Академический Документы
Профессиональный Документы
Культура Документы
Can you notice any drywall tape joints? (examine Check if the floor grout is properly sealed.
both with the lights on and in natural light). Is there any damage to the tiles (eg. cracks)?
Are the holes for lighting and ventilation being Has the wall base been attached correctly?
made properly? Can you spot any cracks between the wall and the
Are there any cracks in the ceiling? Check also the base? Between the flooring and the base?
skylight corners. Can you notice any damage to flooring due to
Is the sealing of skylights completed? construction work?
Is the attic easily accessible? Check also if it has Are transition strips visible in the places where
been insulated correctly. distinct flooring types meet?
Are smoke detectors properly installed? Are they
working as they should? Mechanical
Do the exhaust fans work?
Walls Examine if the microwave exhaust is placed
Can you notice any visible tape joints which are properly?
missing paint or are not properly sanded? Check if the registers and diffusers are fully-
Can you spot any cracks on the door and/or functional.
windows? Check at the corners. Do you notice any problems with the installation of
Is there any screw heads burst through the gypsum the thermostat(s)?
board? Are the furnace filters clean?
Are there any nail heads burst in wood framing? Check if the ductwork is properly sealed and
Is the painting completed? insulated. Has the contractor cleaned it after the
Are there any crushed corners, gouges or dings? end of his/her work?
Do you notice any cracked wall tiles? Is there any noise, vibration or rattling when
Is wall covering secure at corners and wall ends? furnace and AC work?
Are the appliances fully-functional?
Doors and windows Is the range hood ready for use?
Are there any scratches, dents or buckling on the
frames? Plumbing
Do the doors close and open smoothly? Check if the dryer vent is fully functional.
Check the self-closing doors. Do they lock properly? Are the plumbing fixtures sealed and shred
Are all exterior doors weatherstripped? correctly?
Check if sweeps are placed at the exterior doors. If there is a garbage disposer, does it work?
Check if the doors can lock and close properly. Can you notice any problems with the shut-off
Do door hinges miss any screws? valves? Are they properly installed wherever there
Is door threshold properly placed and sealed in is a water connection (eg. bathroom, kitchen)?
order to avert water invasion? Is plumbing in the walls easily reachable?
Can you spot any gaps between the wall and the Do the faucets work as they should?
door frame? Does the toilet flush as it is supposed to?
Can you open and close the windows without any Do you notice any malfunctions with the water
problems? Do they lock easily? heater?
Check if all door stops are properly installed. Check if traps and backflow preventers are installed
Do you notice any damage to the glass panes? Is in the drain.
there any moisture between them?
Are the doors undercut in order to allow air Electrical
movement? Check if all the phone jacks in the place work.
Are all cover plates installed?
Cabinets Is the installation of ceiling fans in the future
Can you notice any exposed screw ends at the back possible?
of your cabinets? Is a wall switch for ceiling fans installed?
What about inside your cabinets? Check closely if the circuits have been labeled
Can you close and open the cabinet doors without correctly.
any problems? Do you notice any malfunction at the garage door?
Are the screws in cabinet hinges places properly? Are cable jacks installed in the different rooms?
Is the molding properly installed? Is it nailed or Check if the irrigation clock is working properly.
glued? Find out where the breaker panel is placed.
Check the quality of close rods installation. Are they
installed as they should?
Counters
Is the sink sealed properly to the countertop?
Can you notice any gaps at countertop corners?
Is the backsplash properly shuttered?
Flooring
Can you notice any shred ends on the carpet?
Check the flooring transition. Is everything put
correctly?