Академический Документы
Профессиональный Документы
Культура Документы
47.In acoustics, what is the term given to minimum sound pressure level that is
capable of evoking auditory sensation?
a. Threshold of Pain
b. Threshold of Speech
c. Threshold of Audibility
d. Threshold of Feeling
48.. A component part of an escalator that gives the unit its motive power.
a. Sprocket assembly
b. Driving machine
c. Step assembly
d. Controller
49.As per code (NBC) provision, what is the minimum width balustrade of an
escalator?
a. 550 mm
b. 540 mm
c. 640 mm
d. 558 mm
50.What is the recommended rated speed of a escalator, measured along its angle
of inclination?
a. 38 mpm
b. 28 mpm
c. 45 mpm
d. 33 mpm
51.Minimum water delivery in liters per minute for an outlet of a wet standpipe at a
residual pressure equivalent to 1.8 kilos per sq. mtrs.
a. 132 liters per minute
b. 112 liters per minute
c. 155 liters per minute
d. 126 liters per minute
52.A rule of thumb in sizing an individual vent pipe
AraCampReview_2017 In God We Trust
Riyadh Kingdom Of Saudi Arabia “To God Be All The Glory”
Ar. Warloff Paloma UAP
a. Vent pipe size is at least 1/2 the fixture unit but not less than the required
minimum whichever is the larger
b. Vent pipe size is at least 1/2 the drain it serves but not less than the required
minimum whichever is larger
c. Vent pipe size is at least equal the branch or trap diameter it serves whichever
is smaller but not less than the required minimum whichever is larger
d. Vent pipe size is at least 1/2 the developed length of the stack it vents but not
less than the required minimum whichever is larger
53.In air conditioning system, that part in which refrigerant is vaporized, thereby
taking up external heat and producing cooling effect.
a. Compressor
b. Condenser
c. Evaporator
d. Chiller
54.A part of an elevator that are fastened to car frame and counterweight at top
and bottom; it is used on guide rails.
a. Guide shoes
b. Compensator
c. Safety switch
d. Car leveling device
55.A system of illumination designed to give uniform and generally, though not
necessarily diffuse lighting throughout the area under consideration.
a. General Lighting
b. Local Lighting
c. Combined general and local lighting
d. Supplementary lighting
56.Which of the following is NOT a type of High Intensity Discharge (HID) Lamp?
a. Mercury lamp
b. Metal halide (MH) lamp
c. High pressure sodium (HPS) lamp
d. Incandescent lamp
57.The term electrical raceway applies to ____________.
a. a channel system in carrying electric wires and cables
b. where electric cars pass
c. conductor of heavy load energy
d. a group of transformers
58.A term used in acoustics used to establish loudness level.
a. Phon
b. Decibels
c. Hertz
AraCampReview_2017 In God We Trust
Riyadh Kingdom Of Saudi Arabia “To God Be All The Glory”
Ar. Warloff Paloma UAP
d. Sabins
59.Which of the following raceway wiring methods has wall thickness lesser than
that of a rigid metal conduit and generally used for both exposed and concealed
work?
a. Intermediate Metal Conduit (IMC)
b. Electrical Metal Tubing (EMT)
c. Flexible Metallic Tubing (FMT)
d. Rigid Non-metallic Conduit (RNMC)
60.How many drinking fountains may be provided for a place of assembly with an
occupant load of 450 persons?
a. 3
b. 4
c. 5
d. 6
61.The abbreviation PABX, a private telephone system serving one or group of
buildings means _____________.
a. Public Address and Building Exchange
b. Phone Activated Branch Exchange
c. Private Automatic Branch Exchange
d. Public Address and Building Utility System
62.What is the type letter for an insulated conductor with a trade name Heat
Resistant Thermoplastic?
a. THHN
b. THW
c. THWN
d. TW
63.Which of the following plumbing traps is considered permissible?
a. Bag Trap
b. P-Trap
c. Bell Trap
d. Metal Partition Trap
64.A type of venting system which function both as a fixture drain and a vent.
a. Individual Vent
b. Dry Vent
c. Wet Vent
d. Looped Vent
65.What is the recommended color code for a pipeline containing oil (discharge)?
a. Buff
b. White
c. Blue
AraCampReview_2017 In God We Trust
Riyadh Kingdom Of Saudi Arabia “To God Be All The Glory”
Ar. Warloff Paloma UAP
d. Yellow
66.Which of the following does not qualify the definition for a dumbwaiter?
a. 1.20 m
b. 277 kgs.
c. 3861 sq. mm
d. used exclusively for carrying materials
67.For cooling, it is the ratio of the rate of heat removed to the rate of energy
input. What is the term?
a. AFUE (Annual Fuel Utilization Efficiency)
b. COP (Coefficient of Performance)
c. EER (Energy Efficiency Ratio)
d. IPLV (Integrated Part Load Value)
68.Which of the following is a type of refrigerant used in chillers for large
installation; it contains a synthetic chemical known as
trichloromonofluoromethane.
a. R 11
b. R12
c. R 22
d. R 114
69.The average time spent by passengers in the lobby to leaving the car at an upper
floor is known as _____________.
a. ALWT (Average Lobby Waiting Time)
b. RTT (Round Trip Time)
c. ATT (Average Trip Time)
d. LDT (Lobby Dispatch Time)
70.A source of electricity that can be obtained by mechanical pressure of certain
crystals such as quartz and Rochelle salts.
a. Photoelectric effect
b. Chemical source
c. Piezoelectric effect
d. Thermoelectric effect
71.Which of the following fixtures is usually provided with pop-up waste?
a. watercloset
b. bathtub
c. urinal
d. floor drain
72.Which of the following types of joint is used on copper pipes?
a. flared joint
b. screwed joint
c. soldered joint
AraCampReview_2017 In God We Trust
Riyadh Kingdom Of Saudi Arabia “To God Be All The Glory”
Ar. Warloff Paloma UAP
d. both a and c
73.In lighting design and calculation, which of the following is/ are essential factors
used when using Zonal Cavity Method?
a. Room Cavity Ratio (RCR)
b. Footcandle value
c. Coefficient of Utilization (CU)
d. All of these
74.When controlling a lamp or group of lamps in four different locations
independently, the following switch combination shall be used. What is it?
a. 2- S3w and 2- S4w
b. 4- S4w
c. 2- S3w and 3- S4w
d. 1- S3w and 3- S4w
75.The resistance of metallic conductors when used in power transmission is
affected by ___________.
a. length
b. cross sectional area
c. material composition
d. all of these
76.What class of insulation consists of mica, asbestos or fiberglass, all with binders?
a. Class A
b. Class B
c. Class C
d. Class O
77.As a safety precaution, a window type AC shall be installed at not less than
_____ from the floor at ground floor level and along corridors and hallways.
a. 2.0 m
b. 1.8 m
c. 2.13 m
d. 2.10 m
78.Which statement violates the mechanical rule provision in the design,
installation and maintenance of an escalator?
a. Installation angle of an escalator shall be more than 30º.
b. The rated speed shall be more than 38 mpm.
c. a only
d. both a and b
79.A type of intrusion detection system where the principle of beam interruption is
employed. Interruption of beam causes the contact to open thereby setting off
the alarm.
a. Photoelectric detector
AraCampReview_2017 In God We Trust
Riyadh Kingdom Of Saudi Arabia “To God Be All The Glory”
Ar. Warloff Paloma UAP
b. Mechanical motion detector
c. Passive infrared detector
d. Acoustic detector
80.Fiber optics is used in installations with very heavy data transmission loads.
Which characteristic/ s is/ are provided by fiber optics make it desirable and
practical?
a. High security
b. Low noise
c. Broad bandwidth
d. All of these
81.In calculating sound absorption, an open window free from obstructions and
having a length of 3 feet and a height of 4 feet has a sound absorption value of
________.
a. 3 sabins
b. 7 sabins
c. 12 sabins
d. 16 sabins
82.Is a component including its attachments having fundamental period greater
than 0.60 sec. (NSCP 208.20)
a. Braced frame c. bearing wall system
b. Rigid Component d. Flexible component
83.Concrete filled driven piles of uniform section shall have a nominal outside
diameter of not less than (NSCP 307.7.3)
a. 200 b. 250 c. 300 d. 350
84.A complete record of test of materials and of concrete shall be available for
inspection during the progress of work and _______ years after completion of
the project and shall be preserved by the inspecting engineer or architect for
that purpose, (NSCP 403.20)
a. 2 yrs. b. 5 yrs. c. 10 yrs. d. 15 yrs
85.The minimum bend diameter for 10mm Ø through 25mm Ø bars (NSCP 407.30)
a. 12 db b. 6 db c. 8 db d. 10 db
86.The minimum clear spacing between parallel bars in a layer must be db but not
less than? (NSCP 407.7.3)
a. 50 mm b. 25 mm c. 75 mm d. 100 mm
87.In spirally reinforced or tied reinforced compression members, clear distance
between longitudinal bars shall not be less than?
(NSCP 407.7.3)
a. 2.0 db b. 2.15 db c. 1.50 mm d. 1.75 mm