combination of the values result in the total sum of the selected counters, e.g.
COMLONG and COMSHORT are all counters of Ind=1 and Ind=2 (equal with
COMLONG).
Table 9: Assignment of FORMAT parameter values to counter blocks
18 P30304-E0731-K170-1-7617
Description of Output Data Trunk Group Measurement Data
P30304-E0731-K170-1-7617 19
Trunk Group Measurement Data Description of Output Data
20 P30304-E0731-K170-1-7617
Description of Output Data Trunk Group Measurement Data
P30304-E0731-K170-1-7617 21
Trunk Group Measurement Data Description of Output Data
22 P30304-E0731-K170-1-7617
Description of Output Data Trunk Group Measurement Data
P30304-E0731-K170-1-7617 23
Trunk Group Measurement Data Description of Output Data
24 P30304-E0731-K170-1-7617
Description of Output Data Trunk Group Measurement Data
P30304-E0731-K170-1-7617 25
Trunk Group Measurement Data Description of Output Data
26 P30304-E0731-K170-1-7617
Description of Output Data Trunk Group Measurement Data
P30304-E0731-K170-1-7617 27
Trunk Group Measurement Data Description of Output Data
28 P30304-E0731-K170-1-7617
Description of Output Data Trunk Group Measurement Data
P30304-E0731-K170-1-7617 29
Trunk Group Measurement Data Description of Output Data
30 P30304-E0731-K170-1-7617
Description of Output Data Trunk Group Measurement Data
P30304-E0731-K170-1-7617 31
Trunk Group Measurement Data Description of Output Data
6 Operating Instructions
Measurement ranges:
(1) 10 measurement objects, 1 hour
(2) 1 measurement object, 1 day
(3) 10 measurement objects, 1 day
Common file size calculation see Error! Reference source not found..
32 P30304-E0731-K170-1-7617
Description of Output Data Trunk Group Measurement Data
7 Examples
None
P30304-E0731-K170-1-7617 33