Академический Документы
Профессиональный Документы
Культура Документы
IGT 50 mA
G1
Description ISOTOP
Packaged in ISOTOP modules, the MSS40 /
MSS50 Series is based on two back-to-back SCR
configurations, providing high noise immunity.
They are suitable for high power applications such
as solid state relays, heating control systems, Table 2. Order codes
welding equipment, motor control circuits... Part numbers Marking
The compactness of the ISOTOP package allows MSS40-1200 MSS40-1200
high power density and optimized power bus
connections. Thanks to their internal ceramic pad, MSS50-800 MSS50-800
they provide high voltage insulation (2500 VRMS), MSS50-1200 MSS50-1200
complying with UL standards (File ref: E81734).
G1
4 3
1: Thyristor 2 Anode (A2)
2: Thyristor 2 Gate (G2) A1 A2
3: Thyristor 1 Anode (A1)
4: Thyristor 2 Gate (G1) 1 2
G2
1 Characteristics
MSS40 0.6
Rth(j-c) Junction to case (AC) ° C/W
MSS50 0.45
2/7
MSS40, MSS50 Characteristics
P(W) IT(RMS)(A)
100 80
MSS50 α = 180°
90 α = 180°
70
80
60 MSS40
70 MSS50
MSS40 50
60
50 40
40 30
30
180° 20
20 α
α 10
10
IT(RMS)(A) Tcase(°C)
0 0
0 10 20 30 40 50 60 70 80 0 25 50 75 100 125 150
2.0
0.5
1.5
IGT
1.0 IH & IL
0.2
0.5
tp(s) Tj(°C)
0.1 0.0
1E-3 1E-2 1E-1 1E+0 1E+1 -40 -20 0 20 40 60 80 100 120 140 160
Figure 6. Surge peak on-state current versus Figure 7. Non-repetitive surge peak on-state
number of cycles current for a sinusoidal pulse with
width tp < 10 ms, and
corresponding values of I2t
ITSM(A) 2
ITSM(A), I t (A s)
2
700
5000
MSS50 Tj initial = 25°C
600 ITSM
MSS50
t=20ms
3/7
Ordering information scheme MSS40, MSS50
ITM(A) ITM(A)
500 1000
Tj max.: Tj max.:
Vt0=0.85V Vt0=0.85V
Rd=11mΩ Rd=7mΩ
100
Tj=max
Tj=max 100
Tj=25°C
Tj=25°C
VTM(V) VTM(V)
10 10
0.0 0.5 1.0 1.5 2.0 2.5 3.0 3.5 4.0 4.5 5.0 5.5 6.0 0.0 1.0 2.0 3.0 4.0 5.0 6.0
MSS 40 - 800
4/7
MSS40, MSS50 Package information
3 Package information
5/7
Ordering information MSS40, MSS50
4 Ordering information
MSS40-1200 MSS40-1200
27 g 10
MSS50-800 MSS50-800 ISOTOP Tube
(without screws) (with screws)
MSS50-1200 MSS50-1200
5 Revision history
6/7
MSS40, MSS50
Information in this document is provided solely in connection with ST products. STMicroelectronics NV and its subsidiaries (“ST”) reserve the
right to make changes, corrections, modifications or improvements, to this document, and the products and services described herein at any
time, without notice.
All ST products are sold pursuant to ST’s terms and conditions of sale.
Purchasers are solely responsible for the choice, selection and use of the ST products and services described herein, and ST assumes no
liability whatsoever relating to the choice, selection or use of the ST products and services described herein.
No license, express or implied, by estoppel or otherwise, to any intellectual property rights is granted under this document. If any part of this
document refers to any third party products or services it shall not be deemed a license grant by ST for the use of such third party products
or services, or any intellectual property contained therein or considered as a warranty covering the use in any manner whatsoever of such
third party products or services or any intellectual property contained therein.
UNLESS OTHERWISE SET FORTH IN ST’S TERMS AND CONDITIONS OF SALE ST DISCLAIMS ANY EXPRESS OR IMPLIED
WARRANTY WITH RESPECT TO THE USE AND/OR SALE OF ST PRODUCTS INCLUDING WITHOUT LIMITATION IMPLIED
WARRANTIES OF MERCHANTABILITY, FITNESS FOR A PARTICULAR PURPOSE (AND THEIR EQUIVALENTS UNDER THE LAWS
OF ANY JURISDICTION), OR INFRINGEMENT OF ANY PATENT, COPYRIGHT OR OTHER INTELLECTUAL PROPERTY RIGHT.
UNLESS EXPRESSLY APPROVED IN WRITING BY AN AUTHORIZED ST REPRESENTATIVE, ST PRODUCTS ARE NOT
RECOMMENDED, AUTHORIZED OR WARRANTED FOR USE IN MILITARY, AIR CRAFT, SPACE, LIFE SAVING, OR LIFE SUSTAINING
APPLICATIONS, NOR IN PRODUCTS OR SYSTEMS WHERE FAILURE OR MALFUNCTION MAY RESULT IN PERSONAL INJURY,
DEATH, OR SEVERE PROPERTY OR ENVIRONMENTAL DAMAGE. ST PRODUCTS WHICH ARE NOT SPECIFIED AS "AUTOMOTIVE
GRADE" MAY ONLY BE USED IN AUTOMOTIVE APPLICATIONS AT USER’S OWN RISK.
Resale of ST products with provisions different from the statements and/or technical features set forth in this document shall immediately void
any warranty granted by ST for the ST product or service described herein and shall not create or extend in any manner whatsoever, any
liability of ST.
Information in this document supersedes and replaces all information previously supplied.
The ST logo is a registered trademark of STMicroelectronics. All other names are the property of their respective owners.
7/7